Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Safety
- Recall - A/T Secondary Shifter Detent Installation
- Recall 97V080000: Unexpected Air Bag Deployment
- Recall - Airbag Control Module
- Overview
- Service Procedure For Neon (PL) Vehicles:
- Service Procedure For Dakota (AN) Vehicles:
- Service Procedure For Wrangler (TJ) Vehicles:
- Service Procedure For Grand Cherokee (ZJ) Vehicles:
- Service Procedure For Viper GTS Coupe (SR) Vehicles:
- Completion Reporting and Reimbursement / Parts Return
- Vehicle Not Available
- Dealer Service Instructions
- Owner Letter
- Recall 00V136000: Front Disc Brake Rotor Corrosion
- Recall 97V194000: Defective Fuel Gauge Sender
- Recall - Fuel Tank Sending Unit
- Recall 97V194000: Fuel Level Sending Unit Defect
- Recall - Passenger Air Bag Safety
- Recall - Front Brake Rotor Corrosion
- Recall 02V053000: A/T Shifter Not Fully Engaged In Park
- Customer Interest
- A/C - Cycles to OFF When Ignition Is Turned OFF
- Front Brakes - One Click on Initial Application
- Front Brakes - Pedal Pulsation
- A/C Heater - Mode Change to Defrost During Acceleration
- Engine - Spark Knock/Oil Consumption
- Rear Axle - Carrier Bearing Growl
- A/T - Overdrive Unavailable in Cold Temperatures
- Radio/CD Player - Erratic Channel/Track Changes
- PCM - MIL ON/Erroneous DTC P1398 (or $BA)
- MIL ON, Erroneous DTC P0107 Set
- PCM - Light Spark Knock Condition
- PCM - Erroneous MIL ON/Driveability Improvements
- PCM - Erroneous MIL, and/or Driveability Concerns
- I/M Testing - OBDII CARB Readiness Monitor Information
- TCM - MIL ON/DTC P1763 Set
- Liftgate Ajar Switch - Terminal Corrosion
- Fuel Gauge - Inaccurate
- Black Plastic Body Components - Chalky Residue
- Rear Door Speaker - Buzz
- Doors/Locks - Inoperative/Binding
- Sun Roof - Inoperative/Stuck
- Windshield Area - Wind Noise
- Wipers/Washers - Wipers Smear or Streak Windshield
- Radio/CD Player - Inoperative
- Ignition System - Cross Fire/Ignition Wire Induction
- A/T - Buzz/Whining in Reverse When Cold
- A/T - Engine Bucking/Surging at 5,300 Rpm
- Heated Seat - Inoperative
- Door Locks - Cycle When Rear Defogger is Turned Off
- RKE Transmitter - Premature Battery Failure
- Door Check Roller - Worn/Broken/Missing
- A/C Evaporator - Emits Odors
- LDP - MIL ON, DTC P1494 Set
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 18-05-00A - 06/23/00
- 08-19-97 - 05/09/97
- Outside Rearview Mirror Glass - Replacement
- Outside Mirror - Glass Replacement
- Radio Transmitting Equipment - Installation
- CD Player - Inoperative
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- Airbag - On/Off Switch Availability
- Airbag - ON/OFF Switches Availability
- Electrical - Wire Splice Procedure Revision
- Brakes - Pedal Pulsation
- Transfer Case Shifter - Thumping/Bumping Noise
- A/T - Diagnostic Teardown Procedures
- A/T - Diagnostic Tear-Down Procedure
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- A/T - Cold Weather Trans Cooler Bypass Kit
- Leak Detection Pump - Dealer Test Mode
- Engine Controls - Flash Reprogramming Failure
- Engine Controls - Co-Pilot Support/Cable Selection
- PCM - Flash Programming Failure Recovery
- Engine - Spark Knock/Excessive Oil Consumption
- A/T - Fluid Usage
- A/T - ATF Usage List
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Brakes - Noise Explanation
- A/C/Electrical - Systems Test Revisions
- A/C - Cycles to OFF When Ignition Is Turned OFF
- A/C - System Sealer Usage Prohibition
- Fuel/Engine Controls - Injector Circuit/TPS Revisions
- Engine Controls/Emissions/A/T - Manual Updates
- Front Brakes - One Click on Initial Application
- Front Brakes - Pedal Pulsation
- A/C/Electrical - Blower Motor/Wiring Diagram Revisions
- Front Hub Seals - Grease Purge Explanation
- A/C Heater - Mode Change to Defrost During Acceleration
- A/C - Air Door Motor Service Procedure Revisions
- Engine - Spark Knock/Oil Consumption
- Front End Alignment - Adjustable/Offset Ball Joints
- Tire and Wheel - Runout
- Roof/Sun Roof - Water Leaks
- Roof/Sunroof - Water Leaks
- Rear Axle - Carrier Bearing Growl
