Powertrain Management: Technical Service Bulletins

• Recalls
  • Emissions
    • Recall - BREMI Ignition Coil Replacement
  • Generals
    • Campaign - OBD Connector Replacement
    • Campaign - TCM/EGS Programming
• Customer Interest
  • Fuel System - Fuel Cap Tether Is Broken Or Lost
  • Fuel System - MIL/Check Gas Cap Lamp ON
  • A/T - MIL ON/Fault Code 048 (P0741) Set
  • Computers/Controls - Progman(R) Can't Identify Vehicle
    • Overview
    • I. Vehicle Order Data Needed For the Procedure
    • II. Procedure to Enter A Vehicle Order Manually on E46
  • Engine - MIL ON/Codes 2882/2883 Set
  • Engine Controls - MIL/EML Lamps ON/Multiple DTC's Set
  • Engine Controls - No Start/SES/DSC Lamps ON/Multiple DTC
  • Engine Controls - Low Speed Idle Dip/Fluctuation
  • Engine Controls - Temp Gauge Goes To Red/No Overheat
  • A/T Controls - Harsh 3-2 and 2-1 Downshifts
  • Engine - MIL ON/Codes Set/Tapping/Rattling Noise
  • A/T - Hard Shifts/Leak at Torque Converter Seal
  • Ignition System - MIL ON/Runs Rough/Misfire DTC's Set
  • A/T - GM5, No 1st to 2nd Gear Upshift/Erratic Upshifts
  • Engine Controls - Intermittent Cold Start Situations
  • Engine Controls - MIL ON/O2 Sensor Fault Codes Stored
  • Engine Controls - MIL ON/O2 Sensor Codes Set
  • A/T Controls - Warning Lamp ON/DTC's Stored
  • Fuel System - Accelerator Pedal Feels 'Notchy'
  • Instruments - Fuel Gauge Innacurate/Won't Read Full
  • A/T - Hard/No Shift Condition/DTC's Stored in TCM
  • M/T - ZF GS6-37 SMG Engine Stall on Deceleration/MIL ON
  • Fuel System - Damage Caused By Fuel Contaminants
  • Engine Controls - Engine Power Drop At 4,000 RPM
  • SRS - Air Bag Lamp ON/Multiple Fault Codes Set
    • Overview
    • Attachments
      • E36
      • E38 and E39
      • E46
      • E53
      • Z3
  • Battery - Discharges With Key Left In Ignition Switch
  • A/T - Warning Lamp ON/Fail-Safe Mode/DTC's 059/065
  • Instruments - 'Check Filler Cap' Warning Inoperative
• By Symptom
  • Abnormal wear/deterioration
    • A/T - MIL ON/Fault Code 048 (P0741) Set
    • Fuel System - Damage Caused By Fuel Contaminants
  • Customer Interest
    • Fuel System - Fuel Cap Tether Is Broken Or Lost
    • Fuel System - MIL/Check Gas Cap Lamp ON
    • A/T - MIL ON/Fault Code 048 (P0741) Set
    • Computers/Controls - Progman(R) Can't Identify Vehicle
      • Overview
      • I. Vehicle Order Data Needed For the Procedure
      • II. Procedure to Enter A Vehicle Order Manually on E46
    • Engine - MIL ON/Codes 2882/2883 Set
    • Engine Controls - MIL/EML Lamps ON/Multiple DTC's Set
    • Engine Controls - No Start/SES/DSC Lamps ON/Multiple DTC
    • Engine Controls - Low Speed Idle Dip/Fluctuation
    • Engine Controls - Temp Gauge Goes To Red/No Overheat
    • A/T Controls - Harsh 3-2 and 2-1 Downshifts
    • Engine - MIL ON/Codes Set/Tapping/Rattling Noise
    • A/T - Hard Shifts/Leak at Torque Converter Seal
    • Ignition System - MIL ON/Runs Rough/Misfire DTC's Set
    • A/T - GM5, No 1st to 2nd Gear Upshift/Erratic Upshifts
    • Engine Controls - Intermittent Cold Start Situations
    • Engine Controls - MIL ON/O2 Sensor Fault Codes Stored
    • Engine Controls - MIL ON/O2 Sensor Codes Set
    • A/T Controls - Warning Lamp ON/DTC's Stored
    • Fuel System - Accelerator Pedal Feels 'Notchy'
    • Instruments - Fuel Gauge Innacurate/Won't Read Full
