Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Odor Correction
- A/C - Odors
- Spark Plug - Fouling
- Engine - Automatic Valve Lash Adjuster Noise
- Engine - New Oil Pump May Reduce Noise
- Engine - Sag or Hesitation when Started Cold
- Engine - Turbo Cross-Fire Shock
- A/T - KM170 Series Transaxle Case Gasket - Improvement
- Manual Transaxle - No-Shift Condition
- Window - Chemical Film Build-Up/Fogging
- Engine, Valves - Valve Adjuster Noise Diagnosis
- Brakes - Judder (vibration) Diagnosis and Repair
- Manual Updates
- Recommended Repairs
- Superceded Bulletins
- 9211001 - 07/31/92
- 91-52B-002 - 02/01/97
- Tools - ROM Pack Tester Msn-4 Usage
- VIN - Master Decoder
- Lighting - Moisture In Headlamps
- Audio System - Diagnosis
- Remote Keyless Entry - Service Information
- Emission - Control Information Label
- Engine - Oil Pump Gear Noise
- Cylinder Block - Heater Installation Procedure
- Engine Block Heater - Application and Installation
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Sealant/Adhesive/Chemical - Interchange Information
- Tools - Multi-Use Tester Warranty
- VIN - Decoding Information
- VIN - Replacement Plate/Label
- VIN - Master Decoder Information
- New Service Bulletin Group Numbers
- A/C - Adding Refrigerant Oil
- A/C - Compressor Seal Replacement
- A/C - System Leak Checking
- A/C - Odor Correction
- A/C - Handling Precautions For Freon R-12
- A/C - Odors
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- Transaxle - Bearing Preload Specifications
- Engine - ISC/TPS Adjustment (ECI Models)
- Idle Speed Control - Specifications Update
- Brakes - Pad Installation Service Points
- Spark Plug - Fouling
- Engine - Crankshaft Bushing Reminder
- Timing Belt - Index Marks Manual Correction
- Engine - Timing Belt Tension Adjustment
- Cylinder Head - Distortion Limits
- Engine - Revised Cylinder Head Bolt Torques
- Engine - Automatic Valve Lash Adjuster Noise
- Engine - Valve Lash Adjuster Cleaning Procedure
- Engine - Auto Valve Lash Adjuster, Manual Update
- Piston Pin - Installation Tool Instructions
- Engine - Cylinder Block Distortion Limit Specification
- Engine - Oil Pump Drive Gear Modifications
- Engine - New Oil Pump May Reduce Noise
- Engine - Piston Pin Installation Tool
- Tools - Piston Pin Tool Operating Instructions
- Recall - Emission Service
- Shock Absorber, Rear - Bolt Torque
- Wheel - Balancing Accuracy Tips
- Wheels - Lug Nut Torque Information and Chart
- Interior - Wind Noise Diagnosis
- Drivetrain - Precaution Removing Driveshaft
- A/T - KM170 Oil Pump Gasket
- A/T Oil Cooler - Backflush Alternative
- A/T - Perform Cooler Flow Test When Replacing A/T
- Clutch Release Cylinder - Repair Kit
- Engine Controls - Never Use a Test Light To Check an ECM
- Brakes - Push Rod Clearance Specifications
- Battery - Care During Long Term Storage
- Battery - Application Guide/Cold Cranking Amp Specs.
- Distributor - Timing Specifications
- Engine - Idle-Up Adjustment, Carbureted Models with A/C
- Engine - Sag or Hesitation when Started Cold
- Recall - Recall Performance Confirmation
- Engine - Turbo Cross-Fire Shock
- Windows - Repair of Rear Defogger Grid
- Rear Window Defogger Grid - Repair
- Brakes - Rotor Service Procedures
- A/C - High Pressure Service Valve Adapter
- M/T - KM162 & KM163 Input Shaft Locknut Torque
- Feedback Control System - Service Manual Update
- Headlamps - Aiming Adapters
- Engine - Formed-In-Place Oil Pan Gasket
- Antilock Brake System - Diagnosis
- Steering Wheel - Centering
- Power Steering Gear - Overhaul
- Synthetic Resin Parts - Heat Resistance Specifications
- VIN - Codes
- Body - Noise Diagnosis
- Tools - Fault Codes When Using the Multi-Use Tester
- Emissions Certification - Identification Update
- Emission Control System - Update
- Emission - Control Information Label Ordering
- Emissions - Correct Diagnosis of Emission Control Parts
- FBC & ECI - Voltmeter Test Procedure
- Engine Controls - DTC P0441
- Tools - MSN Multi-Use Tester ROM Pack Update
- Tools - Multi-Use Tester ROM Pack Usage
- Tool - Multi-Use Tester Application Chart
- Tools - Multi-Use Tester ROM Pack Usage
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Audio - Speaker Troubleshooting Manual Supplement
- Windshield - Installation Instructions
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- A/T - KM 172 Valve Body O-Rings
- A/T - Gear Noise Reduction
- A/T - Recommended Fluid
- A/T - KM170 Series Transaxle Case Gasket - Improvement
- A/T - Planet Carrier Bolt Specification Change
- Transmission - Identification Codes
- A/T - New End-Play and Preload Measurement
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Identification
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- M/T - Diagnosing The KM162/163 Transmission
- A/T - Choosing the Right ATF
- Transaxle Synchronizer Assembly - Information
- Manual Transaxle - No-Shift Condition
- M/T - Flywheel Surfacing Limit
- Automatic Transmission - Fluid Recommendations
- Crankcase - Drain Plug Gasket
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Remote Keyless Entry - Update
- Seat Belt - Rear Shoulder Belt Installation
- Interior - Buzz, Squeak, and Rattle Kit
- Window - Chemical Film Build-Up/Fogging
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Paint - Codes
- Paint - Code Index
- Paint - Damage Identification and Repair
- Fuel - Pressure Test Adapter Couplers
- A/C - Water Temperature Switch Torque Spec Revision
- Water Temperature Switch - Torque Specification
- Engine, Valves - Valve Adjuster Noise Diagnosis
- Fluids, Refrigerants and Materials (Genuine Mitsubishi)
- A/C Refrigerant - Service Information
- Overview
- Refrigerants and Their Availability
- System Differences
- Refrigerant Differences
- Lubricant Differences
- Retrofitting Systems
- Recovery and Recycling of Refrigerants
- Storing Recycled Refrigerant
- Transferring Recycled Refrigerant
- System Flushing
- Typical Cause of A/C System Contamination
- Mixing Refrigerants
- Contaminated Service Equipment
- Disposing of Contaminated Refrigerant
- M/T - Gearshift Lever Design Change
- M/T - Fluid Recommendation/Caution
- Brakes - Judder (vibration) Diagnosis and Repair
- A/C - Refrigerant Temperature Switch Manual Correction
- Engine - Pinging Condition
- A/C - Refrigeration Oil Specification
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Body/Frame - Corrosion Inhibitor Information
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Lighting - Headlamp Moisture Information
- Alignment - Two Wheel Vs. Four Wheel