Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Automatic Temperature Control - Windows Fog Up
- A/C - Low or No Cabin Heat/Engine Overheat
- Power Steering System - Whine Noise
- Fuel Pump - Driveability Concerns
- AC Ducts - Emit Odors
- Heater, A/C Housing - Water Ingestion
- Heater, A/C Housing - Debris Build Up
- Air Conditioning Ducts - Emits Musty Odor
- Steering - Loose Feel/Clunking on Turns
- Steering Gear - Cold Squawk Noise
- Suspension/Alignment - Vehicle Pull Diagnosis
- Serpentine Drive Belt - Chirping Noise
- Exhaust Flex Joint - Squeaking Noise
- Tire - Lead or Drift Corrections
- Lock Cylinder - Key Breakage in Cylinder
- Front Seat Cushion Pan - Cracked/Welds Broken
- Front Hub - Clunk/Click Noise
- A/T - Slips In Reverse At Low Temperature
- Converter Clutch - Vehicle Shudder on Lock Up
- TCC - Acceleration Shudder/DTC 38 Set
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- A/T - Burned Fluid/Damaged Internal Components
- A/T - Ratcheting Sound When Coming To Stop
- PCM - Deceleration Shudder At Low Engine Speeds
- PCM/BCM - No Start or Erratic Theft Alarm Operation
- Instruments/Locks/Lamps - Inoperative
- A/T - Engine Stalls On Takeoff
- PCM - Cold Engine Knock
- MIL ON - Erroneously, DTC Hex #2E Set
- PCM - Sag or Hesitation on Cold Start Up
- Catalytic Converter - Excessive Sulfur Odor
- Speed Control - Intermittent Dropout/Disengagement
- A/T - Poor Shift Quality
- TCM - Improved Transmission Shift Quality
- A/T - Harsh Gear Engagement/Upshifts/Downshifts
- Passenger Airbag Door - Poor Fit/Warped
- Black Plastic Body Components - Chalky Residue
- Trunk - Water and Dust Leaks
- Wipers/Washers - Wipers Smear or Streak Windshield
- Windshield Washer Nozzle - Freeze Up
- Windshield Washer Nozzle - Freeze-Up
- Windshield Washer Nozzle - Freezes Up
- A/T - Shudder/Bumps/Slippage
- Serpentine Belt - Comes Off Pulleys, Driving in Snow
- Speed Sensor - Intermittent Loss of Cruise Control
- Park/Turn Lamps - Moisture Buildup Inside
- A/T - 41TE and 42LE Whistling Noise At Idle
- A/T - 41TE Buzz In Reverse
- A/T - Harsh 1-2/2-3 Upshifts and 3-2 Kickdown
- Differential Vent - Leaks Fluid
- Door Check Straps - Snapping Noise
- A/C Evaporator - Emits Odors
- A/C - Musty Odors When Hot/Humid
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 240695 - 05/05/95
- 240195 - 03/03/95
- 23-11-95 - 03/10/95
- 21-18-96 - 12/27/96
- 19-03-97 - 02/14/97
- 083993 - 01/01/93
- 082892 11/30/92
- 081595 - 04/07/95
- Cruise Control - Erratic During Initial Speed Set
- Speed Control - Intermittent Operation
- Radio Transmitter Equipment - Installation
- Radio Transmitting Equipment - Installation
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- Airbag - On/Off Switch Availability
- Steering Wheel - Loose Feel or Clunk
- Inner Tie Rod - Loose Steering
- Steering Wheel - Loose Feel/Clunk
- Electrical - Wire Splice Procedure Revision
- Differential Vent - Fluid Leaks
- A/T - Vehicle Shudder During Torque Converter Operation
- A/T - Poor Shifting Quality
- A/T Pan Gasket - Reusable Design
- A/T - Vehicle Shudder During T/C Lock-up
- TCM - 41TE or 42LE A/T, Poor Shift Quality/Shudder
- A/T Quick Learn Procedure - Manual Update
- PCM - Engine Sag/Hesitation in Cold Ambient Temperatures
- Fuel Pump - Engine, Low Power/Die Out
- Engine Controls - Flash Reprogramming Failure
- A/C - Loss of Flow and Cooling/Evaporator Freeze Up
- Cooling System - Overheating/Fill Procedure
- Engine - Oil Leak Diagnosis/Prevention
- A/T - Fluid Usage
- A/C - Musty Odors When Hot or Humid
- Front Strut - Vehicle Drifts/Leads
- Alignment - Vehicle Leads or Pulls.
