Powertrain Management: Technical Service Bulletins

• Recalls
  • Recall 02V215000: Fuel Pump Secondary Seal Installation
  • Recall - Fuel Pump Module Secondary Seal
    • Overview
    • Service Procedure
    • Owner Letter
  • Recall 02V214000: Fuel Line Inspection/Replacement
• Customer Interest
  • Fuel System - Engine Slow To Start
  • Fuel Gauge - Doesn't Register Full
  • PCM - Driveability Problem Improvements
  • A/T - Surge/Sag/Shift Bump
  • MIL - Erroneous P0441 Evap Purge Flow Monitor Failure
  • Engine - Moderate To Severe Highway Speed Surge
  • Engine Controls - Rough Idle/Sag/3,000 RPM Surge
  • MIL ON - DTCs P0645, P1282, P1489, P1490, P1495 Set
• By Symptom
  • Customer Interest
    • Fuel System - Engine Slow To Start
    • Fuel Gauge - Doesn't Register Full
    • PCM - Driveability Problem Improvements
    • A/T - Surge/Sag/Shift Bump
    • MIL - Erroneous P0441 Evap Purge Flow Monitor Failure
    • Engine - Moderate To Severe Highway Speed Surge
    • Engine Controls - Rough Idle/Sag/3,000 RPM Surge
    • MIL ON - DTCs P0645, P1282, P1489, P1490, P1495 Set
  • Driveability
    • PCM - Driveability Problem Improvements
    • Engine Controls - Rough Idle/Sag/3,000 RPM Surge
  • False instrument warning light/gauges
    • Fuel Gauge - Doesn't Register Full
    • MIL - Erroneous P0441 Evap Purge Flow Monitor Failure
  • Hard Shifting
    • A/T - Surge/Sag/Shift Bump
  • Hunting-Surging
    • A/T - Surge/Sag/Shift Bump
  • Recalls
    • Recall 02V215000: Fuel Pump Secondary Seal Installation
    • Recall - Fuel Pump Module Secondary Seal
      • Overview
      • Service Procedure
      • Owner Letter
    • Recall 02V214000: Fuel Line Inspection/Replacement
  • Starting problems
    • Fuel System - Engine Slow To Start
• All Technical Service Bulletins
  • Engine Controls - Co-Pilot Support/Correct Cable Usage
  • Engine Control - PCM Initialization Procedure
  • Fuel System - Engine Slow To Start
  • Fuel Gauge - Doesn't Register Full
  • Recall 02V215000: Fuel Pump Secondary Seal Installation
  • Recall - Fuel Pump Module Secondary Seal
    • Overview
    • Service Procedure
    • Owner Letter
  • PCM - Driveability Problem Improvements
  • A/T - Surge/Sag/Shift Bump
  • MIL - Erroneous P0441 Evap Purge Flow Monitor Failure
  • Engine - Moderate To Severe Highway Speed Surge
  • Engine Controls - Rough Idle/Sag/3,000 RPM Surge
  • Engine Controls - Flash Programming Failure Recovery
    • Overview
    • Connected/Disconnected Flash Mode Using TechCONNECT
    • Pay Attention While Performing Flash Reprogram Procedures
    • Error Messages
    • Enhanced and Original Abort Recovery
    • Enhanced Abort Recovery Screens
    • Original Abort Recovery Screen
    • Programmable Modules
    • Powertrain Modules - Engine and Transmission
  • Recall 02V214000: Fuel Line Inspection/Replacement
  • Fuel System - Throttle Body Torque Specification Update
  • MIL - Revised Features for OBDII Readiness
  • EVAP System - Leak Detection Pump Operation
    • Overview
    • Leak Detection Pump (LDP) Operation and Diagnosis
    • EVAP Leak Detection Test Sequence
  • MIL ON - DTCs P0645, P1282, P1489, P1490, P1495 Set
  • Generic Scan Tool - Reference Information
    • Overview
    • Quick Reference
    • 1. Powertrain Diagnostic Data
    • 2. Powertrain Freeze Frame
    • 3. Emission Related DTCs
    • 4. Clear/Reset DTCs
    • 5. O2 Monitoring Results
    • 6. Last Monitor Results
    • 7. 1 Trip Failures
    • 8. On Board System Test
    • 9. Vehicle Information
    • Appendix A, B, C and D Information
  • Ignition Lock Cylinder - Service Precautions