Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall- Headlamp Low Beams Inoperative
- Recall 12V136000: Headlamp Low Beams Inoperative
- Recall - Replacement Driver Air Bag Over-Pressurization
- Recall - Inspect/Replace SRS Cable Reel Connector
- Recall 11V260000: Potential Replacement Air Bag Defect
- Recall - Throttle Cable Drum Contamination
- Recall - A/T Shift Cable Control Pin Corrosion
- Recall 03V274000: A/T Shift Cable Corrosion
- Recall 04V255000: Air Bag Harness Defect
- Recall 12V486000: Master Power Window Switch Melting
- Recall - Possible Power Window Switch Melting/Fire
- Recall 13V132000: Passenger Air Bag Defect
- Customer Interest
- Body - Rear Door Molding Scrapes the Front Door
- Engine Controls - MIL ON/DTC P1163 Is Stored In Memory
- Engine Controls/Fuel Sys - Stalling/Stumbling After Stop
- Engine Controls/Fuel System - MIL ON/DTC P0122 Set
- Brakes - Front Brake Clicking Noise
- Brakes - Rear Clicking Noise
- Suspension - Front Suspension Knocking Noise
- Steering/Suspension - Vehicle Pulls Right
- Body - Front Window Grinding Noise During Operation
- A/T, M/T - Vibration Accelerating From a Stop
- Engine, M/T, A/T - Grind/Rattle on L/H Turns
- M/T - Clutch Pedal Squeak/Twang or Notchy Feel
- Antitheft System - Alarm Will Not Arm/Arms By Itself
- Interior - Seat Belts Slow to Retract
- Fuel/Emissions - MIL ON/DTC P01456 (EVAP System)
- Electrical - DTC P1298 Stored in ECM/PCM
- Restraints - Rear Seat Belt Retractor Rattles/Squeaks
- Lighting - Rear Ceiling Light Flickers
- Lighting - Glove Box Lamp Stays ON
- Body - Door Lock Cylinders Bind
- Body - Door Glass Comes Out of Run Channel
- Restraints - Child Seat Anchor Locating Button Missing
- Cooling System - Engine Growling Noise
- Body - Water Leaks to The Interior From Behind Dash
- Emissions - MIL ON/DTC P1457 Set
- Steering/Suspension - Vehicle Pulls Left/Right
- A/C - System is Inoperative
- Drivetrain - Rear Differential Moaning/Groaning On Turns
- Engine - MIL ON, DTC's P2646/P2651 Or P2647/P2652
- Body - Windshield Side Trim Retainer is Loose or Broken
- Superceded Bulletins
- 90-011 - 05/02/09
- 89-022 - 06/18/04
- Campaign - Extension of The Vehicle Warranty
- 99-018 - 04/20/06
- Campaign - Vehicle Warranty Extension
- 02-025 - 11/12/2002
- 98-019 - 05/13/05
- 06-001 - 01/16/06
- 01-077 - 01/12/05
- 98-011 - 02/05/02
- 04-077 - 12/09/04
- Body - Front Door Glass Out of Run Channel
- Body - Front Door Glass Comes Out of Run Channel
- 12-067 - 10/16/12
- 12-067 - 10/05/12
- Recall - Power Window Master Switch Replacement
- Recall - Headlamp Low Beams Inoperative
- Campaign - Warranty Extension For Odometer Inaccuracy
- Body - Recommended Repair Materials
- Body - Recommended Sealers And Adhesives
- Body - Recommended Sealers/Repair materials
- Body - Door Lock Cylinder Binds/Sticks
- Body - Door Lock Cylinder Binds
- Body - Door Lock Cylinder Binding
- Audio/Navigation/RES - Warr. Exchange/Non-Warr. Repair
- Audio/Navigation/RES Unit - Warranty Exchange/Repair
- Audio/Entertainment/Navigation - Service/Warranty Info.
