Alignment - Premature/Irregular Front and Rear Tire Wear

Bulletin No.
93-011

Issue Date
JAN 16, 1995

Model
1990-93
ACCORD

Applicable To
See VEHICLES
AFFECTED

FILE UNDER
SUSPENSION

Front and Rear Tire Wear
(Supersedes 93-011, dated October 24, 1994)

SYMPTOM

Premature and/or irregular wear on the front or rear tires.

VEHICLES AFFECTED
Ohio-produced cars:
1990 - 1993 Accord 4-Door DX (equipped with Goodyear tires) - Thru VIN IHGCB7... PA079739
1991 - 1993 Accord Wagon LX and EX -
Thru VIN 1HGCB9... PA003803

CORRECTIVE ACTION

Replace only the worn tires with the new tires listed (which have improved wear characteristics), and reset the front and rear toe. Inspect and reset the caster if necessary.

SERVICE ADVISOR

1. Inspect the tires for premature and/or irregular tire wear. If they are worn, discuss the following items with the customer.

^ Explain that you will replace the worn tires, on a pro rata basis, with tires having improved wear characteristics. In addition, the front and rear end alignment will be checked and adjusted.

^ Explain the importance of correct tire pressure, as stated in the Owner's Manual and on the driver's door jamb. Emphasize to wagon owners that the recommended rear tire pressure varies with loading.




^ Explain the importance of periodic tire rotation to increased tire life. Show the customer the tire rotation pattern below. This rotation pattern supersedes the information given in the Owner's Manual for these models.




2. Order the correct replacement tires from Goodyear (see the chart). Use only the tires listed. they have improved wear characteristics.

TECHNICIAN

1. Mount, balance, and install the new tires.

2. Check and adjust the front and rear wheel alignment according to the specifications shown.

3. Check the front caster. If it is less than +3°, adjust the caster as shown on page 18-4 of the 1993 Accord Service Manual.

TIRE PRORATION TABLE




AHM will pay, on a pro rata basis, for tires that need replacement due to premature or irregular wear. The full cost of mountin9 and balancing are reimbursed up to 36,000 miles.

WARRANTY CLAIM INFORMATION




In warranty: The normal warranty applies.

Out of warranty: Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Service Manager or your Zone Office. You must request consideration, and get a decision, before starting work.

Failed part: P/N 53540-SM4-003
H/C 3283249

Defect code: 005

Contention code: B99