Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Electrical - Front Door Locks/Windows Inoperative
- Body - Light To Moderate Paint Imperfections
- Brakes - Front/Rear Brakes Squeal On Light Application
- Interior - Ash Tray Won't Stay Closed/Won't Open
- Body - Gaps Between Spoiler and Deck Lid
- Body - Sunroof Rattles
- Interior - Headliner Sags in Rear
- A/T - Shudder/Buzz, Fluid Water Contamination
- Overview
- Repair Procedure
- A. Air Pressure Test
- B. Road Testing Vehicle For Torque Converter Shudder
- C. Fill Tube Oil Seal Replacement
- D. Torque Converter Replacement
- E. Transmission Oil Drain
- F. Fill and Mix Transmission Oil Prior to Flush
- G. Final Transmission Fluid Fill-Up and Check
- H. Reset Transmission Learned Adaptives Using StarScan
- Engine Controls - A/T Shift Hesitation on WOT Throttle
- Engine Control - Rough Idle/Idle Sag/Cruise Control Inop
- Engine Controls - MIL ON/DTC's P2112 or P1521
- Cell Phone - Hands Free Module Will Not Connect
- Body - Sunroof Squeaks When Opening or Closing
- Body - Circular/Ring Marks on Glass
- Wipers/Washers - Wipers Smear or Streak Windshield
- Body - Gap Between Rear Fascia and Body Side/Tail Lamp
- Body - Cladding Has Come Loose
- Computers/Controls - Rear Wiper Inop/Fog Lamps Stay ON
- Interior - Adhesive Residue On Carpet
- Drivetrain - Transfer Case Shudder On Slow Speed Turns
- Body - Rear of Sunroof Not Flush With Roof
- Audio System - Satellite Radio Static
- Brakes - Front/Rear Rotors Grooved/Scored
- Audio System - Poor Radio Reception With Defroster ON
- Body - Buzzing/Humming From Upper Windshield Area
- Seats/Steering Column - Won't Return to Memory Positions
- A/C - Musty Odors When Hot/Humid
- Body - Sunroof Glass Not Flush With Roof/Won't Close
- Engine Controls - MIL ON/DTC P0573 Set
- Body - Power Window 'Express Up' Feature Inoperative
- Steering - Vehicle Leads Left or Right
- Steering - Squeak/Rub Noise From Lower Column Area
- Drivetrain - Ping Noise When Shifting From 'D' to 'R'
- Body - Ratcheting Noise When Operating Sunroof
- Body - Rattle Sound in Sunroof Area
- Fuel System - Difficult Fuel Fill/Nozzle Shuts Off
- Superceded Bulletins
- Body - Ratcheting Noise During Sunroof Operation
- Windows - Inoperative Express Up Feature
- Cell Phone - Hands Free Feature is Inoperative
- Restraints - Passenger Air Bag Deactivation
- Steering - Revised Power Steering Bleeding Procedure
- A/T - Diagnostic Teardown Procedures
- A/T - Diagnostic Tear-Down Procedure
- Automatic Transmission - Diagnostic Teardown Procedure
- Fuel System - Hard To Fill With Fuel/Nozzle Shuts Off
- Engine Controls - Reprogramming Abort Recovery Procedure
- Engine Controls - MIL ON/DTC's P2112 or P1521 Set
- Engine Controls - Generic PCM Programming Procedures
- Engine Controls - PCM Initialization Procedure
- A/C - Musty Odors When Hot or Humid
- Air Bag System Passenger Air Bag Deactivation
- Maintenance - Fluid Flushing Recommendations
- Drivetrain - Low Speed Transfer Case Shudder
- All Technical Service Bulletins
- Electrical - Front Door Locks/Windows Inoperative
- Canada - Campaign - K39 A/T Shifter Interlock Lever
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Wheels/Tires - Chrome Clad Wheel Balancing Info.