- Audio/Navigation/RES - Warr. Exchange/Non-Warr Repair
- Audio/Entertainment/Navigation - Service/Exchange
- 12-070 - 03/21/13
- Antitheft System - Immobilizer System (Type 3)
- Antitheft System - Type 3 System Operation/Programming
- Keyless Entry - Transmitter ID/Programming
- Keyless Entry - Remote Transmitter Information
- Antitheft System - Won't Arm or Arms By Itself
- Audio/Navigation/RES/iMID(R) - Warr Exchange/Non Warr Repair
- Restraints - Occupant Detection Initialization
- Campaign - OPDS Unit/Sensor Warranty Extension
- SRS - Indicator Lamp ON/Multiple DTC's Set
- Campaign - OPDS Unit Warranty Extension
- Campaign - OPDS Sensor/Unit Warranty Extension
- Recall - SRS Cable Reel Replacement
- 10-039 - 12/08/11
- Recall -Driver Air Bag Inflator Can Be Over-Pressurized
- 10-039 - 05/17/11
- Recall - Inspect/Replace SRS Cable Reel Connector
- Recall - SRS Cable Reel Connector
- 07-030 - 06/15/07
- A/C - System Does Not Operate
- A/C - Air Conditioning System Is Inoperative
- A/C - System Inoperative
- Suspension - Front Suspension Knocking on Bumpy Roads
- Steering/Suspension - Vehicle Drifts to The Right
- Electrical - GR8 Battery Diagnostic Station Update Info.
- Electrical - GR8 Battery Diagnostic Station Update
- Electrical - Battery Testing And Replacement
- Electrical - GR8(R) Battery Diagnostic Station Update
- Electrical - ED-18 Battery Analyzer Update Information
- Electrical - Battery Testing and Replacement
- Electrical - Battery Test Procedure/Equipment
- Battery - Testing Procedures
- Battery - Testing Procedure
- Disc Brake System - Brake Disc Refinishing Guidelines
- Brakes - Brake Disc Refinishing Guideline
- Brakes - Rear Brake Grinding Noise
- Brakes - Rear Brake Clicking Noise
- Brakes - Front Caliper Clicking Noise
- Drivetrain - Rear Differential Moan/Groan
- M/T - Squeak/Twang At Clutch Pedal
- M/T - Clutch Pedal Noise/Notchy Feel
- Recall - Throttle Drum Contamination
- Computers/Controls - Updating Control Units/Modules
- Computers/Controls - Module/Control Unit Updating
- Engine Controls - Updating ECM/PCM Software
- Computers/Controls - HIM Module Updating
- Fuel/Emissions - Fuel Cap Binding/MIL ON/DTC P1456
- Recall - Excessive A/T Shift Cable Corrosion
- Recall - A/T Shift Cable Corrodes
- Recall - A/T Shift Cable Pin Corrosion
- Engine Controls/Emissions - OBD II DTC's and Monitors
- Engine Control - MIL ON, DTC P1163
- Engine Controls - MIL ON with DTC P1163 (A/F Sensor)
- Fuel System - MIL ON/DTC's P0451/P0452/P0453/P1454
- Engine Controls - DTC P1298 Stored in Memory
- Engine Controls - MIL ON/DTC P1163 Stored
- Engine Controls - Engine Stumble/Stall After Stopping
- Computers/Controls - Updating Modules/Control Units
- Computers/Controls - Updating Control Units And Modules
- Computers/Controls - Control Unit/Module Reprogramming
- Computers/Controls - Updating Modules/Control Units
- Engine Controls - Control Module Programming Procedure
- Vehicle - Recommended Materials
- Engine/Transmission Mount - Noise on Left Turns
- Vehicle - Recommended Service Materials
- Campaign - Engine Oil Filter Installation Inspection
- Steering/Suspension - Vehicle Pulls Right/Left
- Steering/Suspension - Vehicle Pulls/Drifts To One Side
- Steering/Suspension - Vehicle Pull/Drift To One Side
- Drivetrain - Rear Differential Moan/Groan On Turns
- Steering - Vehicle Pulls/Drifts to the Left/Right
- Drivetrain - Rear Differential Moan or Groan
- Drivetrain - Rear Differential Moans/Groans On Turns
- A/C - System Is Inoperative
- Engine Controls - Engine Stall/Stumble After a Stop
- Engine Controls - Engine Stumbles/Stalls After a Stop
- All Technical Service Bulletins
- Body - Rear Door Molding Scrapes the Front Door
- A/T - New ATF DW-1 Available
- Campaign - OPDS Unit Warranty Extension
- Restraints - OPDS Unit Initialization Procedure
- Vehicle - Recommended Service Materials/Sealers/Lubricants
- Recall- Headlamp Low Beams Inoperative
- Recall 12V136000: Headlamp Low Beams Inoperative
- Recall - Replacement Driver Air Bag Over-Pressurization
- Engine Controls - MIL ON/DTC P1163 Is Stored In Memory
- Engine Controls/Fuel Sys - Stalling/Stumbling After Stop
- Recall - Inspect/Replace SRS Cable Reel Connector
- Keyless Entry - Keyless Remote Transmitter Information
- Recall 11V260000: Potential Replacement Air Bag Defect
- Electrical - ED-18 Battery Analyzer Update Info.
