Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Door Side Molding - Comes Off In Extreme Cold
- Door Side Molding - Detaches in Extreme Cold
- A/C - Intermittent Operation
- Fuel Gauge - Reads 3/4 Full When Tank is Full
- Oil Pump - Engine Stall/Rough Idle on Cold Start
- Blower Motor - Noises/Passenger Carpet Damp
- A/C Expansion Valve - Whistling Noise
- Front Strut - Squeaks On Turns
- Steering Gear - Fluid Loss
- HLA - Noise After Long Storage
- Engine - Tapping Noise When Cold
- Engine - Idle Vibration
- Stabilizer Links - Knocking Noise On Bumps
- Door Weatherstrip - Wind Noise Around Doors
- Sunroof - Rattle Noise
- A/T - LA4EL DTC 628/Harsh Shifts
- ISC Valve - Rough Idle/Miss Under Load
- Mass Air Flow Sensor - MIL ON/Driveability Concerns
- Throttle Body - Stalling/Rough or Rolling Idle
- Seat Belt - Will Not Retract/Hard to Pull Out
- Brakes - Judder/Vibration/Pulsation
- Steering Wheel - Slightly Off Center.
- Steering Wheel - Is Slightly Off Center
- Muffler Bracket - Rattling Noise
- Speedometer - Inoperative/MIL ON/DTC P0500
- Power Door Lock - Knob Malfunction
- Door Window - Comes Off Track
- Wiper Arm - Rattling Noise From Right Hand Side
- Passenger Side Cowl - Creak/Rattle Noise
- Front Door Glass Run Channel - Out Of Position
- A/T - Bell Housing Fluid leaks
- Engine Mount - Clicking/Clunking/Vibration
- A/T Overdrive Switch - Inoperative
- Instrument Panel - Delamination Above Passenger Air Bag
- Paint - Cracking on Horizontal Surfaces
- A/T Shift Lever - Will Not Move From Park
- Room Lamp - Does Not Illuminate
- Outer Door Handle - Loose/Rattles
- A/T Valve Body - Whistle Noise At Idle
- A/T - Oil Leak From Breather
- A/C Relay Failure - Insufficient Cooling
- Sunroof - Sunshade Rattling Noise
- Seat Belt - Difficult Shoulder Height Adjustment
- Front Seat Back - Clicking/Popping Noise
- A/T - LA4A-EL Converter Hub Seal Leakage
- Chemicals,Additives
- Labor/Parts Updates
- Manual Updates
- Superceded Bulletins
- S01997 - 08/30/97
- R00396 - 06/12/96
- N00196 - 04/15/98
- K00598 - 04/22/98
- K00396 - 07/11/96
- G0197 - 04/08/97
- G00397 - 06/19/97
- B00598 - 11/04/98
- S03296 - 06/27/96
- ST00294 - 10/25/94
- T01496 - 06/27/96
- T01595 - 11/14/95
- 15070-88 - 06/19/97
- Rear Window Defroster - Grid Line Repair Procedures
- Rear Window Defroster - Grid Repair Procedure
- Body - Wind Noise Around Doors
- Outer Door Handle - Rattles/Loose
- Bumper - Pre-Painting Procedures
- Air Bag System - Effect of Aftermarket Accessories
- Air Bags - Replacement After Deployment
- A/C System - Tracer Dye Leak Detection
- A/C Expansion Valve - Intermittent Whistling Noise
- Battery - Test Procedures
- A/T Cooler/Line - Flushing Procedure
- Camshaft Friction Gear - Tapping Noise
- Steering Wheel - Slightly Off Center
- Reconditioned Anti-Freeze - Recommendations
- All Technical Service Bulletins
- Door Side Molding - Comes Off In Extreme Cold
- Door Side Molding - Detaches in Extreme Cold
- Interior - Console Damage Prevention During Removal
- Fuel System - Fuel Ethanol Content Testing
- Mirrors - Door Mirror Glass Is Loose
- A/C - Poor Blower Motor Performance
- Wheels/Tires - Tire Pessure/Rotation Information
- Mirrors - Interior Mirror Removal
- Electrical - Lightning Strike Information
- Wheels - Aluminum Wheel Cleaning Precautions
- Special Tools - Storage Cabinet System
- Required Tools - Inventory List
- Tools - Shipment Of NGS Program Card Version 2.0
- A/C - O Ring Replacement
- A/C - Intermittent Operation
- Special Service Tools - Shipment Date
- Coolant - Propylene Glycol Based Not Recommended
- Battery - Dies In A relatively Short Period Of Time
- Fuel Pump/Sender - Non-Interchangeability
- Fuel Gauge - Reads 3/4 Full When Tank is Full
- Oil Pump - Engine Stall/Rough Idle on Cold Start
- A/C Compressor - Noise Replacement Criteria
- Blower Motor - Noises/Passenger Carpet Damp
- A/C Expansion Valve - Whistling Noise
- Front Strut - Squeaks On Turns
- Recall - Front Coil Spring Guard Installation