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Body - Light To Moderate Paint Imperfections
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Campaign - A/T Shift Interlock Lever Replacement
- Brakes - Front/Rear Brakes Squeal On Light Application
- Interior - Ash Tray Won't Stay Closed/Won't Open
- Wheels - Caring for Chrome Wheels
- Body - Gaps Between Spoiler and Deck Lid
- Body - Sunroof Rattles
- Interior - Headliner Sags in Rear
- A/T - Shudder/Buzz, Fluid Water Contamination
- Overview
- Repair Procedure
- A. Air Pressure Test
- B. Road Testing Vehicle For Torque Converter Shudder
- C. Fill Tube Oil Seal Replacement
- D. Torque Converter Replacement
- E. Transmission Oil Drain
- F. Fill and Mix Transmission Oil Prior to Flush
- G. Final Transmission Fluid Fill-Up and Check
- H. Reset Transmission Learned Adaptives Using StarScan
- Engine Controls - Generic PCM programming Procedure
- Engine Controls - A/T Shift Hesitation on WOT Throttle
- Engine Control - Rough Idle/Idle Sag/Cruise Control Inop
- Engine Controls - MIL ON/DTC's P2112 or P1521
- Cell Phone - UConnect(R) Hands Free Phone Inoperative
- Cell Phone - Hands Free Module Will Not Connect
- SRS - Passenger Air Bag Deactivation Procedure
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- StarSCAN(R) - Vehicle Scan Report Availability
- Body - Sunroof Squeaks When Opening or Closing
- Body - Circular/Ring Marks on Glass
- Wipers/Washers - Wipers Smear or Streak Windshield
- Body - Gap Between Rear Fascia and Body Side/Tail Lamp
- Body - Cladding Has Come Loose
- Computers/Controls - Rear Wiper Inop/Fog Lamps Stay ON
- A/T - ATF+4 Fluid Usage/Applications
- Interior - Gap Between Carpet and Scuff Plate
- Interior - Adhesive Residue On Carpet
- Drivetrain - Transfer Case Shudder On Slow Speed Turns
- Recall 05V460000: A/T Parking Pawl Shaft Anchoring
- Recall - A/T Parking Pawl Cup Plug Defect
- Body - Rear of Sunroof Not Flush With Roof
- Steering - Revised Power Steering Bleeding
- Audio System - Satellite Radio Static
- Brakes - Front/Rear Rotors Grooved/Scored
- Engine Controls - Flash Reprogramming Abort Recovery
- Audio System - Poor Radio Reception With Defroster ON
- Body - Buzzing/Humming From Upper Windshield Area
- Seats/Steering Column - Won't Return to Memory Positions
- A/C - Musty Odors When Hot/Humid
- Body - Sunroof Glass Not Flush With Roof/Won't Close
- Engine Control - PCM Initialization Procedure
- Engine Controls - MIL ON/DTC P0573 Set
- A/T - Delayed or Rough 1-2 Shift at WOT
- Engine - Engine Whine Sound at Idle
- Air Bag System - Passenger Air Bag Deactivation
- Body - Power Window 'Express Up' Feature Inoperative
- Steering - Vehicle Leads Left or Right
- Wheels/Tires - Lug Nut Removal Precautions
- A/T - ATF + 4 Fluid Usage
- Interior - Low Gloss Interior Trim Care Information
- Steering - Squeak/Rub Noise From Lower Column Area
- Drivetrain - Ping Noise When Shifting From 'D' to 'R'
- Lighting - Color/Brightness Difference Between Headlamps
- Body - Ratcheting Noise When Operating Sunroof
- Body - Rattle Sound in Sunroof Area
- Brakes - Parking Brake Adjustment Service Intervals
- A/T - Repair/Replacement Guidelines
- Maintenance - Fluid Flushing Information
- Wheels/Tires - Chrome Clad Wheel Balancing Information
- Fuel System - Difficult Fuel Fill/Nozzle Shuts Off
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process