- A/T - Vehicle Shudder During TC Lock-up
- A/T - 41TE/42LE Intermittent Delayed Engagement
- Engine Coolant - Recommendations
- A/T - ATF Usage List
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- TSBs - Using Body Code Identification
- Service Manual - Revisions / Updates
- Service Manual - Revisions and Updates
- Service and/or Diagnostic Manual - Revision Descriptions
- Brakes - Noise Explanation
- A/C - R-12 to R-134a Conversion Procedure
- Climate Control Diagnostics - Revision
- Automatic Temperature Control - Windows Fog Up
- A/C - Low or No Cabin Heat/Engine Overheat
- A/C - System Leak Detection
- A/C - System Sealer Usage Prohibition
- A/C - Diagnostics Text Correction
- Engine - Oil Leak Prevention/Diagnosis
- Engine - Knocking When Cold
- Idle Air Control Motor - Whistling Noise
- Power Steering System - Whine Noise
- Ignition/Steering - Service Manual Revisions
- Fuel Filter - Quick Connect Package
- Fuel Pump and Filter - Replacement Information
- Fuel Pump - Driveability Concerns
- Ignition System - Spark Plug Gap Revision
- AC Ducts - Emit Odors
- Heater, A/C Housing - Water Ingestion
- A/C - Evaporator Freezes Up/Lack Of Cooling
- Instrument Panel Vents - Emit White Flakes
- Heater, A/C Housing - Debris Build Up
- Air Conditioning Ducts - Emits Musty Odor
- Steering - Loose Feel/Clunking on Turns
- Steering Gear - Cold Squawk Noise
- Suspension/Alignment - Vehicle Pull Diagnosis
- Inner Tie Rod End To Steering Gear - Service Torque
- Engine - Piston Knock at Idle
- Engine - Noise Diagnosis
- Serpentine Drive Belt - Chirping Noise
- Exhaust Flex Joint - Squeaking Noise
- Tire - Lead or Drift Corrections
- Tires/Wheels - Runout Reference Chart
- Lock Cylinder - Key Breakage in Cylinder
- Recall - Defective Power Seat Adjuster
- Front Seat Cushion Pan - Cracked/Welds Broken
- Front Hub - Clunk/Click Noise
- A/T - 41TE/42LE Shudder During EMCC Shift
- A/T - Slips In Reverse At Low Temperature
- Converter Clutch - Vehicle Shudder on Lock Up
- TCC - Acceleration Shudder/DTC 38 Set
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- A/T - Burned Fluid/Damaged Internal Components
- A/T - Ratcheting Sound When Coming To Stop
- PCM - Deceleration Shudder At Low Engine Speeds
- PCM/BCM - No Start or Erratic Theft Alarm Operation
- Instruments/Locks/Lamps - Inoperative
- Front Axle - Hub Nut Torque Revision
- ABS - Kelsey Hayes EBC-5H, EBC 310 Test Revisions
- ABS - Component Service Procedure
- A/T - Engine Stalls On Takeoff
- PCM - Cold Engine Knock
- MIL ON - Erroneously, DTC Hex #2E Set
- PCM - Sag or Hesitation on Cold Start Up
- Engine Controls - Flash Programming Failure Recovery
- Fuel Pressure Regulator - Installation Procedure
- Catalytic Converter - Excessive Sulfur Odor
- A/T - (41TE) Pinion Factor Axle Ratio Values
- Speed Control - Intermittent Dropout/Disengagement
- Radio - Poor FM Reception
- A/T - Poor Shift Quality
- TCM - Improved Transmission Shift Quality
- A/T - Harsh Gear Engagement/Upshifts/Downshifts
- Radio Communication Equipment - Recommendations
- Passenger Airbag Door - Poor Fit/Warped
- Airbag/Clock Spring - Service
- Brakes - Rotor Thickness Specification Correction
- Headlamp - Pattern Improvements
- Antilock Brake System - Operation Characteristics
- Recall - ABS Piston and Pump/Motor Assy.
