Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall 99V113000: Inadvertent Air Bag Deployment
- Recall - Inadvertent Airbag Deployment
- Recall 00V305000: Steering Wheel Separation
- Recall - Passenger Air Bag Safety
- Campaign - Liftgate Latch
- Recall 95I001000: Rear Liftgate Latch Opens
- Recall 95I001001: Rear Liftgate Latch Opens In Collision
- Customer Interest
- Crossmember/Alignment/Wheels/Tires - Vehicle Drifts Left
- IAC Motor - Intermittent Rough Idle When Cold
- Fuel Pump - High Pitched Noise
- AC Ducts - Emit Odors
- Low Heater Performance - Diagnosis/Repair
- A/C Compressor - Moaning Noise
- A/C Evaporator - High Pitched Whistle Noise
- Air Conditioning Ducts - Emits Musty Odor
- Cooling Module Fan - Vibrates/Comes Loose
- Heater - Poor Performance
- Front Coil Spring - Metallic Rapping Noise
- Front Suspension - Rapping Noise On Bumps
- Tires/Wheels - Smooth Road Vibration/Shake/Wobble.
- Rear Leaf Springs - Floor Pan Ticking Noise
- Rear Seat - High Sliding Effort
- Under Seat Storage Drawer - Cracks
- A/T - Slips In Reverse At Low Temperature
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- Speedometer - Inoperative
- A/T - Ratcheting Sound When Coming To Stop
- Engine - Overheats Under Heavy Load
- Door Ajar Lamp - Flickers/Locks Cycle Repeatedly
- ABS - Warning Light ON Continuously
- Engine Starter - Intermittent No Crank
- Catalytic Converter - Excessive Sulfur Odor
- A/T - Harsh Shift At Low Speed/Speedo. Fluctuates
- A/T - Poor Shift Quality
- Speed Control Switch - Loose/Rattles
- Radio - Locks Up During Operation
- Instrument Panel - Squeak/Rattle From Right Side
- A/C System - Poor Cooling Performance
- Black Plastic Body Components - Chalky Residue
- Left B Pillar - Intermittent Creaking Noise
- Front Door - Sagging
- Backlight/Windshield Moulding - Glue Oozing Out
- Wipers/Washers - Wipers Smear or Streak Windshield
- Body Cladding - Interferes With Use Of Jack
- A/T - Shudder/Bumps/Slippage
- Engine Mount - Squeak/Clunk Noise
- Serpentine Belt - Comes Off Pulleys, Driving in Snow
- A/C, Heater - Temperature Lever Difficult to Move
- Speed Sensor - Intermittent Loss of Cruise Control
- Fuse Block - Rattle in Lower Left Dash Area
- Middle Side Glass Vent Latch - Difficult Operation
- Vent Window - Latch Pops Open/Rattles/Pops Closed
- Front Map/Courtesy Lamp - Incorrect Operation
- M/T - Shifter Squeak When Shifting
- A/T - Harsh 1-2/2-3 Upshifts and 3-2 Kickdown
- M/T - Vent Oil Leak
- Front Seat Adjuster Latch - Does Not Latch Smoothly
- Rear Seat Adjuster - Rattle
- Quad Seat Floor Attachment - Rattling Noise
- Manual Transaxle - Locked in Neutral or Reverse
- Front Seat Back - Squeaking Noise
- Left B Post Exhauster - Loose
- Factory Modifications
- Improved Performance
- Labor/Parts Updates
- Recommended Repairs
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 240695 - 05/05/95
- 237494 - 10/07/94
- 21-18-96 - 12/27/96
- 081595 - 04/07/95
- 080794A - 10/21/94
- Sliding Door Ajar Switch - Adjustment
- Cruise Control - Erratic During Initial Speed Set
- Radio Transmitter Equipment - Installation
- Radio Transmitting Equipment - Installation
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- Airbag - On/Off Switch Availability
- Airbag - ON/OFF Switches Availability
- A/C Ducts - Emit Musty Odors
- Electrical - Wire Splice Procedure Revision
- ABS - Left Front Speed Sensor Identification
- A/T - Vehicle Shudder During Torque Converter Operation
- A/T - Poor Shifting Quality
- A/T Pan Gasket - Reusable Design
- TCM - 41TE or 42LE A/T, Poor Shift Quality/Shudder
- Engine Controls - Flash Reprogramming Failure
- IAC Motor - Intermittent Rough Idle
- Heater - Poor Performance In Cold Temperatures
- Intake Valve Deposits - Engine Die Out/Sags/Rough Idle
- Tires/Wheels - Smooth Road Vibration/Shake/Wobble
- A/T - Vehicle Shudder During TC Lock-up
- A/T - 41TE/42LE Intermittent Delayed Engagement
- ABS - Bleeding Procedure, Manual Revisions
- Engine Coolant - Recommendations
- Fuse Block - Cracks
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Service Manual - Update
- Brakes - Noise Explanation
- A/C - System Sealer Usage Prohibition
- Crossmember/Alignment/Wheels/Tires - Vehicle Drifts Left
- Engine - Knocking When Cold
- IAC Motor - Intermittent Rough Idle When Cold
- Fuel Pump Module Connector - Service
- Fuel Pump Module - Wiring Connector
- Fuel Pump - High Pitched Noise
- Instruments - Calibration/Diagnostics Revisions
- AC Ducts - Emit Odors
- Low Heater Performance - Diagnosis/Repair
- A/C Compressor - Moaning Noise
- A/C - Evaporator Freezes Up/Lack Of Cooling
- A/C Evaporator - High Pitched Whistle Noise
- Instrument Panel Vents - Emit White Flakes
- Air Conditioning Ducts - Emits Musty Odor
- Cooling Module Fan - Vibrates/Comes Loose
- Heater - Poor Performance
- Front Coil Spring - Metallic Rapping Noise
- Front Suspension - Rapping Noise On Bumps
- Tire and Wheel - Runout
- Tires/Wheels - Smooth Road Vibration/Shake/Wobble.
