Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall 00V421001: Lower Ball Joint Separation
- Recall 99V066001: Damaged Lower Ball Joint Boots
- Recall 99V066002: Damaged Lower Ball Joint Boots
- Recall - Lower Ball Joint/Control Arm Inspection
- Recall 98V020000: Sunroof Control Defect
- Recall 98V212000: False ABS Warning Light Problem
- Recall - Fuel Tank Leak
- Recall 00V237000: Possible Fuel Tank Leaks
- Recall - Stop Light Malfunction
- Customer Interest
- Steering - Drift Diagnosis And Correction.
- Engine - Valve Noise at Start-up
- Spark Plug - Fouling
- A/C - Resonating `Whooping' Noise
- Front Suspension - Popping/Knocking/Clunking
- Rear Shock Absorber - Thumping/Knocking Noise
- Steering - Drift Diagnosis And Correction
- Sunroof - Water Leak
- A/T - Gear Selection Noise, Acceleration Clunk/Vibration
- ABS - Light ON Intermittently/Multiple DTC's Set
- Battery - Discharges at Idle Speed
- A/T- Harsh 3 to 2 Downshift
- Door Trim Panel - Peeling/Gap
- Audio System - Speaker Static/Buzzing/Inoperative
- Brakes - Grinding/Scraping Noise/Premature Wear
- Front Doors - Hard to Open From Outside
- Ignition Switch - Key Difficult to Remove
- Radio - Poor Reception
- Window - Chemical Film Build-Up/Fogging
- Paint - Spotting/Whitening
- Suspension - Front Creaking/Poping/Squeaking Noises
- Brakes - Judder (vibration) Diagnosis and Repair
- Sunroof - Trim Cover Loose
- Factory Modifications
- Recommended Repairs
- Superceded Bulletins
- 99-002 - 06/01/99
- 96-11-002 - 03/01/96
- 91-52B-002 - 02/01/97
- 05-54-002 - 02/01/04
- 03-55-005 - 06/01/03
- Lighting - Moisture In Headlamps
- Speedometer/Odometer - Replacement/Mileage Setting
- Audio System - Diagnosis
- Remote Keyless Entry - Service Information
- Recall - Lower Lateral Arm Ball Joint Boot
- Recall - Lower Ball Joint Replacement
- Cylinder Block - Heater Installation Procedure
- Engine Block Heater - Application and Installation
- Battery - Discharges During Idling
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Sealant/Adhesive/Chemical - Interchange Information
- Tools - Multi-Use Tester Warranty
- VIN - Decoding Information
- VIN - Decoder
- VIN - Decoding
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- Steering - Drift Diagnosis And Correction.
- Engine - Valve Noise at Start-up
- Fuel Pump - Revised Testing Procedure
- Spark Plug - Fouling
- A/C Lap Cooler Duct - Service Manual Revision
- A/C Magnetic Clutch - Corrected Service Procedures
- A/C - Resonating `Whooping' Noise
- Engine - Revised Nut & Bolt Tightening Specifications
- Engine - Valve Lash Adjuster Cleaning Procedure
- Valve Lash Adjuster Noise - Troubleshooting Procedures
- Piston Pin - Installation Tool Instructions
- Engine - Piston Ring Installation Corrections
- Timing Belt Auto Tensioner - Testing
- A/C Receiver Pressure Switches - Manual Revision
- Front Suspension - Popping/Knocking/Clunking
- Lateral Lower Arm Ball Joint - Torque Revision
- Recall 00V421001: Lower Ball Joint Separation
- Recall 99V066001: Damaged Lower Ball Joint Boots
- Recall 99V066002: Damaged Lower Ball Joint Boots
- Recall - Lower Ball Joint/Control Arm Inspection
- Rear Shock Absorber - Thumping/Knocking Noise
- Wheel - Balancing Accuracy Tips
- Steering - Drift Diagnosis And Correction
- Interior - Wind Noise Diagnosis
- Sunroof - Water Leak
- Recall 98V020000: Sunroof Control Defect
- A/T - Gear Selection Noise, Acceleration Clunk/Vibration
- A/T Oil Cooler - Backflush Alternative
- A/T - Perform Cooler Flow Test When Replacing A/T
- Fuel Injector - Resistance Values Revised
- Engine Controls - PCM Reprogramming Procedure
- O2 Sensor - Revised Resistance Values
- CV Joint Boot - Replacement Tool/Installation
- Recall 98V212000: False ABS Warning Light Problem
- ABS - Light ON Intermittently/Multiple DTC's Set
- Brake Booster - Push Rod Adjustment
- Battery - Discharges at Idle Speed
- Battery - Application Guide/Cold Cranking Amp Specs.