    • A/T - Hard/No Shift Condition/DTC's Stored in TCM
    • M/T - ZF GS6-37 SMG Engine Stall on Deceleration/MIL ON
    • Fuel System - Damage Caused By Fuel Contaminants
    • Engine Controls - Engine Power Drop At 4,000 RPM
    • SRS - Air Bag Lamp ON/Multiple Fault Codes Set
      • Overview
      • Attachments
        • E36
        • E38 and E39
        • E46
        • E53
        • Z3
    • Battery - Discharges With Key Left In Ignition Switch
    • A/T - Warning Lamp ON/Fail-Safe Mode/DTC's 059/065
    • Instruments - 'Check Filler Cap' Warning Inoperative
  • Driveability
    • Engine Controls - Low Speed Idle Dip/Fluctuation
    • Ignition System - MIL ON/Runs Rough/Misfire DTC's Set
    • Engine Controls - Intermittent Cold Start Situations
  • Erratic Shifting
    • A/T - GM5, No 1st to 2nd Gear Upshift/Erratic Upshifts
  • False instrument warning light/gauges
    • Engine Controls - Temp Gauge Goes To Red/No Overheat
    • Engine Controls - MIL ON/O2 Sensor Fault Codes Stored
    • Engine Controls - MIL ON/O2 Sensor Codes Set
    • A/T Controls - Warning Lamp ON/DTC's Stored
    • Instruments - Fuel Gauge Innacurate/Won't Read Full
  • Hard Shifting
    • A/T Controls - Harsh 3-2 and 2-1 Downshifts
    • A/T - Hard Shifts/Leak at Torque Converter Seal
    • A/T - Hard/No Shift Condition/DTC's Stored in TCM
  • Inoperative
    • Instruments - 'Check Filler Cap' Warning Inoperative
  • Leaks
    • Fuel System - Evaporative System Vacuum Leak Diagnosis
    • A/T - Hard Shifts/Leak at Torque Converter Seal
  • Low, Dead battery
    • Battery - Discharges With Key Left In Ignition Switch
  • No shift/Incorrect gear engagement
    • A/T - GM5, No 1st to 2nd Gear Upshift/Erratic Upshifts
    • A/T - Hard/No Shift Condition/DTC's Stored in TCM
  • Noise
    • Engine - MIL ON/Codes Set/Tapping/Rattling Noise
  • Recalls
    • Recall - BREMI Ignition Coil Replacement
    • Campaign - OBD Connector Replacement
    • Campaign - TCM/EGS Programming
  • Sticking/Binding
    • Fuel System - Accelerator Pedal Feels 'Notchy'
• All Technical Service Bulletins
  • Emissions - Pressure Cont. Crankcase Ventilation Info.
  • Computer/Controls - Replacement DME Programming
  • Fuel System - Evaporative System Vacuum Leak Diagnosis
  • Computers, Controls - Programming VS Veh. Data Status
  • Fuel System - Fuel Tank Lock Ring Torque Spec Missing
  • Emissions System - Evaporative System Leak Testing
  • Compuetrs/Controls - Recommended Diagnostic Procedures
  • Fuel System - Alcohol Fuel Blend Usage
  • Fuel System - High Alcohol Fuel Detection
  • Fuel System - Fuel Cap Tether Is Broken Or Lost
  • Emissions - MIL ON, Multiple DTC's Stored
  • Fuel System - MIL/Check Gas Cap Lamp ON
  • A/T - MIL ON/Fault Code 048 (P0741) Set
  • Engine Controls - DME Programming Tips
  • Progman(R) - Programming/Coding/Individualization
    • Overview
    • General_Rules_For_Programming
    • Procedure_A_Module_Replacement
    • Procedure_B_Software_Update
    • Procedure_C_Troubleshooting
      • Index
      • Introduction
      • Section I: Preparing A Progman Session
      • Section II: Progman Session Initialization
      • Section III: Before Programming/Coding
      • Section IV: After Programming Coding
      • Illustrations and Table
    • Procedure_E_Coding
  • Computers/Controls - Progman(R) Can't Identify Vehicle