- Tires/Wheels - Smooth Road Vibration/Shake
- Rear Leaf Springs - Floor Pan Ticking Noise
- Middle Row Seat - Interchangeability
- Rear Seat - High Sliding Effort
- Under Seat Storage Drawer - Cracks
- Headliner - Fastener Pins
- A/T - Slips In Reverse At Low Temperature
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- Speedometer - Inoperative
- A/T - Ratcheting Sound When Coming To Stop
- Engine - Overheats Under Heavy Load
- High Altitude Kit - Installation
- Door Ajar Lamp - Flickers/Locks Cycle Repeatedly
- ABS - Wheel Speed Sensor Applications
- Antilock Brake System - Wheel Speed Sensor Diagnosis
- ABS - Warning Light ON Continuously
- ABS - Kelsey Hayes EBC-5H, EBC 310 Test Revisions
- Engine Starter - Intermittent No Crank
- Diagnostic Connector - Change
- Engine Controls - Flash Programming Failure Recovery
- Fuel Tank - Slow To Fill
- Catalytic Converter - Excessive Sulfur Odor
- A/T - Harsh Shift At Low Speed/Speedo. Fluctuates
- A/T - Poor Shift Quality
- Speed Control Switch - Loose/Rattles
- Overhead Compass/Temperature - Manual Revision
- Radio - Locks Up During Operation
- Radio - Removal and Installation Procedure
- Radio Communication Equipment - Recommendations
- Recall 99V113000: Inadvertent Air Bag Deployment
- Instrument Panel - Squeak/Rattle From Right Side
- Recall - Inadvertent Airbag Deployment
- Airbag/Clock Spring - Service
- Stop Light Switch - Wiring Connector Service
- Airbag - Warning Light Illumination
- A/C System - Poor Cooling Performance
- A/C Hose - Squeaking Noise
- ABS - Component Identification, Manual Update
- ABS - Service Manual Revision
- ABS System - Revised Test Procedures
- Recall 00V305000: Steering Wheel Separation
- Tamper Resistant Ignition Key Cylinder - Revision
- Black Plastic Body Components - Chalky Residue
- Left B Pillar - Intermittent Creaking Noise
- Radio Transmitters - Installation
- Recall - Passenger Air Bag Safety
- Airbag - NHTSA Authorized Deactivation
- Air Bag System - Diagnostic Procedures Revisions
- Auto Computers - Y2K Effects
- Front Door - Sagging
- Front Door - Replacement Precautions
- Lift Gate Trim Panel - Cracked
- Campaign - Liftgate Latch
- Recall 95I001000: Rear Liftgate Latch Opens
- Recall 95I001001: Rear Liftgate Latch Opens In Collision
- Backlight/Windshield Moulding - Glue Oozing Out
- Windshield/Cowl - Squeak Elimination
- Wipers/Washers - Wipers Smear or Streak Windshield
- Body Cladding - Interferes With Use Of Jack
- Engine - Coolant Recommendations
- A/T - Shudder/Bumps/Slippage
- A/T - 41TE/42LE Cruise Control Interaction
- A/T - 41TE/42LE Interactive Cruise Control
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Failsafe Modes
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Linkage Adjustment
- Engine Mount - Squeak/Clunk Noise
- Serpentine Belt - Comes Off Pulleys, Driving in Snow
- Transmission Range Sensor - Production Change
- A/C, Heater - Temperature Lever Difficult to Move
- Speed Sensor - Intermittent Loss of Cruise Control
- Fuse Block - Rattle in Lower Left Dash Area
- Steering/Suspension - Lead Diagnosis Chart Revisions
- Engine - Oil Leak Diagnosis
- Wiring - Revised Splicing Procedure
- Electrical Connectors - Cleaning Precautions
- Electrical - Pin Outs and Graphics Revisions
- Speed Control - Adaptive Strategy
- Tires/Wheels - Radial Runout Specification Revision
- Middle Side Glass Vent Latch - Difficult Operation
- Vent Window - Latch Pops Open/Rattles/Pops Closed
- Electronic Cycling Clutch Switch - Availability
- Front Map/Courtesy Lamp - Incorrect Operation
- M/T - Shifter Squeak When Shifting
- A/T - Harsh 1-2/2-3 Upshifts and 3-2 Kickdown
- Ignition - Tamper Resistant Ignition Cylinder Addition
- M/T - Vent Oil Leak
- Front Seat Adjuster Latch - Does Not Latch Smoothly
- Rear Seat Adjuster - Rattle
- Quad Seat Floor Attachment - Rattling Noise
- R 134A Refrigerant - Leak Detection
- R 134A Refrigerant - Leak Detection Systems
- Spare Tire Winch - Operation Precautions
- Manual Transaxle - Locked in Neutral or Reverse
- Brakes - Bendix ABS System Bleeding Procedure Revision
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- Front Seat Back - Squeaking Noise
- Left B Post Exhauster - Loose
- A/T Pan Gasket - Reusable Design/Installation
- Restraints - Child Seat Tether Installation
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process