Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall 97V080000: Unexpected Air Bag Deployment
- Recall 96V060000: Defective Air Bag Module
- Recall - Airbag Control Module
- Overview
- Service Procedure For Neon (PL) Vehicles:
- Service Procedure For Dakota (AN) Vehicles:
- Service Procedure For Wrangler (TJ) Vehicles:
- Service Procedure For Grand Cherokee (ZJ) Vehicles:
- Service Procedure For Viper GTS Coupe (SR) Vehicles:
- Completion Reporting and Reimbursement / Parts Return
- Vehicle Not Available
- Dealer Service Instructions
- Owner Letter
- Recall - Airbag Electronic Control Module
- Recall - Fuel Tank Sending Unit
- Recall - Passenger Air Bag Safety
- Recall - Steering Column Airbag Clockspring
- Recall 98V046000: Air Bag Clock Spring Wiring Harness
- Customer Interest
- Steering/Suspension - Vibration/Shimmy Above 50 MPH
- Front Brakes - One Click on Initial Application
- Front Brakes - Pedal Pulsation
- AC Compressor - Growling Noise
- A/C Evaporator - Freeze Up
- Power Steering Reservoir - Fluid Seepage
- Engine - Apparent Rear Main Seal Oil Leaks
- Heater A/C Actuator - Squeaking Noise
- Front Seat - Squeaking Noise
- Door Weatherstrip - Water Leaks/Wind Noise
- Body - Water Leaks From The A-Pillar Area
- Steering Column - Boot Squawk
- TCM/TV Cable - MIL ON/False DTC #94 Set
- MIL ON, DTC's #28, #6A, #9B, #BA Set
- PCM - MIL ON/Erroneous DTC P1398 (or $BA)
- MIL ON, Erroneous DTC P0107 Set
- PCM - Erroneous MIL ON/Driveability Improvements
- PCM - Erroneous MIL, and/or Driveability Concerns
- PCM - Erroneous MIL ON/DTC's Set/Hesitation
- I/M Testing - OBDII CARB Readiness Monitor Information
- Fuel Tank - Slow to Fill
- TCM - MIL ON/DTC P1763 Set
- Fuel Gauge - Inaccurate Readings
- Fuel Gauge - Inaccurate
- A/C Manifold - Refrigerant Leaks
- Black Plastic Body Components - Chalky Residue
- Body Mount - Creaking/Popping Noise
- Interior - Water Leak Diagnostic and Repair Procedure
- MIL ON, Engine Misfire DTC's Set
- Door Latch - Binds/Door Remains Locked
- Hood/Fender - Rattle/Paint Chafing
- Wipers/Washers - Wipers Smear or Streak Windshield
- Heater A/C - No Air From Panel Vents
- Odometer - LED's Flash When 4 Way Flashers are On
- Carpet -Poor Fit/Slides
- A/T - Buzz/Whining in Reverse When Cold
- Steering Column - Clicking Noise When Turning
- Heater A/C Housing - Water Leaks To Interior
- Heater/AC Housing - Water Leaks To The Interior
- A/C Evaporator - Emits Odors
- Transfer Case Shifter - Creaking/Thumping Noise
- Evaporator Drain Tube - Water Leaks Into Interior
- A/C - Evaporator Drain Tube Leaking into Interior
- Interior - Water Leaks Onto Passenger Carpet
- A/C - Water Leaks Onto Passenger Carpet
- Tailgate - Rattle/Knock on Rough Roads
- Tailgate - Rattling/Chuckling Noise
- EZ Entry Seat Back Release Cable - Detached
- Fuel Filler Bezel Screws - Rust Prematurely
- A/C - Musty Odors When Hot/Humid
- Steering - High Speed Shimmy After Hitting Bumps
- Superceded Bulletins
- 18-05-00A - 06/23/00
- Soft Top - Window Zippers Difficult To Operate
- Interior - Water Leak Diagnosis and Repair
- Body - Water Leak Diagnostic/Repair Procedure.
