Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Generals
- Safety
- Recall - Corrosion On Rear Lower Trailing Link Bracket
- Recall - Rear Lower Trailing Link Bracket Corrosion
- Recall - ABS Coil Integrated Module Replacement
- Recall - Negative Battery Cable Replacement
- Recall 00V058000: Rear Axle Lower Link Joint Nut, Bolt
- Recall - Rear Suspension
- Recall 97V206000: Driver's Side Optional Floor Mat
- Recall 97V206002: Rubber Floor Mat Defect
- Campaign - Trailer Harness Update
- Recall 10V436000: Rear Lower Control Arm Bracket
- Customer Interest
- Fuel/Engine Controls - MIL ON/DTC P1441
- Instrument Panel/Dashboard - Squeak/Rattle
- PCM Check - After Fuel Pump Replacement
- Brakes, Front - Noise (Squeal)
- Air Conditioner - Moaning Noise
- Air Conditioning - Inoperative
- Blower Motor - Will Not Run In One Or More Settings
- Vibration When Idling
- Front Tires - Rub On Mud Flap On Sharp Turns
- Front Seat, Recline Lever Handle - Comes Off
- Front Door Weatherstrip - Deformed
- Body - Door Seal Corner Out of Position
- Clockspring - Scraping Noise When Turning Steering Wheel
- Steering Column - Noise
- Drivetrain - Clicking Noise On Low Speed Turns
- Brakes - Pedal Pulsation, Noise
- Rear Brakes - Squeal Upon Application
- ABS - Light ON
- Ignition Switch - Won't Turn To The Lock Position
- Interior - Seat Belts Slow to Retract
- Fuel Gauge - Reads Low
- Front Floor - Clunk Noise
- Security Alarm - Activates
- Exhaust System - Passenger Seat Area Buzzing Noise
- Speakers - Whine During Cassette Player Use
- Speakers - Whining During Cassette Player Use.
- Radio - No Sound/Crackles/Fades/No Display
- Door Mirror - Cracks When Using The Defogger
- Fender Side Moulding - Comes Off
- Body - Air Deflector Rubs On Grille
- Rear Beverage Holder - Does Not Stay Closed
- Rough Idle And/Or Diagnostic Trouble Code (DTC) stored
- Audio Unit with CD Player/Changer - Error Codes
- Steering - Wheel Shimmy (Vibration)
- Vibration at Speeds Above 50 Mile Per Hour (MPH)
- Hatch Glass - Creak From The Rear Cargo Area
- A/T - Fluid Leak From the Accumulator Cover
- Rear Hatch - Will Not Open
- Moonroof - Visor Sags in The Middle
- Moonroof - Creaking Noise
- A/T Main Case Oil Plug - Fluid Leaks
- Rear Axle Seal(s) - Leak
- Steering/Suspension - Vehicle Pulls Left/Right
- Factory Modifications
- Manual Updates
- Recommended Repairs
- PCM Check - After Fuel Pump Replacement
- Brakes, Front - Noise (Squeal)
- Air Conditioner - Moaning Noise
- Air Conditioning - Inoperative
- Vibration When Idling
- Front Seat, Recline Lever Handle - Comes Off
- Steering Column - Noise
- Brakes - Pedal Pulsation, Noise
- ABS - Light ON
- Fuel Gauge - Reads Low
- Security Alarm - Activates
- Door Mirror - Cracks When Using The Defogger
- Fender Side Moulding - Comes Off
- Body - Air Deflector Rubs On Grille
- Rear Beverage Holder - Does Not Stay Closed
- Audio Unit with CD Player/Changer - Error Codes
- Steering - Wheel Shimmy (Vibration)
- Vibration at Speeds Above 50 Mile Per Hour (MPH)
- A/T - Fluid Leak From the Accumulator Cover
- Moonroof - Creaking Noise
- Rear Axle Seal(s) - Leak
- Safety
- Superceded Bulletins
- 12-003 - 01/05/12
- 90-011 - 05/02/09
- 89-022 - 06/18/04
- 99-018 - 04/20/06
- 02-025 - 11/12/2002
- 98-019 - 05/13/05
- 06-001 - 01/16/06
- 99-018 - 04/20/99
- 99-016 - 06/08/99
- 99-012 - 02/23/99
- 99-005 - 02/02/99
- 99-004 - 05/11/1999
- 98-059 - 08/10/98
- 98-011 - 02/05/02
- 97-015 - 08/31/99
- 98-010 - 06/23/98
- 89-029 - 05/06/96
- 86-020 - 06/08/99
- 02-038 - 08/20/02
- 01-029 - 03/20/01
- 01-007 - 07/03/01
- 00-088 - 04/03/01
- 00-088 - 08/14/02
- Required Special Tools And Equipment,
- Recommended Materials
- Service Publications and Supplies - Ordering Information
- Body - Recommended Repair Materials
- Body - Recommended Sealers And Adhesives
- Body - Recommended Sealers/Repair materials
- Paint - Codes And Cross references
- Rear Beverage Holder - Will Not Stay Closed
- Audio Unit - Warranty Exhange/Out of Warranty Repair
- Audio Unit - Warranty Exchange/Customer Pay Repair
- Radio - Audio Unit Error Code
- Audio/Navigation/RES - Warr. Exchange/Non-Warr. Repair
- Audio/Navigation/RES Unit - Warranty Exchange/Repair
- Audio/Entertainment/Navigation - Service/Warranty Info.
