Thermostat: Testing and Inspection
Thermostat TestA new thermostat should be installed only after this test has been carried out.
Thermostat-Mechanical Test
1. Remove the thermostat.
2. Check the thermostat for seating. Hold the thermostat up to a lighted background. Leakage of light around the thermostat valve at room temperature indicates that a new thermostat should be installed. Some thermostats have a small leakage notch at one location on the perimeter of the thermostat valve, which is considered normal.
3. Immerse the thermostat in a boiling antifreeze and water mixture.
4. See Specifications for thermostat opening temperatures.
Thermostat-Electrical Test
NOTE: The electrical thermostat test is most accurate if carried out indoors at less than 37° (100°F) ambient air. This test can be carried out with or without the hood open and with the engine warm or cold.
1. Check the engine coolant level. Fill as needed.
2. With the ignition OFF, attach the Rotunda 73 Digital Multimeter to the Cylinder Head Temperature (CHT) sensor. It may be used to monitor sensor voltage values between 0-5 volts.
3. NOTE: Running this test with the vehicle in gear or with the A/C compressor clutch engaged (running) will cause incorrect diagnosis.
Place the transmission in PARK (P) or NEUTRAL (N).
4. Start the engine and allow the engine to idle throughout this test. Allow the engine to run for two minutes, then record the CHT voltage. Record the CHT voltage every 60 seconds. When the CHT voltage trend changes direction or only changes slightly (0.03 volt or less) from the previous reading, record this as the thermostat opening voltage. Use the voltage and corresponding coolant temperature chart.
5. If the thermostat opening temperatures is not above 82°C (180°F) or the corresponding voltages shown on the chart, install a new thermostat.
6. If the thermostat opening temperatures and voltages are within the specified range, the thermostat is good and a new thermostat is not required. GO to Symptom Chart. Symptom Related Diagnostic Procedures