- A/T - Overdrive Unavailable in Cold Temperatures
- A/T Cooler - Reverse Flush With Bypass Kit Installed
- A/T - Quick Connect Removal and Reconnect Procedure
- Recall - A/T Secondary Shifter Detent Installation
- PCM - Wire Harness Connector Repair Package
- Powertrain Control Module - Service Precaution
- Engine Controls/Electronics/Emissions - Manual Revisions
- Radio/CD Player - Erratic Channel/Track Changes
- Body Control Module - Check Sum Error Fault
- ABS - Kelsey Hayes EBC-5H, EBC 310 Test Revisions
- Brakes - Teves Mark IV/Teves Mark 20 ABS Revisions
- PCM - MIL ON/Erroneous DTC P1398 (or $BA)
- MIL ON, Erroneous DTC P0107 Set
- PCM - Light Spark Knock Condition
- PCM - Erroneous MIL ON/Driveability Improvements
- PCM - Erroneous MIL, and/or Driveability Concerns
- I/M Testing - OBDII CARB Readiness Monitor Information
- Engine Controls - Flash Programming Failure Recovery
- TCM - MIL ON/DTC P1763 Set
- Liftgate Ajar Switch - Terminal Corrosion
- Radio Communication Equipment - Recommendations
- Recall 97V080000: Unexpected Air Bag Deployment
- Airbag/Clock Spring - Service
- Driver Airbag - Trim Cover Service
- Recall - Airbag Control Module
- Overview
- Service Procedure For Neon (PL) Vehicles:
- Service Procedure For Dakota (AN) Vehicles:
- Service Procedure For Wrangler (TJ) Vehicles:
- Service Procedure For Grand Cherokee (ZJ) Vehicles:
- Service Procedure For Viper GTS Coupe (SR) Vehicles:
- Completion Reporting and Reimbursement / Parts Return
- Vehicle Not Available
- Dealer Service Instructions
- Owner Letter
- Recall 00V136000: Front Disc Brake Rotor Corrosion
- Recall 97V194000: Defective Fuel Gauge Sender
- Fuel Gauge - Inaccurate
- Recall - Fuel Tank Sending Unit
- Recall 97V194000: Fuel Level Sending Unit Defect
- ABS/TCS - Diagnostic Test Revisions
- Brakes - Teves Mark IVG and Mark 20 ABS Revisions
- Brakes - Kelsey Hayes ABS Manual Revisions
- Brakes - ABS Diagnostic Procedures Revision
- Brakes - Kelsey-Hayes ABS System Diagnostic Revisions
- Brakes - Bendix ABX 4 ABS System Test Revisions
- Black Plastic Body Components - Chalky Residue
- Lighting - Pulse Width Dimming Test Revision
- Recall - Passenger Air Bag Safety
- Airbag - NHTSA Authorized Deactivation
- Antitheft Systems - Test Procedures Revisions
- Leak Detection Pump - Monitor Test
- Evaporative System - Leak and DTC Diagnostics
- Auto Computers - Y2K Effects
- Generic Scan Tool - Reference Information
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- Rear Door Speaker - Buzz
- Horn Switch - Service
- Rear Window Wiper - Operation
- Doors/Locks - Inoperative/Binding
- Memory Power Seat - Travel Range
- Sun Roof - Inoperative/Stuck
- Windshield Area - Wind Noise
- Wipers/Washers - Wipers Smear or Streak Windshield
- Outside Rearview Mirror - Glass Replacement
- Engine - Coolant Recommendations
- CD Player - CD Compatibility
- Radio/CD Player - Inoperative
- A/T - ATF+4 Fluid Usage/Applications
- Ignition System - Cross Fire/Ignition Wire Induction
- Power Distribution Center - Service
- Wiring - Revised Splicing Procedure
- ABS - Connector Repair
- Electrical - Connector Circuit/Diagnostic Revisions
- Paint - Fallout Damage Repair
- A/T - Buzz/Whining in Reverse When Cold
- Recall - Front Brake Rotor Corrosion
- A/T - Engine Bucking/Surging at 5,300 Rpm
- Heater A/C Housing - Service
- Heated Seat - Inoperative
- Door Locks - Cycle When Rear Defogger is Turned Off
- RKE Transmitter - Premature Battery Failure
- Evaporator/Cowl Screen - Revision
- Door Check Roller - Worn/Broken/Missing
- A/C Evaporator - Emits Odors
- Recall 02V053000: A/T Shifter Not Fully Engaged In Park
- Garage Door Opener - Rolling Code Information
- EVAP System - Leak Detection Pump Misdiagnosis
- LDP - MIL ON, DTC P1494 Set
- Engine - High Driveability Index Fuels
- Fuel Pressure Gauge Adapter - Usage
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- A/T - ATF + 4 Fluid Usage
- A/T - Repair/Replacement Guidelines
- Restraints - Child Seat Tether Installation
- Recall - Replace Mopar(R) Value Line Catalytic Converter
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process