- Audio/Navigation/RES - Warr. Exchange/Non-Warr Repair
- Audio/Entertainment/Navigation - Service/Exchange
- Antitheft System - Key Code Duplicator
- Keyless Entry - Transmitter
- Keyless Entry - Transmitter ID/Programming
- Keyless Entry - Remote Transmitter Information
- Audio/Navigation/RES/iMID(R) - Warr Exchange/Non Warr Repair
- Restraints - Occupant Detection Initialization
- Restraint System - Occupant Detection Initialization
- 07-030 - 06/15/07
- Recall - Potential Rear Trailing Link Bracket Corrosion
- 10-079 - 02/11/11
- Recall - Lower Trailing Link Bracket Corrosion
- 10-079 - 12/10/10
- Electrical - GR8 Battery Diagnostic Station Update Info.
- Electrical - GR8 Battery Diagnostic Station Update
- Electrical - Battery Testing And Replacement
- Electrical - GR8(R) Battery Diagnostic Station Update
- Electrical - ED-18 Battery Analyzer Update Information
- Electrical - Battery Testing and Replacement
- Electrical - Battery Test Procedure/Equipment
- Battery - Testing Procedures
- Battery - Testing Procedure
- Disc Brake System - Brake Disc Refinishing Guidelines
- Brakes - Brake Disc Refinishing Guideline
- Brakes - Brake Disc Refinishing Guidelines
- Brake Discs - Refinishing Guidelines
- Brake Rotor - Refinishing Guidelines
- Campaign - ABS Lamp Comes On/Module Replacement
- CV Joint Boot - Band Tool
- Computers/Controls - Updating Control Units/Modules
- Computers/Controls - Module/Control Unit Updating
- Engine Controls - Updating ECM/PCM Software
- Computers/Controls - HIM Module Updating
- MIL ON - DTC P1441 Set
- Aftermarket OBD II Tester and Software Availability
- Exhaust System - Buzz From The Passenger Seat Area
- Exhaust Damper - Buzz From the Passenger's Seat Area
- Vehicle - Recommended Materials
- Transmission/Engine - Hydraulic Lift Truck Usage
- Vehicle - Recommended Service Materials
- Steering - Vehicle Pulls/Drifts to the Left/Right
- All Technical Service Bulletins
- A/T - New ATF DW-1 Available
- Restraints - OPDS Unit Initialization Procedure
- Vehicle - Recommended Service Materials/Sealers/Lubricants
- Recall - Corrosion On Rear Lower Trailing Link Bracket
- Recall - Rear Lower Trailing Link Bracket Corrosion
- Fuel/Engine Controls - MIL ON/DTC P1441
- Keyless Entry - Keyless Remote Transmitter Information
- Electrical - ED-18 Battery Analyzer Update Info.