- BULLETIN CANCELLATION NOTIFICATION
- Tools - Required Special Tools And Equipment
- ABS Indicator On With ABS DTC 54 Or No DTC(s)
- ABS DTC 51 Or 53 - Diagnostic Tip
- ABS - Grunts When Doing A Self-Check
- Gauges - Eratic Gauges Or Odd Odometer Display
- Maintenance Required Indicator Doesn't Reset
- Odometer - Does It Rack Up Miles When Towed
- A/C - System Performance Testing
- A/C - Indicator Should Stay Off in Defrost Mode
- A/C - Rattle Or Buzz Accelerating With A/C On
- A/C - Poor Cooling During Hard Acceleration
- A/C - Heater Blows Cold Air, A/C Blows Warm Air
- Engine Oil Recommendations
- Drive Belt Noise? Could Be A Bad Water Pump Bearing
- Battery Goes Dead When Towing With A Motorhome
- Engine Controls/Fuel System - MIL ON/DTC P0122 Set
- Gas Tank - Fuel Pump/Sending Unit Installation Tip
- Brakes - Front Brake Clicking Noise
- Brakes - Rear Clicking Noise
- Blower (Heater) Motor Gets Hot and Blows A Fuse
- Suspension - Front Suspension Knocking Noise
- Steering/Suspension - Vehicle Pulls Right
- Wheel Bearing - Correct Installation To Prevent DTC's
- Wheel Bearings - Humming Or Growling
- Balancer Shaft Buzz Or Rattle Is Normal
- Body - Front Window Grinding Noise During Operation
- A/T, M/T - Vibration Accelerating From a Stop
- Engine, M/T, A/T - Grind/Rattle on L/H Turns
- Differential - Moans With Brakes Applied At Low Speeds
- A/T - Leak From Cooler Line Banjo Bolt
- A/T - Avoiding Fluid Contamination
- A/T - Fixing Banjo Bolt Leaks
- A/T - Do Not Remove Torque Converter From Mainshaft
- M/T - Clutch Pedal Squeak/Twang or Notchy Feel
- Drivetrain - Revised CV Joint Boot Band/Installation
- Brakes - Rear Brake Grinding Noise
- Recall - Throttle Cable Drum Contamination
- A/T - Stuck In Park After Throttle Body Replacement
- Catalytic Converter - Rotten Egg Smell
- Exhaust System - Catalytic Converter Noise
- Key Beeper, Light Chime and Ceiling Light Don't Work
- Antitheft System - Alarm Will Not Arm/Arms By Itself
- Interior - Seat Belts Slow to Retract
- Driver's Air Bag - Replace Torx Bolts Properly
- Campaign - Oil Filter Campaign Cancellation
- Clicking Or Ratcheting Noise On Hard Right Turn
- Suspension - Drifting and Pulling At Highway Speeds
- Center Dash Pocket Removal
- Interior and Exterior Trim - Tool To Make Removal A Snap
- Air Fresheners - Bad News For Paint Or Plastic
- Water Leak From Door. Check Rain Protector
- Roof Rack - Wind Noise
- Wind Noise - Simple Way To Replicate
- Accessory Security System - Troubleshooting
- Audio Unit - Electronically Retrieving Serial Numbers
- Audio Unit - Models Which Are Electronically Retrieval
- Restraints - SRS DTC 15-3, Service Manual Revision
- Emissions - DTC P1457 Possible Clogged Line
- Fuel Filler Cap Adapter Available For Testing Emissions
- Recall - A/T Shift Cable Control Pin Corrosion
- Fuel/Emissions - MIL ON/DTC P01456 (EVAP System)
- Clearing DTCs and Setting ECM/PCM With The HDS
- Electrical - DTC P1298 Stored in ECM/PCM
- Engine Controls - DTC P0171 Set
- Engine Controls - DTC P0172
- Engine Controls - Clearing DTC's
- Engine Controls - DTC P2646, P2647
- Windshield Washer Nozzle Troubleshooting
- Restraints - Rear Seat Belt Retractor Rattles/Squeaks