    • Overview
    • I. Vehicle Order Data Needed For the Procedure
    • II. Procedure to Enter A Vehicle Order Manually on E46
  • Engine - MIL ON/Codes 2882/2883 Set
  • Engine Controls - MIL/EML Lamps ON/Multiple DTC's Set
  • A/T - Fault Code 002 and 003 Diagnosis
  • Engine Controls - No Start/SES/DSC Lamps ON/Multiple DTC
  • Engine Controls - Updated DISplus/GT1 Software
  • Computers/Controls - 'Retrofit' Update Programming
  • Engine Controls - Low Speed Idle Dip/Fluctuation
  • Engine Controls - Various Driveability Complaints
  • Engine Controls - Temp Gauge Goes To Red/No Overheat
  • A/T Controls - Harsh 3-2 and 2-1 Downshifts
  • Engine Controls - Progman(R) V22.1/V22.1.1 and V22.1.2
  • Engine Controls - False Maintenance Interval in Progman
  • Engine Controls - Progman(R) V21.0 Software Errors
  • Spark Plug (HP Platinum) - Application Chart
  • Engine - MIL ON/Codes Set/Tapping/Rattling Noise
  • A/T - Hard Shifts/Leak at Torque Converter Seal
  • Ignition System - MIL ON/Runs Rough/Misfire DTC's Set
  • Recall - BREMI Ignition Coil Replacement
  • Campaign - OBD Connector Replacement
  • Campaign - TCM/EGS Programming
  • A/T - GM5, No 1st to 2nd Gear Upshift/Erratic Upshifts
  • Engine Controls - Intermittent Cold Start Situations
  • Engine Controls - MIL ON/O2 Sensor Fault Codes Stored
  • Engine Controls - MIL ON/O2 Sensor Codes Set
  • A/T Controls - Warning Lamp ON/DTC's Stored
  • Fuel System - Accelerator Pedal Feels 'Notchy'
  • Instruments - Fuel Gauge Innacurate/Won't Read Full
  • Engine Controls/Emissions - OBD Readiness Code Setting
  • Emissions - Evaporative Emission Fault Diagnostics
  • A/T - Hard/No Shift Condition/DTC's Stored in TCM
  • Engine Controls - DSC Not Recognized During Diagnostics
  • M/T - ZF GS6-37 SMG Engine Stall on Deceleration/MIL ON
  • Fuel System - Damage Caused By Fuel Contaminants
  • Ignition System - Platinum Spark Plug Application Chart
  • Engine Controls - Progman(R) V21.01 and V21.02.01 Errors
  • Computers/Controls - Progman(R) V22.0/V22.0.1 Errors
  • Engine Controls - Engine Power Drop At 4,000 RPM
  • SRS - Air Bag Lamp ON/Multiple Fault Codes Set
    • Overview
    • Attachments
      • E36
      • E38 and E39
      • E46
      • E53
      • Z3
  • Battery - Discharges With Key Left In Ignition Switch
  • A/T - Warning Lamp ON/Fail-Safe Mode/DTC's 059/065
  • Electrical - Oil Level Sensor Diagnostic Hints
  • Engine Controls - Temp Gauge Goes To Red/FC10
  • Fuel System - TOP TIER Gasoline Usage Recommendations
  • Fuel System - Fuel Quality and Additive Information
  • Instruments - 'Check Filler Cap' Warning Inoperative
  • Emissions - Evaporative Emissions System Testing
  • Fuel System - Injection/Induction System Cleaning
  • Fuel System - Fuel/Induction System Cleaning Information
  • Computers/Controls - ISTA/D DTC S0001 After Quick Delete
  • Computers/Controls - ISTA Test Plan Priority Error Info.
  • Maintenance - Condition Based Service (CBS) Overview
  • Engine - Engine Oil Separator Freezing Concerns
  • Computers/Control - Loading/Activation Of Enabling Codes
  • Fuel System - BMW Group Fuel System Cleaner Plus Info.
  • Fuel System - Injection/Induction System Cleaning
    • Overview
    • Attachments
      • Procedure - A
      • Procedure - B
      • Procedure - C
      • Procedure - D
      • Procedure - E