Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall - Excessive Vapor Pressure in Fuel Tank
- Recall - Cruise Control Not Functioning Properly
- Recall 90V035000: Cruise Control Actuator Defect
- Recall 90V123000: Excessive Fuel Tank Vapor Pressure
- Recall - R351 Purge Kit installation
- Recall - Cruise Control Defect
- Recall 85V087000: Fuel Hose/Clip Fittings
- Customer Interest
- Radio - Intermittent Left Channel Operation
- Engine - Oil Leaks
- Radiator - Air Flow Restriction
- Tires - Vibrations, Flat Spotting
- Hood Gas Strut - Poor Support When Fully Open
- A Post - Water Leaks and Wind Noise
- ECU Vacuum Pipe - Knocking Noise
- ECU Manifold Vacuum Hose - Detached
- Fuel Rail Hose Clip - Torque Increased
- AM Band Radio - Interference
- Front Upper Suspension - Knock/Creak Noise
- Backup Lights - Moisture Ingress
- Windshield Wiper - Smearing
- Trip Computer - Erratic Fuel Mileage Readings
- A/T - Leak Due to Blocked Vent Pipe
- Seals, Gaskets
- Superceded Bulletins
- All Technical Service Bulletins
- Closed Service Actions - No Longer Warrantied
- VIN and Certification Plates/Labels - Location/Replace
- Two Methods For Recovering/Towing
- Tools - Introduction of Tool Board Overlay Kit
- Service Literature - Availability
- Maintenance - Schedule Update
- Wiring Diagrams - Correct Source Information
- VIN and Certification Labels - Replacement
- Recall - Excessive Vapor Pressure in Fuel Tank
- Campaign - Excessive Fuel Tank Vapor Pressure
- Low Coolant Probe - Relocated
- Radio - Intermittent Left Channel Operation
- A/C - Diagnosis Repair Noise and Leaks
- Tool - A/C Compressor Thermal Fuse Tester
- Mk. III Air Conditioning - Revised
- R134a Retrofit Kits - Available
- A/C - Flap Adjustment
- A/C Compressor Thermal Fuse - Failure
- R-134a Retrofit Kits - Available
- Evaporator Assembly - Modifications
- Steering Rack - Additional Items Required for Overhaul
- Upper Steering Column - No Adjustment Permitted
- Steering Racks - Reconditioned Available
- Steering Column - Squeak, Recommended Lubrication
- Tool - Steering Rack Bushing Replacement
- Steering Column - Suitable Lubricant For Squeak
- PDU - Vibration Analyzer
- Engine - Oil Leaks
- Cooling System - Antifreeze Leaks
- Cooling System - Preventing Antifreeze Leaks
- Lucas MF3 Battery - Maintenance and Charging Procedures
- Low Maintenance Battery - Revised
- Battery - Readings For Testing Component Drain
- No Start May Be Caused By Vacuum Signal Line
- Spark Plug Gap - Specification
- Spark Plugs - Factory Approved Replacements
- Front, Rear Hub - Lubrications Maintenance Service
- Metric Cylinder Heads - Introduced
- Engine - Correct Pistons and Liners Replacement
- Engine Crankcase - Sealing Oil Leaks
- Engine - Oil Sump Sandwich Plate Gasket Sealing
- New Oil Pump - Available
- Radiator - Damage By Incorrect Removal and Installation
- Radiator - Air Flow Restriction
- Tool - Rear Main Seal
- Piston Ring End Gap - Correction to Specification
- Lower Ball Joint Bolts - Different Thicknesses
- Tires and Wheels - Non Standard Fitting Policy
- Road Wheel - Removal and Replacement Tips
- Snow Tire - Recommendations
- Wheel Alignment - Tire Wear/Handling Problems
- Tires - Vibrations, Flat Spotting
- Tires - Pirelli P5 Replaced by P4000 Super Touring Tire
- Hood Gas Strut - Poor Support When Fully Open
- A Post - Water Leaks and Wind Noise
- ECU Vacuum Pipe - Knocking Noise
- ECU Manifold Vacuum Hose - Detached
- Fuel Injector - On Vehicle Flow Test
- Tools - Fuel Injector Cleaning Procedures
- Tools - Fuel Injection Pulse Duration Tester