- Windshield Wipers - Blade Care and Replacement
- Engine - Oil Recommendation GF-4 Standard
- A/T Whine - Test Drive Tip
- A/T - Don't Test Drive With The MIL Or D Indicator On
- A/T - Harsh Or Noisy Downshifts When Slowing Down
- Recall 03V274000: A/T Shift Cable Corrosion
- Lighting - Rear Ceiling Light Flickers
- Dashboard Switch Not Lit,? Replace Bulb, Not Switch
- M/T - Hard To Shift Into 1st Gear, Grinds Into Reverse
- Audio System - Never Play CD's With Adhesive Labels
- Body/Frame - Universal Subframe Removal Adapter
- Lighting - Glove Box Lamp Stays ON
- Body - Door Lock Cylinders Bind
- Ignition/Locks - Cutting Sidewinder-Type Keys
- Ignition Keys Gets Warm While Driving
- Body - Door Glass Comes Out of Run Channel
- Recall 04V255000: Air Bag Harness Defect
- Restraints - Child Seat Anchor Locating Button Missing
- Body - Plastic Body Clip Removal Tips
- Cooling System - Engine Growling Noise
- Tires - Tubless Tire Repair Information
- Seats - Rear Seat Won't Fold Up
- Fuel System - MIL ON/DTC P0451/P0452/P0453/P1454
- Paint - Industrial Fallout Paint Damage
- Body - Water Leaks to The Interior From Behind Dash
- Body - Unibody Repair Guidelines
- Music Link(R) - System Information/Diagnostics
- A/C - Refrigerant Leak Detection
- Emissions - MIL ON/DTC P1457 Set
- Campaign - Vehicle Warranty Mileage Extension
- Steering/Suspension - Vehicle Pulls Left/Right
- Electrical - Battery Testing and Replacement Information
- Engine - Connecting Rod Damage Information
- A/C - Heater Blows Cold Air/A/C Blows Hot Air
- A/T - ATF Cooler Cleaner Information
- Emissions - OBD II DTC's And Associated Monitors
- A/T - Vehicle Speed Sensor Installation Precautions
- Electrical - Battery Replacement Precautions
- Starting System - Unable To Key In Ignition Switch
- Computers/Controls - Initialization Procedure Info.
- Engine Controls - Test Drive Precautions
- Audio System - CD/DVD Precautions
- Electrical - Auxiliary Power Socket Overload
- Interior - Fabric Upholstery Wrinkle Information
- Body - Chrome/Stainless Trim Staining Information
- Brakes - Brake Disc Refinishing Information
- A/C - System is Inoperative
- Drivetrain - Rear Differential Moaning/Groaning On Turns
- A/T - Cooler Flushing Equipment Information
- Recall 12V486000: Master Power Window Switch Melting
- Recall - Possible Power Window Switch Melting/Fire
- Electrical - GR8 Battery Diagnostic Station Update Information
- Recall 13V132000: Passenger Air Bag Defect
- Antitheft - Immobilizer System (Type 3) Information
- Overview
- Immobilizer System Components
- ECM/PCM
- Adding Programmed Ignition Keys
- Replacing All Programmed Ignition Keys
- Clearing Transponder Codes of Lost Programmed Ignition Keys
- Starting The Engine Without A Programmed Ignition Key
- Replacing The Immobilizer Control Unit Receiver
- Replacing the ECM/PCM
- Customer Situation and Required Items Chart
- Engine - MIL ON, DTC's P2646/P2651 Or P2647/P2652
- Computers/Controls - Updating Control Units/Modules
- Audio,Navigation, RES - Warr. Exchange/Non-Warr. Repair
- Cell Phone - Programmable HFL (HFT) Unit Update Info.
- Body - Windshield Side Trim Retainer is Loose or Broken