Repair and Diagnosis: Technical Service Bulletins

• How to Find Technical Service Bulletins by Category/Symptom
• Recalls
  • Emissions
    • Recall - DPFE Sensor Replacement/Warranty Extension
      • Dealer Letter
      • Attachment I - Dealer Information
      • Attachment II - Owner Notification Letter
      • Reimbursement Plan and Application Form
  • Safety
    • Recall - Potential ABS Module Fires
      • Dealer Letter
      • Attachment I - Parts and Service Information
      • Attachment II
      • Attachment III - Owner Letter
      • Reimbursement Plan
    • Recall 04V605000: Liftgate Latch Release Rod Replacement
    • Recall 07V157000: ABS Module Connector Defect
    • Recall - ABS Module Connector Defect
      • Dealer Letter
      • Attachment I - Dealer Information
      • Attachment II - Repair Procedure
      • Attachment III - Owner Letter
      • Reimbursement Plan
      • Reimbursement Application Form
• Customer Interest
  • Steering - Steering Wheel Off Center When Driving Straight
  • Steering/Suspension - Steering Wheel Off-Center
  • Engine Controls/Instruments - DTC P1635/P1639 Present
    • Overview
    • Repair Procedure
  • Audio System - Whining/Buzzing Noise From Speakers
  • A/C - Musty/Mildew Type Odors
  • A/T - Harsh Shifting/Slipping/A/T Lamp ON/DTC's Set
  • Brakes - Brake Fluid Reservoir Cap Leakage
  • Engine Controls - Rolling Idle in High Temperatures
  • Steering - Noise/Premature Wear on the Tie Rod Ends
  • Emissions - MIL ON/Multiple EVAP System DTC's Set
  • SRS - Air Bag Lamp ON/DTC's B1994 or B1998 Set
  • Air Bag System - Warning Lamp ON/DTC's B1877/B1881
  • Body - Doors Will Not Open
    • Overview
    • Repair Procedure
      • Information
      • Procedure # 1
      • Procedure # 2
  • Restraints - Seat Belts Retract Too Slowly
  • Steering - Power Steering Fluid Leak When Cold
  • Audio System - No Sound From CD Player/Speakers
  • Tires/Wheels - Body Vibration/Steering Wheel Shimmy
  • Audio System - Whining/Buzzing Noise From Radio Speakers
    • Overview
    • Repair Procedure
  • Steering/Suspension - Vehicle Pulls To One Side
  • Body - Door Seal Squeaking Noise
  • M/T - Clutch Master Cylinder Squeaking Noise
  • Body - Wind Noise From Around Windows
  • Engine Controls - No Crank/No Start/MIL ON/Multiple DTCs
  • Steering - Squeaking Noise When Turning at Low Speed
  • Suspension - Various Low Speed Front End Noises
  • A/T CD4E - Failure During Warm Up In Cold Weather
  • Body/Frame - Front/Rear Creak/Squeak Noises
  • Steering - Steering Wheel Off Center, No Pull Or Drift
• Superceded Bulletins
  • 0100604 - 02/06/04
  • 0102906 - 07/28/06
  • 0200104 - 01/15/08
  • 0800104 - 08/30/04
  • 0901202 - 09/10/02
  • 0200403 - 02/01/03
  • A/C - Rear Defroster Grid Repair
  • Body - Paint Damage Repair Guide
  • Interior - Avoiding Driver Floor Mat/Pedal Interference
  • Body - Wind Noise Around Doors
  • Anti-Theft (PATS) System - Diagnostic Service Tips
  • Restraints - Air Bag Lamp ON/Multiple DTC's Set
  • Restraints - Seat Belt(s) Retract Too Slowly
  • A/C - Musty/Mildew Odors
  • Suspension - Strut/Shock Replacement Guidelines
  • Suspension - Strut/Shock Absorber Replacement Guidelines
  • Suspension - Shock/Strut Replacement Guidelines
  • Suspension - Shock Absorber/Strut Replacement Guidelines
  • Electrical - Wiring/Soldering/Crimping Repair Tips
  • Electrical - Battery Testing Procedures
  • Electrical - Battery Testing Procedure Requirements
  • Electrical - Battery Testing/Charging Procedures
  • Battery - Test Procedures
  • A/T - TCIL ON/Shift Concerns/DTC's Set
  • A/T - Cooler/Line Flushing Procedure
  • A/T - Cooler Line Flushing Procedure