- Fuel Rail - Single Injector Replacement Not Possible
- Tool - Remove Tamper Proof ECU Plug
- Lambda Oxygen Sensor - Contamination
- Cold Start Kit - Has Wrong Vacuum Valve
- Fuel System - Conditions for CO Adjustment
- Front Hub End Float - New Specification and Adjustment
- Charging System - Checks
- Alternator Warning Light Circuit - Location of Resistor
- Fuel Rail Hose Clip - Torque Increased
- Engine - To Prevent Hesitation
- Catalyst and Cannister - Replacement Interval
- Antenna Mast - Cleaning and Replacement
- Antenna - Revised to Prevent Damage
- Electric Antenna - Repair Tips
- Recall - Cruise Control Not Functioning Properly
- Recall 90V035000: Cruise Control Actuator Defect
- AM Band Radio - Interference
- Radio - Reception Information
- Oil Filter - Changing When Sandwich Plate Is Removed
- Oil Filter - Shorter Improved Clearance
- Tool - Lucas Electronic Ignition Analyzer Available
- Oil Pressure Transmitter - Revised Tightening Torque
- Speedometer - Needle Flicker With Vehicle Standing
- Front Upper Suspension - Knock/Creak Noise
- Tool - Rear Suspension Wishbone Removal
- Suspension - Geometry Specification
- Body and Frame - Water Leaks Wind and Noise
- Paint - Scratches, Swirl Marks, Other Surface Damage
- Trip Computer - More In Depth Checking Procedures
- Trip Computer - Notes to Assist in Fault Diagnosis
- Trip Computer - Change in ECU Pin
- Backup Lights - Moisture Ingress
- Tools - Exhaust Emission Checking Attachment
- Recall 90V123000: Excessive Fuel Tank Vapor Pressure
- Recall - R351 Purge Kit installation
- Tool - Fuel Injection Tester
- Trunk Lid Lock Friction Plate - Revised
- Windshield - Cleaning to Prevent Streaking
- Washer Additive Quantities
- Trunk Lock Security - Revised
- Trunk - Procedure for Additional Ventilation
- Windshield Wiper - Smearing
- Ashtray Lid - Spring Detached
- Coolant System - Using Phosphate Free Anti Freeze
- A/T - THM 200/200C, 400, 700R4 Speedometer Leak
- A/T - 3L80/THM 400 Center Support Bolt
- A/T - 700-R4 and 400 Improved Governor Driven Gear
- A/T - Torque Converter Identification
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - Recurrent Sticking Valves/In Line Filters
- A/T - THM 400 Rear Band Adjustment Too Loose
- A/T - Rapid Converter Pump Bushing Wear
- A/T - Methods to Check for Restricted Exhaust
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - THM 400 Too Sensitive 3-2 Downshift
- A/T - No Upshift/Governor Contamination
- A/T - THM 400 No Reverse
- A/T - THM Steel Clutch Piston Inspection
- A/T - Sprag Rotation
- A/T - Checking Pressure Switches For Leaks
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Electric Antenna - Short Link Harness Deleted
- Service Interval Counter - Location Change
- Drive Belt Tension - Adjustment Requirements
- Oil Filter Housing Gasket - Revised
- Trip Computer - Erratic Fuel Mileage Readings
- Engine - Poor Operation Due to Poor Engine Ground
- Engine Wiring Harnesses - Part Numbers
- Tools - Testing Damaged Cruise Control Circuit Boards
- Recall - Cruise Control Defect
- Tools - Wheel Alignment Setting
- Suspension - Alignment Specifications
- Wood Veneer Panels - Repair Process
- Wood Veneer Repair Program
- Brake Fluid - Replacement Schedule
- Trip Computer - Reset After Highest Number
- A/T - Leak Due to Blocked Vent Pipe
- Tappet Block to Cylinder Head Joint - Sealant
- Recall 85V087000: Fuel Hose/Clip Fittings
- Interior - Approved Cleaning Products
- Body - Windshield Damage Diagnostic Guide
- Engine Controls - Removal of Seized Oxygen (O2) Sensors