- Steering Gear - Fluid Loss
- HLA - Noise After Long Storage
- Engine - Tapping Noise When Cold
- Cooling System - Water Pump Weep Hole Seepage
- Engine - Idle Vibration
- Receiver Dryer - Replacement Criteria
- Stabilizer Links - Knocking Noise On Bumps
- Bumper - Painting Preparation
- Door Weatherstrip - Wind Noise Around Doors
- Sunroof - Rattle Noise
- A/T - LA4EL DTC 628/Harsh Shifts
- A/T Cooler Line - Recommended Flushing Equipment
- ISC Valve - Rough Idle/Miss Under Load
- Mass Air Flow Sensor - MIL ON/Driveability Concerns
- Air Flow Meter - Service Precautions
- CPU - Troubleshooting Procedures
- Maintenance Free Battery - Diagnostic/Charge Procedure
- Overview
- 1. Conditions Leading to Battery Problems
- 2. Battery Maintenance Responsibility
- 3. Battery Maintenance Record
- 4. Servicing Equipment Requirements
- 5. Charging and Load Testing Information
- 6. Battery Cold Cranking Amperage (CCA) Ratings
- 7. Battery Diagnostic Procedures
- 7a. Battery Diagnostic Procedures
- 8. Parts Information
- 9. Warrantable Charging and/or Replacement
- 10. Warranty Claim Submission
- 11. Warranty Information
- Battery - Diagnostic/Charging Procedure
- Battery - Diagnosis/Service
- Battery - Ignition OFF Draw Current Diagnosis
- Throttle Body - Stalling/Rough or Rolling Idle
- Throttle Adjustment Screw - Adjustment Precaution
- Power Antenna Mast - Replacement
- Seat Belt - Will Not Retract/Hard to Pull Out
- Recall 95E006001: Air Bag Inflator Malfunction
- Air Bag System - Parts Replacement After Deployment
- Recall 98V249000: Air Bag Module Reprogramming
- Brake Rotor - Machining and Replacement Criteria
- Brakes - Use On Car Brake Lathe to Correct Judder
- Brakes - Judder/Vibration/Pulsation
- Speedometer - Replacement Procedure
- Headlight Switch - Replacement
- Wiper Motor - Inoperative/Circuit Breaker Operation
- Stabilizer Bar Bushings - Replacement Procedure
- Steering Wheel - Slightly Off Center.
- Steering Wheel - Is Slightly Off Center
- Air Bag System - Diagnosis/Troubleshooting
- Muffler Bracket - Rattling Noise
- NGS System - Reprogramming Service
- NGS System - Test Lead Inspection
- NGS System - Reprogramming Procedure
- Year 2000 - Computer Systems Compliance
- Star Tester - New Version Program Cards
- Speedometer - Inoperative/MIL ON/DTC P0500
- Power Door Lock - Knob Malfunction
- Windshield - Stone Chipping Inspection
- Door Window - Comes Off Track
- Wiper Arm - Rattling Noise From Right Hand Side
- Passenger Side Cowl - Creak/Rattle Noise
- Front Door Glass Run Channel - Out Of Position
- Front Console - Service Parts Availability
- A/T - LA4A-EL Forward Clutch Filter - Service
- A/T - Repair Policies
- A/T - Repair Policy
- A/T - LA44 A-EL Updated Transmission Assembly
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Overhaul Information
- A/T - Bell Housing Fluid leaks
- Engine Mount - Clicking/Clunking/Vibration
- Cigarette Lighter - Replacement
- A/T Overdrive Switch - Inoperative
- Instrument Panel - Delamination Above Passenger Air Bag
- Electrical - Terminal/Connector Replacement
- Paint - Iron Particle/Industrial Fallout Damage
- Paint - Cracking on Horizontal Surfaces
- A/T Shift Lever - Will Not Move From Park
- Room Lamp - Does Not Illuminate
- Outer Door Handle - Loose/Rattles
- A/T Valve Body - Whistle Noise At Idle
- A/T - Oil Leak From Breather
- A/C Refrigerant - Recommendations
- A/C - R134a Training/Equipment Requirements
- A/C - O-Ring Replacement
- A/C Relay Failure - Insufficient Cooling
- Sunroof - Sunshade Rattling Noise
- Fuel Volatility - Driveability Concerns
- Fuel - California Reformulated Gasoline
- Seat Belt - Difficult Shoulder Height Adjustment
- Seat Belt - Extender Availability
- Front Seat Back - Clicking/Popping Noise
- A/T - LA4A-EL Converter Hub Seal Leakage
- Wheels - Wheel Lock Installation Precautions
- Air Bag System - Affect of Accessories On Air Bag Sys.
- Wheels - Stain Prevention Information
- Fuel System - Ethanol Fuel Usage