- ABS System - Diagnostic Procedure revision
- Black Plastic Body Components - Chalky Residue
- Radio Transmitters - Installation
- Recall - Passenger Air Bag Safety
- Airbag - NHTSA Authorized Deactivation
- Air Bag System - Diagnostic Procedures Revisions
- Diagnostic Manual - Revision
- Auto Computers - Y2K Effects
- Electrical - Pin Out and Graphics Revisions
- Trunk - Water and Dust Leaks
- Wipers/Washers - Wipers Smear or Streak Windshield
- Windshield Washer Nozzle - Freeze Up
- Windshield Washer Nozzle - Freeze-Up
- Windshield Washer Nozzle - Freezes Up
- Mirror Glass - Precautions Against Scratching
- Tape Stripe and Molding Adhesive - Removal
- Engine - Coolant Recommendations
- A/T Quick Learn Transaxle - Manual Correction
- A/T - Shudder/Bumps/Slippage
- A/T - (41TE/42LE) Service Information
- A/T - 41TE/42LE Cruise Control Interaction
- A/T - 41TE/42LE Interactive Cruise Control
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - A604 Snap Ring Breakage
- A/T - Failsafe Modes
- A/T - Chatter During Engagement or Shifts
- A/T - Intermittent Limp-In/Fault Codes
- A/T - Electrical Harness Repair Parts
- A/T - Circuit Leaks, Low/Reverse Accumulator Cover
- A/T - Engine Speed Sensing Problems
- A/T - Snap Ring Locations
- A/T - Neutral-Safety And PRNODL Switch Check
- A/T - Overdrive Reverse Piston Interchanges
- A/T - Underdrive Clutch Piston Outer Lip Seal Change
- A/T - 41TE (A604) Solenoid Body Electrical Check
- A/T - 41TE/42LE Bind-Up In Reverse
- A/T - 41TE/42LE DTC 41, 42, 43, or 44/Solenoid Circuit
- A/T - 41TE (A604) Neutral Safety Switch/No Start
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- CD Player - CD Compatibility
- Power Steering Pressure Switch - Service
- Serpentine Belt - Comes Off Pulleys, Driving in Snow
- A/T - ATF+4 Fluid Usage/Applications
- Recall - Lower Control Arm Reinforcement
- Recall 99V215000: Cracked Lower Control Arm Brackets
- Transmission Range Sensor - Production Change
- Speed Sensor - Intermittent Loss of Cruise Control
- Relay Bank/Fuse Block - Locations/Identification
- Engine - Oil Leak Diagnosis
- Charging System - No Code test Procedure Revisions
- Wiring - Revised Splicing Procedure
- Electrical Connectors - Cleaning Precautions
- Speed Control - Adaptive Strategy
- Stone Guard - Paint Repair
- Paint - Codes/Cross references/Applications
- Overview
- Paint Suppliers/Codes By Assembly Plant
- Domestic Passenger Car and Truck Exterior Paint
- Domestic Car and Truck Interior Paint Monotone Colors
- Domestic Car and Truck Interior Paint Two-Tone Colors
- Domestic Passenger Car Vinyl Roof
- Chrysler-Plymouth-Dodge Painted Stripe Colors
- Painted Two-Tone Stripe Application Chart Upper/Lower Colors
- Fascias Colors
- Cherokee/Wrangler Bumpers
- Wrangler Hardtops
- Painted Steel Wheels and Dakota Light BAR Package
- Import Passenger Car and Truck Exterior Paint
- Park/Turn Lamps - Moisture Buildup Inside
- A/T - 41TE and 42LE Whistling Noise At Idle
- Heating/Air Conditioning Housing - Service
- A/T - 41TE Buzz In Reverse
- Front Shock Tower - Metal Screws/Bolts Precautions
- Recall 96V099000: ABS Hydraulic Control Unit Failure
- Engine - Timing Components Service Revisions
- A/T - Harsh 1-2/2-3 Upshifts and 3-2 Kickdown
- Emergency Trunk Release - Availability
- Differential Vent - Leaks Fluid
- Rear License Plate/Frame - Rattles
- Door Check Straps - Snapping Noise
- A/C Evaporator - Emits Odors
- Steering Gear - Mounting Bushing Service
- Steering - Power Steering Fluid Usage
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- A/T Pan Gasket - Reusable Design/Installation
- A/C - Musty Odors When Hot/Humid
- A/T - ATF + 4 Fluid Usage
- Restraints - Child Seat Tether Installation
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process