Fastener Tightening Specifications

Accelerator Control Cable Bracket Bolt Nut		89 inch lbs.
Air Injection Check Valve - with NC1 California Emissions		15 ft. lbs.
Air Injection Check Valve Front Bracket Bolt/Nut - with NC1 California		18 ft. lbs.
Air Injection Check Valve Bolt/Nut - with NC1 California Emissions		89 inch lbs.
Air Injection Check Valve Pipe Adapter - with NC1 California Emissions		22 ft. lbs.
Air Injection Check Valve Pipe Assembly Bolt		89 inch lbs.
Air Injection Check Valve Rear Bracket Bolt/Nut - with NC1 California		18 ft. lbs.
Air Injection Solenoid Bolt - with NC1 California Emissions		89 inch lbs.
Camshaft Position Sensor Bolt		89 inch lbs.
Camshaft Sprocket Bolt		103 ft. lbs.
Camshaft Thrust Plate Screw		89 inch lbs.
Connecting Rod Bearing Cap Nut	First Pass	15 ft. lbs.
	Final Pass	75 degrees
Coolant Drain Plug		14 ft. lbs.
Coolant Temperature Sensor		17 ft. lbs.
Crankshaft Balancer Bolt	First Pass	52 ft. lbs.
	Final Pass	72 degrees
Crankshaft Main Bearing Cap Bolt Stud	First Pass	37 ft. lbs.
	Final Pass	77 degrees
Crankshaft Oil Deflector Nut		18 ft. lbs.
Crankshaft Position Sensor Bolt-Front Cover		89 inch lbs.
Crankshaft Position Sensor Stud-Side of Engine Block		98 inch lbs.
Crankshaft Position Sensor Shield Nut		98 inch lbs.
Crankshaft Position Sensor Wiring Bracket Bolt		30 ft. lbs.
Cylinder Head Bolt	First Pass	44 ft. lbs.
	Final Pass	95 degrees
Drive Belt Tensioner Bolt		37 ft. lbs.
EGR Valve Adapter Pipe to Exhaust Manifold Nut		18 ft. lbs.
EGR Valve Pipe to EGR Valve Bolt		18 ft. lbs.
Engine Front Cover Bolt	Large Bolt	41 ft. lbs.
	Medium Bolt	41 ft. lbs.
	Small Bolt	20 ft. lbs.
Engine Mount Strut and A/C Compressor Bracket Bolt		37 ft. lbs.
Engine Mount Strut and Lift Bracket Bolt- Engine Lift Rear		52 ft. lbs.
Engine Mount Strut and Generator Bracket Bolt		37 ft. lbs.
Engine Mount Strut and Support Bracket	Large Bolt	41 ft. lbs.
	Medium Bolt	41 ft. lbs.
	Small Bolt	20 ft. lbs.
Engine Oil Pressure Indicator Switch		115 inch lbs.
Engine Wiring Harness Bracket Bolt		115 inch lbs.
Exhaust Manifold Heat Shield Bolt		89 inch lbs.
Exhaust Manifold Nut		12 ft. lbs.
Exhaust Manifold Stud		13 ft. lbs.
Flywheel Bolt		52 ft. lbs.
Fuel Feed and Return Pipe Bracket Stud		37 ft. lbs.
Fuel Feed and Return Pipe Retaining Clip Bolt		71 inch lbs.
Fuel Feed and Return Pipe Retaining Clip Nut		18 ft. lbs.
Fuel Feed Pipe To Fuel Injector Rail Nut		13 ft. lbs.
Fuel Injector Rail Bolt		89 inch lbs.
Fuel Pipe Clip Bolt		71 inch lbs.
Heated Oxygen Sensor		31 ft. lbs.
Heater Inlet Pipe Nut		18 ft. lbs.
Heater Inlet Pipe Stud		37 ft. lbs.
Ignition Coil Bracket Bolt/Nut/Stud		18 ft. lbs.
Intake Manifold Coolant Pipe Bolt		89 inch lbs.
Knock Sensor		14 ft. lbs.
Lower Intake Manifold Bolt	First Pass	62 inch lbs.
	Final Pass	115 inch lbs.
MAP Sensor Bolt		44 inch lbs.
MAP Sensor Bracket Bolt		18 ft. lbs.
Oil Cooler Connector		37 ft. lbs.
Oil Cooler Hose Fitting		14 ft. lbs.
Oil Cooler Pipe Bracket Bolt		89 inch lbs.
Oil Filter		22 ft. lbs.
Oil Filter Bypass Hole Plug		14 ft. lbs.
Oil Filter Fitting		29 ft. lbs.
Oil Gallery Plug-1/4 inch		14 ft. lbs.
Oil Gallery Plug-3/8 inch		24 ft. lbs.
Oil Level Indicator Tube Bolt		18 ft. lbs.
Oil Level Sensor Bolt		89 inch lbs.
Oil Pan Bolt		18 ft. lbs.
Oil Pan Drain Plug		18 ft. lbs.
Oil Pan Side Bolt		37 ft. lbs.
Oil Pump Cover Bolt		89 inch lbs.
Oil Pump Drive Clamp Bolt		27 ft. lbs.
Oil Pump Mounting Bolt		30 ft. lbs.
Spark Plug - Initial Installation		20 ft. lbs.
Spark Plug - After Initial Installation		13 ft. lbs.
Thermostat Bypass Pipe to Engine front Cover Bolt		106 inch lbs.
Thermostat Bypass Pipe to Throttle Body Nut		18 ft. lbs.
Throttle Body Bolt/Stud		18 ft. lbs.
Timing Chain Dampener Bolt		15 ft. lbs.
Upper Intake Manifold Bolt/Stud		18 ft. lbs.
Valve Lifter Guide Bolt		89 inch lbs.
Valve Rocker Arm Bolt	First Pass	14 ft. lbs.
	Final Pass	30 degrees
Valve Rocker Arm Cover Bolt		89 inch lbs.
Water Outlet Bolt		18 ft. lbs.
Water Pump Bolt		98 inch lbs.
Water Pump Pulley Bolt		18 ft. lbs.