  • Engine Controls - O2, A/F Sensor Removal Precautions
  • Engine Controls - Oxygen Sensor Removal Precaution
  • Engine Controls - Oxygen Sensor Removal Precautions
  • Exhaust System - Sulfur Smell
  • Exhaust System - Excessive Sulfur Odors
  • Steering - Squeaking Noise When Turning at Low Speeds
  • Engine - Oil Viscosity Recommendations
  • Tires/Wheels - Vibration Concerns
  • A/T - MERCON(R) V Fluid Information
  • A/T - Fluid Usage/Applications
  • Steering - Steering Wheel Is Off Center
  • A/T - Correct Fluid Applications
  • Recall 6712A - Brake Fluid Leak Leading To Possible Fire
• All Technical Service Bulletins
  • Steering - Steering Wheel Off Center When Driving Straight
  • Recall - Potential ABS Module Fires
    • Dealer Letter
    • Attachment I - Parts and Service Information
    • Attachment II
    • Attachment III - Owner Letter
    • Reimbursement Plan
  • Electrical - Battery Maintenance Information
  • Electrical - Battery Testing Procedures
  • Body - Paint Damage Repair Guide
  • Exhaust System - Excessive Sulfur Odors
  • Steering/Suspension - Steering Wheel Off-Center
  • A/T - Cooler Line Flushing Procedures
  • Interior - Console Damage Prevention During Removal
  • Fuel System - Fuel Ethanol Content Testing
  • Computers/Controls KAM Memory Clearing After VVT R & R
  • Mirrors - Door Mirror Glass Is Loose
  • A/C - Poor Blower Motor Performance
  • Engine - Camshaft Timing Information
  • Wheels/Tires - Tire Pessure/Rotation Information
  • Mirrors - Interior Mirror Removal
  • Electrical - Lightning Strike Information
  • Wheels - Aluminum Wheel Cleaning Precautions
  • Electrical - Battery Maintenance
  • Engine Controls/Instruments - DTC P1635/P1639 Present
    • Overview
    • Repair Procedure
  • Audio System - Whining/Buzzing Noise From Speakers
  • Brakes - New Brake Pads Reduce Dust and Rotor Wear
  • A/C - Musty/Mildew Type Odors
  • A/T - Harsh Shifting/Slipping/A/T Lamp ON/DTC's Set
  • Engine Controls/Emissions - OBD II Diagnosis Aid
    • Overview
    • Description of Terms and Acronyms
    • Heated Oxygen Sensor (HO2S) Monitor Description
    • Catalyst Efficiency Monitor Description
    • Fuel System Monitor Description
    • General OBDII Service Tips
  • Engine Control - MIL ON, Runs Rough, Multiple DTCs
  • Recall - DPFE Sensor Replacement/Warranty Extension
    • Dealer Letter
    • Attachment I - Dealer Information
    • Attachment II - Owner Notification Letter
    • Reimbursement Plan and Application Form
  • Brakes - Brake Fluid Reservoir Cap Leakage
  • Engine Controls - Rolling Idle in High Temperatures
  • A/C - Rear Window Defroster Grid Diagnosis/Repair
  • Body - Exterior Mirror Glass/Motor Replacement
  • Interior/Instruments- Mirror/Compass Operation/Diagnosis
  • Restraints - Seat Belt Tongue Stop Button Service
  • Steering - Noise/Premature Wear on the Tie Rod Ends
  • Passive Antitheft System - Diagnostic Service Tips
    • Overview
    • Repair Information
      • Information
      • Key Programming Procedure
        • With NGS V9.0 Card - PATS Type B
        • With NGS V9.0 Card - PATS Type E
        • With WDS B12M or Later - PATS Type B or E
      • Replacing Pats Module
        • With V9.0 NGS - Pats Type B
        • With WDS B12M or Later - Pats Type B
      • Replacing PCM
        • With V9.0 NGS - PATS Type B
        • (Built-In PATS Module) With V9.0 NGS - PATS Type E
        • With WDS B12M or Later - Pats Type B
        • (Built-In PATS Module) With WDS B12M or Later - PATS Type E
      • What to Do If All Keys Are Lost - PATS Type B or E
      • Spare Key Programming Procedure
        • With V9.0 NGS (Add Extra Keys) - PATS Type B
