Trunk - Front or Tulip Panel Misaligned

9207caddy01

Bulletin No. T-92-37
File in Group 10
Number 233
Corp. Ref. No. 101008
Date Dec. 1991


SUBJECT: REAR COMPARTMENT FRONT PANEL MISALIGNED

MODELS AFFECTED: 1991-1992 DE VILLES AND FLEETWOODS


Some 1991-1992 DeVilles and Fleetwoods may exhibit a condition of the rear compartment front panel (tulip) being misaligned.

To correct this condition the following procedures should be followed:

NOTE: Prior to any adjustment of the tulip panel, make sure the deck lid is properly located to the deck lid opening.

To Adjust the Panel Fore/Aft:

Figure 1:

Remove the tulip panel and relocate the supports (near glass) to any one of three available mounting slots. Selecting the correct slot will allow movement of the panel approximately 1 mm in either direction. If greater fore/aft movement is necessary, remove the panel and shave up to 2 mm from the lower leg. Remove only enough to allow proper panel alignment. Refer to Figure 1.

To Adjust Up/Down:

Loosen all attachments, move the panel to the desired location, and tighten.

If greater up/down movement is required, remove the panel and replace or reinstall the supports as necessary. Install the panel to desired location. Refer to Figure 1.

For warranty purposes use Labor Operation T5240 at .3 hour.