Powertrain Management: Technical Service Bulletins

• Recalls
  • Canada - Campaign - F37 Torque Converter/Reprogram ECM/TCM
    • Overview
    • Dealer Information
    • Owner Letter
  • Recall - Torque Converter and Reprogram ECM/TCM
    • Overview
    • Service Procedure
      • A. Vehicle Inspection
      • B. Torque Converter Replacement
      • C. Transmission Flush, Torque Converter and Pump Replacement
      • D. Reprogram the ECM/TCM For 2006 MY Vehicles
      • E. Reprogram ECM/TCM For 2005 MY Vehicles
    • Owner Letter
• Customer Interest
  • Engine Controls - ECM Update When Replacing Glow Plugs
  • Engine Controls - Low Power In Rev./MIL/DTCs P1713/P1776
  • Lighting - Dome Lamp Won't Turn OFF
  • Engine Controls - Hard Start in Extreme Cold Conditions
  • Engine Controls - Engine Run-Up on Hot Re-Start
  • Engine Controls - Intermittent 4WD Lamp or DTC P0573
  • Emissions - MIL ON/DTC P0401 (EGR Solenoid) Set
  • Engine Controls - High Altitude Driveability/DTC P0504
  • A/T Controls - MIL ON/Low Line Pressure/DTC's Set
  • Fuel System - MIL ON/DTC P0457 Set
  • A/T - 42RLE MIL ON/Multiple DTC's Set
    • Overview
    • AN/HB/ND Repair Procedure
    • KJ Repair Procedure
    • LX Repair Procedure
    • TJ Repair Procedure
    • Wiring Harness and Solenoid Repair Procedure
  • Brakes/Drivetrain - MIL/ABS Lamps ON/Possible DTC P0501
  • Fuel System - Hard Or No Start/Rough Idle
  • Fuel System - Difficult Fuel Fill/Nozzle Shuts Off
• By Symptom
  • Abnormal wear/deterioration
    • Brakes/Drivetrain - MIL/ABS Lamps ON/Possible DTC P0501
  • Customer Interest
    • Engine Controls - ECM Update When Replacing Glow Plugs
    • Engine Controls - Low Power In Rev./MIL/DTCs P1713/P1776
    • Lighting - Dome Lamp Won't Turn OFF
    • Engine Controls - Hard Start in Extreme Cold Conditions
    • Engine Controls - Engine Run-Up on Hot Re-Start
    • Engine Controls - Intermittent 4WD Lamp or DTC P0573
    • Emissions - MIL ON/DTC P0401 (EGR Solenoid) Set
    • Engine Controls - High Altitude Driveability/DTC P0504
    • A/T Controls - MIL ON/Low Line Pressure/DTC's Set
    • Fuel System - MIL ON/DTC P0457 Set
    • A/T - 42RLE MIL ON/Multiple DTC's Set
      • Overview
      • AN/HB/ND Repair Procedure
      • KJ Repair Procedure
      • LX Repair Procedure
      • TJ Repair Procedure
      • Wiring Harness and Solenoid Repair Procedure
    • Brakes/Drivetrain - MIL/ABS Lamps ON/Possible DTC P0501
    • Fuel System - Hard Or No Start/Rough Idle
    • Fuel System - Difficult Fuel Fill/Nozzle Shuts Off
  • Driveability
    • Engine Controls - Low Power In Rev./MIL/DTCs P1713/P1776
  • Leaks
    • Brakes/Drivetrain - MIL/ABS Lamps ON/Possible DTC P0501
  • Recalls
    • Canada - Campaign - F37 Torque Converter/Reprogram ECM/TCM
      • Overview
      • Dealer Information
      • Owner Letter
    • Recall - Torque Converter and Reprogram ECM/TCM
      • Overview
      • Service Procedure
        • A. Vehicle Inspection
        • B. Torque Converter Replacement
        • C. Transmission Flush, Torque Converter and Pump Replacement
        • D. Reprogram the ECM/TCM For 2006 MY Vehicles
        • E. Reprogram ECM/TCM For 2005 MY Vehicles
      • Owner Letter
  • Starting problems
    • Engine Controls - Hard Start in Extreme Cold Conditions
  • Won't turn off
    • Lighting - Dome Lamp Won't Turn OFF
• All Technical Service Bulletins
  • Canada - Campaign - F37 Torque Converter/Reprogram ECM/TCM
    • Overview
    • Dealer Information
    • Owner Letter
  • Engine Controls - ECM Update When Replacing Glow Plugs
  • Engine Controls - Low Power In Rev./MIL/DTCs P1713/P1776
  • Engine Controls - Co-Pilot Support/Correct Cable Usage
  • Engine Control - PCM Initialization Procedure
  • Lighting - Dome Lamp Won't Turn OFF
  • Engine Controls - Hard Start in Extreme Cold Conditions
  • Engine Controls - Engine Run-Up on Hot Re-Start
  • Engine Controls - Intermittent 4WD Lamp or DTC P0573
  • Engine Controls - Flash Programming Failure Recovery
    • Overview
    • Connected/Disconnected Flash Mode Using TechCONNECT
    • Pay Attention While Performing Flash Reprogram Procedures
    • Error Messages
    • Enhanced and Original Abort Recovery
    • Enhanced Abort Recovery Screens
    • Original Abort Recovery Screen
    • Programmable Modules
    • Powertrain Modules - Engine and Transmission
  • Emissions - MIL ON/DTC P0401 (EGR Solenoid) Set
  • Engine Controls - High Altitude Driveability/DTC P0504
  • A/T Controls - MIL ON/Low Line Pressure/DTC's Set
  • Safety Systems - Inadvertent Damage/Disabling
  • Fuel System - MIL ON/DTC P0457 Set
  • A/T - 42RLE MIL ON/Multiple DTC's Set
    • Overview
    • AN/HB/ND Repair Procedure
    • KJ Repair Procedure
    • LX Repair Procedure
    • TJ Repair Procedure
    • Wiring Harness and Solenoid Repair Procedure
  • Brakes/Drivetrain - MIL/ABS Lamps ON/Possible DTC P0501
  • Recall - Torque Converter and Reprogram ECM/TCM
    • Overview
    • Service Procedure
      • A. Vehicle Inspection
      • B. Torque Converter Replacement
      • C. Transmission Flush, Torque Converter and Pump Replacement
      • D. Reprogram the ECM/TCM For 2006 MY Vehicles
      • E. Reprogram ECM/TCM For 2005 MY Vehicles
    • Owner Letter
  • Fuel System - Hard Or No Start/Rough Idle
  • Fuel System - Difficult Fuel Fill/Nozzle Shuts Off