        • With V9.0 NGS (Add Extra Keys) - PATS Type E
        • With WDS (Add Extra Keys) - PATS Type B or E
      • PCM/Pats Init./Pats Ground - Starter Relay; Anti-Scan Feature
      • Clarification on Selected PATS DTCs
      • Pats Type B and/or E and F Information
  • Emissions - MIL ON/Multiple EVAP System DTC's Set
  • Engine - System Lean DTC's Service Tips
  • SRS - Air Bag Lamp ON/DTC's B1994 or B1998 Set
  • Air Bag System - Warning Lamp ON/DTC's B1877/B1881
  • Recall 04V605000: Liftgate Latch Release Rod Replacement
  • Body - Doors Will Not Open
    • Overview
    • Repair Procedure
      • Information
      • Procedure # 1
      • Procedure # 2
  • Restraints - Seat Belts Retract Too Slowly
  • Wipers/Washers - Rear Wiper Arm Removal
  • Engine - Oil Recommendations
  • Cooling System - Premium Gold Coolant Service Tip
  • Steering - Power Steering Fluid Leak When Cold
  • Audio System - No Sound From CD Player/Speakers
  • A/T - Correct Fluid Usage
  • Tires/Wheels - Body Vibration/Steering Wheel Shimmy
  • Keyless Entry - Diagnostics/Remote Programming
  • A/T - Inadvertant Brake/Shift Interlock Disabling
  • Audio System - Whining/Buzzing Noise From Radio Speakers
    • Overview
    • Repair Procedure
  • Wheels - Wheel Lock Installation Precautions
  • Steering/Suspension - Vehicle Pulls To One Side
  • Body - Door Seal Squeaking Noise
  • M/T - Clutch Master Cylinder Squeaking Noise
  • Brakes - Wheel Speed Sensor Service Precautions
  • Wipers/Washers - Wiper Blade Cleaning & Maintenance
  • Electrical - Wiring, Soldering and Crimping repairs
  • Ignition System - Spark Plug Removal/Installation
  • Body - Wind Noise From Around Windows
  • Engine Controls - No Crank/No Start/MIL ON/Multiple DTCs
  • Electrical - Battery Charging Precautions
  • Air Bag System - Affect of Accessories On Air Bag Sys.
  • Cooling System - Reconditioned Coolant Recommendations
  • A/T, Power Steering - Mercon(R) V Fluid Information
  • Recall 07V157000: ABS Module Connector Defect
  • Recall - ABS Module Connector Defect
    • Dealer Letter
    • Attachment I - Dealer Information
    • Attachment II - Repair Procedure
    • Attachment III - Owner Letter
    • Reimbursement Plan
    • Reimbursement Application Form
  • Engine - Front Crankshaft Bolt Service Precautions
  • Steering - Squeaking Noise When Turning at Low Speed
  • Computers/Controls - Module Reprogramming Precautions
  • Suspension - Lower Control Arm Bushing Inspection
  • Suspension - Various Low Speed Front End Noises
  • A/T CD4E - Failure During Warm Up In Cold Weather
  • Body/Frame - Front/Rear Creak/Squeak Noises
  • Engine Controls - O2 Sensor Removal Precautions
  • Campaign - Warranty Information Booklet Update
    • Dealer Letter
    • Model Year 2000 California Emission Control Warranty
    • Model Year 2001 California Emission Control Warranty
    • Model Year 2002 California Emission Control Warranty
    • Model Year 2003 California Emission Control Warranty
    • Model Year 2004 California Emission Control Warranty
    • Model Year 2005 California Emission Control Warranty
    • Model Year 2006 California Emission Control Warranty
    • Model Year 2007 California Emission Control Warranty
    • Model Year 2008 California Emission Control Warranty
    • Model Year 2009 California Emission Control Warranty
    • Reimbursement Plan
    • Reimbursement Form
    • Owner Letter
  • Cruise Control - System Diagnostics
  • Fuel System - Ethanol Fuel Usage
  • Suspension - Shock Absorber/Strut Replacement Guidelines
  • Steering - Steering Wheel Off Center, No Pull Or Drift
  • A/T - ATF Applications
  • Interior - Proper Floor Mat Usage And Installation