Interior - Sunvisor Rattles
06-079December 8, 2006
Applies To:
2006 Ridgeline - ALL
Sunvisor Rattles
(Supersedes 06-079, dated October 20, 2006, to update the information marked by asterisks)
SYMPTOM
The sunvisor rattles while driving with it clipped into its holder (the rattle stops if it's unclipped).
PROBABLE CAUSE
The sunvisor holder isn't strong enough to clamp the sunvisor.
CORRECTIVE ACTION
Replace both sunvisor holders. Make sure you use the holder color that matches the vehicle's interior.
PARTS INFORMATION
Holder:
P/N 88217-SDB-A01ZA, H/C 7588460 (Gray)
P/N 88217-SDB-A01ZP, H/C 7942246 (Beige)
P/N 88217-SDB-A01ZN, H/C 7942238 (Green)
WARRANTY CLAIM INFORMATION
Operation Number: 8401A9
Flat Rate Time: 0.2 hour
Failed Part: P/N 88217-SDB-A01ZA,
H/C 7588460
Defect Code: 07801
Symptom Code: 07302
*Template ID: 06-079A (Gray)
06-079B (Beige)
06-079C (Green)*
Skill Level: Repair Technician
Out of warranty:
Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Parts and Service Manager or your Zone
Office. You must request consideration, and get a decision, before starting work.
REPAIR PROCEDURE
1. Unclamp the sunvisor from the holder, and move the sunvisor out of the way.
2. Using a flat-tip screwdriver, push in on the hook, turn the holder 90 degrees, then pull it out.
3. Insert the new holder as shown, then turn the holder 90 degrees to lock it into place.
4. Repeat steps 1 to 3 for the other side.
Disclaimer