- BULLETIN CANCELLATION NOTIFICATION
- Tools - Required Special Tools And Equipment
- Special Tool Loan Program
- Service Publications - Availability and Ordering
- ABS DTC C0265 Diagnostic Tip
- Instrument Panel/Dashboard - Squeak/Rattle
- Tools - Denso HLD-100 Halogen Leak Detector
- A/C - System Performance Testing
- A/C - Heater Blows Cold Air, A/C Blows Warm Air
- Engine/Transmission - Hydraulic Lift Truck usage
- Engine Oil Recommendations
- PCM Check - After Fuel Pump Replacement
- Brakes, Front - Noise (Squeal)
- Air Conditioner - Moaning Noise
- Air Conditioning - Inoperative
- Blower Motor - Will Not Run In One Or More Settings
- Blower (Heater) Motor Gets Hot and Blows A Fuse
- Owner's Manual - Timing Belt Interval Update
- Engine - Cylinder Head Service Supplement
- Vibration When Idling
- Front Tires - Rub On Mud Flap On Sharp Turns
- Front Seat, Recline Lever Handle - Comes Off
- Front Door Weatherstrip - Deformed
- Body - Door Seal Corner Out of Position
- Clockspring - Scraping Noise When Turning Steering Wheel
- Steering Column - Noise
- Drivetrain - Clicking Noise On Low Speed Turns
- A/T - Avoiding Fluid Contamination
- A/T - Fixing Banjo Bolt Leaks
- A/T - Identifying Shift Solenoids
- A/T - Do Not Remove Torque Converter From Mainshaft
- Drivetrain - Revised CV Joint Boot Band/Installation
- Brakes - Pedal Pulsation, Noise
- Rear Brakes - Squeal Upon Application
- ABS - Light ON
- Recall - ABS Coil Integrated Module Replacement
- Campaign - Alternator Replacement
- Recall - Negative Battery Cable Replacement
- Ignition Switch - Won't Turn To The Lock Position
- PCM- Smart Cable Programming Procedures
- Engine - High or Erratic Idle
- Recall - Evaporative Emissions System
- Catalytic Converter - Rotten Egg Smell
- Exhaust System - Catalytic Converter Noise
- Campaign - Accelerator Pedal Pad Replacement
- Interior - Seat Belts Slow to Retract
- Fuel Gauge - Reads Low
- ABS - DTC Erasure Without PGM Tester
- Recall 00V058000: Rear Axle Lower Link Joint Nut, Bolt
- Recall - Rear Suspension
- Front Floor - Clunk Noise
- Special Tool - Chassis EAR(TM), Diagnostic Tool
- Wind Noise - Simple Way To Replicate
- Supplemental Restraint System - Inspection
- Security Alarm - Activates
- Immobilizer Key - Key Code Duplicator
- Exhaust System - Passenger Seat Area Buzzing Noise
- Aftermarket On Board Diagnostic (OBD) II Tester
- Engine Controls - DTC Capture and Downloading
- Clearing DTCs and Setting ECM/PCM With The HDS
- Engine Controls - Clearing DTC's
- Speakers - Whine During Cassette Player Use
- Speakers - Whining During Cassette Player Use.
- Radio - No Sound/Crackles/Fades/No Display
- Windshield Wipers - Blade Care and Replacement
- Door Mirror - Cracks When Using The Defogger
- Fender Side Moulding - Comes Off
- Body - Air Deflector Rubs On Grille
- Rear Beverage Holder - Does Not Stay Closed
- Engine - Oil Recommendation GF-4 Standard
- Rough Idle And/Or Diagnostic Trouble Code (DTC) stored
- A/T - In-Warranty Exchange Program
- Audio Unit with CD Player/Changer - Error Codes
- Cruise Control - Service Manual Update, DTC 1-3
- Cruise Control - DTC Retrieval
- Steering - Wheel Shimmy (Vibration)
- Vibration at Speeds Above 50 Mile Per Hour (MPH)
- Recall 97V206000: Driver's Side Optional Floor Mat
- Recall 97V206002: Rubber Floor Mat Defect
- Hatch Glass - Creak From The Rear Cargo Area
- Audio System - Never Play CD's With Adhesive Labels
- Body - Minor Paint Finish Repair
- Paint - Codes/Cross References
- Campaign - Trailer Harness Update
- A/T - Fluid Leak From the Accumulator Cover
- Rear Hatch - Will Not Open
- Moonroof - Visor Sags in The Middle
- Moonroof - Creaking Noise
- Tools - New Fuel Pressure Gauge and Replacement Parts
- Brakes - Revised Brake Bleeding Procedure
- A/T Main Case Oil Plug - Fluid Leaks
- Body - Plastic Body Clip Removal Tips
- Torque Converter Oil Seal - Installation Tool
- Rear Axle Seal(s) - Leak
- Tires - Tubless Tire Repair Information
- Paint - Industrial Fallout Paint Damage
- Body - Unibody Repair Guidelines
- A/C - Refrigerant Leak Detection
- Steering/Suspension - Vehicle Pulls Left/Right
- Electrical - Battery Testing and Replacement Information
- Engine - Connecting Rod Damage Information
- A/C - Heater Blows Cold Air/A/C Blows Hot Air
- A/T - ATF Cooler Cleaner Information
- A/T - Vehicle Speed Sensor Installation Precautions
- Electrical - Battery Replacement Precautions
- Starting System - Unable To Key In Ignition Switch
- Computers/Controls - Initialization Procedure Info.
- Audio System - CD/DVD Precautions
- Interior - Fabric Upholstery Wrinkle Information
- Body - Chrome/Stainless Trim Staining Information
- Brakes - Brake Disc Refinishing Information
- Recall 10V436000: Rear Lower Control Arm Bracket
- A/T - Cooler Flushing Equipment Information
- Electrical - GR8 Battery Diagnostic Station Update Information
- Audio,Navigation, RES - Warr. Exchange/Non-Warr. Repair