- Radio Transmitting Equipment - Installation
- Airbag - On/Off Switch Availability
- Airbag - ON/OFF Switches Availability
- Evaporator Drain Tube - Water Leaks Onto Passenger Floor
- Steering Column Boot - Squawk Noise
- Wiring Harness - Connector Repair Packages
- Electrical - Wire Splice Procedure Revision
- Brakes - Pedal Pulsation
- A/T - Diagnostic Teardown Procedures
- A/T - Diagnostic Tear-Down Procedure
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- Engine Controls - Flash Reprogramming Failure
- Engine Controls - Co-Pilot Support/Cable Selection
- PCM - Flash Programming Failure Recovery
- Crankshaft Position Sensor - Rough Running Engine
- Engine - Rear Main Seal Oil Leak
- MIL ON, Misfire DTC's Set
- A/T - Fluid Usage
- A/C - Musty Odors When Hot or Humid
- A/T - ATF Usage List
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Steering/Suspension - Vibration/Shimmy Above 50 MPH
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Service Manual - Revisions/Updates
- Service Manual - Revision
- Brakes - Noise Explanation
- A/C - System Leak Detection
- A/C - System Sealer Usage Prohibition
- Fuel Pump - Diagnosis
- Front Brakes - One Click on Initial Application
- Front Brakes - Pedal Pulsation
- AC Compressor - Growling Noise
- A/C Evaporator - Freeze Up
- Power Steering Reservoir - Fluid Seepage
- Engine - Apparent Rear Main Seal Oil Leaks
- A/C - Vacuum Schematics Revisions
- Heater A/C Actuator - Squeaking Noise
- Front End Alignment - Adjustable/Offset Ball Joints
- Tire and Wheel - Runout
- Front Seat - Squeaking Noise
- Door Weatherstrip - Water Leaks/Wind Noise
- Body - Water Leaks From The A-Pillar Area
- Steering Column - Boot Squawk
- TCM/TV Cable - MIL ON/False DTC #94 Set
- PCM - Wire Harness Connector Repair Package
- Powertrain Control Module - Service Precaution
- Engine Controls/Electronics/Emissions - Manual Revisions
- ABS - Kelsey Hayes EBC-5H, EBC 310 Test Revisions
- Brakes - Teves Mark IV/Teves Mark 20 ABS Revisions
- MIL ON, DTC's #28, #6A, #9B, #BA Set
- PCM - MIL ON/Erroneous DTC P1398 (or $BA)
- MIL ON, Erroneous DTC P0107 Set
- PCM - Erroneous MIL ON/Driveability Improvements
- PCM - Erroneous MIL, and/or Driveability Concerns
- PCM - Erroneous MIL ON/DTC's Set/Hesitation
- I/M Testing - OBDII CARB Readiness Monitor Information
- Engine Controls - Flash Programming Failure Recovery
- Fuel Tank - Slow to Fill
- TCM - MIL ON/DTC P1763 Set
- Radio Communication Equipment - Recommendations
- Recall 97V080000: Unexpected Air Bag Deployment
- Airbag/Clock Spring - Service
- Driver Airbag - Trim Cover Service
- Recall 96V060000: Defective Air Bag Module
- Recall - Airbag Control Module
- Overview
- Service Procedure For Neon (PL) Vehicles:
- Service Procedure For Dakota (AN) Vehicles:
- Service Procedure For Wrangler (TJ) Vehicles:
- Service Procedure For Grand Cherokee (ZJ) Vehicles:
- Service Procedure For Viper GTS Coupe (SR) Vehicles:
- Completion Reporting and Reimbursement / Parts Return
- Vehicle Not Available
- Dealer Service Instructions
- Owner Letter
- Recall - Airbag Electronic Control Module
- Fuel Gauge - Inaccurate Readings
- Fuel Gauge - Inaccurate
- Recall - Fuel Tank Sending Unit
- A/C Manifold - Refrigerant Leaks
- ABS/TCS - Diagnostic Test Revisions
- Brakes - Teves Mark IVG and Mark 20 ABS Revisions
- Brakes - Kelsey Hayes ABS Manual Revisions
- Brakes - ABS Diagnostic Procedures Revision
- Brakes - Kelsey-Hayes ABS System Diagnostic Revisions
- Brakes - Bendix ABX 4 ABS System Test Revisions
- Black Plastic Body Components - Chalky Residue
- Body Mount - Creaking/Popping Noise
- Interior - Water Leak Diagnostic and Repair Procedure
- Body - Rear Window Lift Glass/Seal Carrier R and R
- Recall - Passenger Air Bag Safety
- Airbag - NHTSA Authorized Deactivation
- Interior - Air Bag Service Manual Revisions
- Warranty - Emissions Component Update
- Leak Detection Pump - Monitor Test
- MIL ON, Engine Misfire DTC's Set
- Auto Computers - Y2K Effects
- Generic Scan Tool - Reference Information
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- Door Latch - Binds/Door Remains Locked
- Hood/Fender - Rattle/Paint Chafing
- Windshield - Stress Cracks
- Wipers/Washers - Wipers Smear or Streak Windshield
- Engine - Coolant Recommendations
- CD Player - CD Compatibility
- Engine/Steering - Oil Capacity/Pressure Switch Revisions
- A/T - ATF+4 Fluid Usage/Applications
- Heater A/C - No Air From Panel Vents
- Recall - Steering Column Airbag Clockspring
- Recall 98V046000: Air Bag Clock Spring Wiring Harness
- Odometer - LED's Flash When 4 Way Flashers are On
- Power Distribution Center - Service
- Wiring - Revised Splicing Procedure
- Wiring Harness - Connector Repair Package
- Soft Top - Improvements
- Body - Soft Top Zipper cleaner
- Paint - Fallout Damage Repair
- Carpet -Poor Fit/Slides
- A/T - Buzz/Whining in Reverse When Cold
- Steering Column - Clicking Noise When Turning
- Heater A/C Housing - Water Leaks To Interior
- Heater/AC Housing - Water Leaks To The Interior
- A/C Evaporator - Emits Odors
- Transfer Case Shifter - Creaking/Thumping Noise
- Evaporator Drain Tube - Water Leaks Into Interior
- A/C - Evaporator Drain Tube Leaking into Interior
- Interior - Water Leaks Onto Passenger Carpet
- A/C - Water Leaks Onto Passenger Carpet
- Tailgate - Rattle/Knock on Rough Roads
- Tailgate - Rattling/Chuckling Noise
- Steering - Power Steering Fluid Usage
- EZ Entry Seat Back Release Cable - Detached
- EVAP System - Leak Detection Pump Misdiagnosis
- Engine - High Driveability Index Fuels
- Steering/Suspension - Alignment Specifications Revisions
- Engine Controls - Oil Pressure Sensor Art Revisions
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Fuel Filler Bezel Screws - Rust Prematurely
- A/C - Musty Odors When Hot/Humid
- Steering - High Speed Shimmy After Hitting Bumps
- A/T - ATF + 4 Fluid Usage
- A/T - Repair/Replacement Guidelines
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process