Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall - Power Brake Booster
- Recall 00V105000: Air Bag Light On/Accidental Deployment
- Recall - Airbag Control Module Internal Corrosion
- Recall 00V136000: Front Disc Brake Rotor Corrosion
- Recall 98V048000: Shoulder Belt Turning Loop Anchors
- Recall - Front Brake Rotor Corrosion
- Recall 98V023000: Brake Power Booster Rip/Tear
- Recall - Front Shoulder Belt Adjustable Anchors
- Customer Interest
- Engine - Spark Knock on Acceleration
- Front Brakes - One Click on Initial Application
- Front Brakes - Pedal Pulsation
- A/C Evaporator - Freeze Up
- Fan Viscous Drive - Scraping Noise/Radiator Damage
- Exhaust System - Squeak in Cold Weather
- Heater A/C Actuator - Squeaking Noise
- Front Shock Absorber - Rattle/Knock
- Front Seat - Squeaking Noise
- Drive Line - Vibration/Droning Noise Over 60 Mph
- Propeller Shaft - Clicking Noise
- Engine - Spark Knock/PCM Reprogramming
- MIL ON, Erroneous DTC P0107 Set
- PCM - Incorrect Fault Mature Time for DTC#B7
- I/M Testing - OBDII CARB Readiness Monitor Information
- Fuel Tank - Rattling/Knocking/Gurgling Noises
- TCM - MIL ON/DTC P1763 Set
- Rear Brakes - Clunk or Thump When Brakes Are Applied
- Headlamps - Momentarily Flicker
- A/C Manifold - Refrigerant Leaks
- Body/Frame - Floor Pan Corrosion
- Instrument Cluster - Intermittent/Erratic Operation
- MIL ON, Engine Misfire DTC's Set
- Doors/Locks - Inoperative/Binding
- Wipers/Washers - Wipers Smear or Streak Windshield
- Instrument Panel - Erratic Operation
- A/T - Buzz/Whining in Reverse When Cold
- Transfer Case Shifter - Creaking/Thumping Noise
- Firewall/Footwell - Noise/Air/Water Leaks
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 18-05-00A - 06/23/00
- 18-05-00 - 09/15/00
- Instrument Panel Cluster - Erratic Operation
- Radio Transmitting Equipment - Installation
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- Airbag - On/Off Switch Availability
- Airbag - ON/OFF Switches Availability
- Brakes - Pedal Pulsation
- Engine Controls - Flash Reprogramming Failure
- Engine Controls - Co-Pilot Support/Cable Selection
- MIL - Erroneously ON, DTC P1763 Set
- MIL - Erroneously ON, DTC #24 (P0107)
- PCM - Flash Programming Failure Recovery
- MIL ON, Misfire DTC's Set
- Engine - Spark Knock Noise
- Engine - Spark Knock.
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- A/C - System Leak Detection
- A/C - System Sealer Usage Prohibition
- Electrical/Fuel/Ignition/A/C - Manual Updates
- Engine - Spark Knock on Acceleration
- Fuel System/Engine Controls - Manual Revisions
- Engine Controls - TPS Connector/DTC Test Revisions
- Front Brakes - One Click on Initial Application
- Front Brakes - Pedal Pulsation
- A/C Evaporator - Freeze Up
- Fan Viscous Drive - Scraping Noise/Radiator Damage
- Exhaust System - Squeak in Cold Weather
- Heater A/C Actuator - Squeaking Noise
- Front End Alignment - Adjustable/Offset Ball Joints
- Front Shock Absorber - Rattle/Knock
- Leaf Spring - Retainer Clamp Availability
- Front Seat - Squeaking Noise
- Drive Line - Vibration/Droning Noise Over 60 Mph
- Propeller Shaft - Clicking Noise
- Powertrain Control Module - Service Precaution
- Electrical/Engine Controls - Manual Revisions
- Engine Controls - Speed Sensor Diagnostics Revisions
- Recall - Power Brake Booster
- Brakes - Teves Mark IV/Teves Mark 20 ABS Revisions
- Brakes - Teves Mark 20 ABS System Test Revisions
- Engine - Spark Knock/PCM Reprogramming
- MIL ON, Erroneous DTC P0107 Set
- PCM - Incorrect Fault Mature Time for DTC#B7
- I/M Testing - OBDII CARB Readiness Monitor Information
- Engine Controls - Flash Programming Failure Recovery
- Fuel Tank - Rattling/Knocking/Gurgling Noises
- TCM - MIL ON/DTC P1763 Set
- Radio Communication Equipment - Recommendations
- Recall 00V105000: Air Bag Light On/Accidental Deployment
- Airbag/Clock Spring - Service
- Driver Airbag - Trim Cover Service
- Recall - Airbag Control Module Internal Corrosion
- Recall 00V136000: Front Disc Brake Rotor Corrosion
- Rear Brakes - Clunk or Thump When Brakes Are Applied
- Engine Controls - Miss-Fire Test Revisions
- Headlamps - Momentarily Flicker
- A/C Manifold - Refrigerant Leaks
- ABS/TCS - Diagnostic Test Revisions
- Brakes - Teves Mark IVG and Mark 20 ABS Revisions
- ABS System - 'No Response' Test Revisions
- Brakes - Teves Mark 20 ABS, Manual Revisions
- Brakes - Teves Mark 20 ABS System Revisions
- Brakes - Kelsey Hayes EBC 2 and EBC 3 ABS Revisions
- Body/Frame - Floor Pan Corrosion
- Instrument Cluster - Intermittent/Erratic Operation
- Airbag - NHTSA Authorized Deactivation
- Leak Detection Pump - Monitor Test
- Evaporative System - Leak and DTC Diagnostics
- MIL ON, Engine Misfire DTC's Set
- Auto Computers - Y2K Effects
- Generic Scan Tool - Reference Information
- A/T - Check Shifter Signal Test Revisions
- Engine Controls/Electrical - Diagnostic/Wiring Revisions
- Engine Controls/Electrical - Manual Revisions
- Differential Cover - Updated Sealer and Fluid
- Doors/Locks - Inoperative/Binding
- Wipers/Washers - Wipers Smear or Streak Windshield
- Outside Rearview Mirror - Glass Replacement
- CD Player - CD Compatibility
- Engine Controls - ECT Sensor Test revisions
- Instrument Panel - Erratic Operation
- Power Distribution Center - Service
- Wiring - Revised Splicing Procedure
- ABS - Connector Repair
- Electrical - Wire Harness Connector Location Rev.
- Speedometer Gear - Adapter Alignment
- Recall 98V048000: Shoulder Belt Turning Loop Anchors
- A/T - Buzz/Whining in Reverse When Cold
- Recall - Front Brake Rotor Corrosion
- Differential - Lubricant and Sealing Requirements
- Recall 98V023000: Brake Power Booster Rip/Tear
- Transfer Case Shifter - Creaking/Thumping Noise
- Firewall/Footwell - Noise/Air/Water Leaks
- Engine - High Driveability Index Fuels
- Fuel Pressure Gauge Adapter - Usage
- Recall - Front Shoulder Belt Adjustable Anchors
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- A/T - ATF + 4 Fluid Usage
- Restraints - Child Seat Tether Installation
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process