- Generator Stator - Removal Procedure Revision
- Park/Nuetral Switch Position Indicator - Manual Revision
- Park/Neutral Switch - Continuity Check Revised
- Fuel - Tank Filler Tube Routing Corrected
- Recall - Fuel Tank Leak
- Recall 00V237000: Possible Fuel Tank Leaks
- Evaporative Emission Purge Solenoid - Correction
- A/T- Harsh 3 to 2 Downshift
- Door Trim Panel - Peeling/Gap
- Rear Window Defogger Grid - Repair
- Audio System - Speaker Static/Buzzing/Inoperative
- Air Bag - Minimizing Deployment Risk
- SRS Air Bag Troubleshooting - Revision
- SRS Cautions and Warnings - Revision
- SRS - Trouble Shooting, Front Impact Sensor Inspection
- SRS - Diagnostic Trouble Code (DTC) Erasure
- Engine - Block Heater Update
- Headlights - Aiming Procedures Revised
- Brakes - Grinding/Scraping Noise/Premature Wear
- Recall - Stop Light Malfunction
- ABS Solenoid Valve - Internal Resistance Revision
- ABS Troubleshooting Chart - Service Manual Revision
- Antilock Brake System - Diagnosis
- Payload/Gross Vehicle Weight Rating Information
- Synthetic Resin Parts - Heat Resistance Specifications
- Body - Noise Diagnosis
- SRS - Troubleshooting Revision
- SRS Warning Lamp Bulbs - Manual Correction
- Engine Controls - DTC P0441
- Wiring Harness - Connector Compatibility
- Tools - Enhanced Diagnostic Testing & Feature Software
- Automatic Transmission - Waveform I.D. Correction
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Front Doors - Hard to Open From Outside
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- Coolant Breather Plug Washer - Thickness Change
- A/T End Clutch - Improved
- Automatic Transaxle - Improved Rear Clutch
- A/T - Remanufacturing Program.
- A/T, Remanufactured - Program Update
- Transmission - Identification Codes
- A/T - New End-Play and Preload Measurement
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Third Gear Limp-in Condition
- A/T - KM175 Delayed Forward Engagement
- A/T - KM175 Harsh Downshifts
- A/T - KM175 Series 1-2 Bind Up
- A/T - No 2nd, Multiple Codes, Tapping Noise
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Recommended Maintainence
- Toe Control Arm Adjustment - Graduation Value Revised
- Ignition Switch - Key Difficult to Remove
- Idle Switch Inspection - Service Manual Revision
- Engine - Oil Economy Test
- Engine - Oil Consumption/Oil Economy Test
- Circuit Diagram Configuration - Corrections
- Fuel - Poor Driveability Using Premium
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Front Drive Shaft Repair Kits - Service Manual Revision
- Remote Keyless Entry - Update
- Radio - Poor Reception
- Antenna - Inspection and Caution Revision
- Automatic Transaxle - Shift Characteristics of F4A
- Interior - Buzz, Squeak, and Rattle Kit
- Window - Chemical Film Build-Up/Fogging
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Paint - Damage Identification and Repair
- Paint - Spotting/Whitening
- A/C - Compressor Pressure Relief Valve Service
- Fluids, Refrigerants and Materials (Genuine Mitsubishi)
- A/C - Refrigerant Capacities
- A/C Refrigerant - Service Information
- Overview
- Refrigerants and Their Availability
- System Differences
- Refrigerant Differences
- Lubricant Differences
- Retrofitting Systems
- Recovery and Recycling of Refrigerants
- Storing Recycled Refrigerant
- Transferring Recycled Refrigerant
- System Flushing
- Typical Cause of A/C System Contamination
- Mixing Refrigerants
- Contaminated Service Equipment
- Disposing of Contaminated Refrigerant
- M/T Shift Lever - Operational Inspection Revision
- Homelink Universal Transmitter System - Features
- Garage Door Transmitter - Reprogramming Procedure
- Suspension - Front Creaking/Poping/Squeaking Noises
- Door Lock Circuit Diagrams - Service Manual Revision
- Brakes - Judder (vibration) Diagnosis and Repair
- Engine - Pinging Condition
- Sunroof - Trim Cover Loose
- Interior - Child Safety Seat Upper Tether Anchor Kits
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Restraints - Revised Clockspring Alignment Procedure
- Body/Frame - Corrosion Inhibitor Information
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Lighting - Headlamp Moisture Information
- Powertrain - DTC P0172 & P0175
- Alignment - Two Wheel Vs. Four Wheel
- Engine Controls - Revised Misfire DTC Information
- Restraints - Revised SRS ECU Removal and Installation