Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Fender - Rear Flare Trim Loose
- Spark Plug - Fouling
- A/C - Musty/Moldy Odors In Passenger Compartment
- Engine - MIL ON/P0300 - P0306 Misfire DTCs/Knock
- Cooling System - Upper Radiator Fan Shroud Crack
- Vehicle - Body Vibration
- Front Door - Weatherstrip Wind Noise
- Steering - Column Rattle/Steering Wheel Vibration
- Differential Whine - Revision
- Audio - Malfunction/Failure
- Audio System - Speaker Static/Buzzing/Inoperative
- SRS Air Bag - Passenger Side Cover Fits Poorly
- A/C - Pulsating/Rattle Noise
- Body - Squeak Noise on Bumps
- Fuel/Emissions - Sulfur Odor From Exhaust
- Liftgate Hatch - Noise From Rear of Vehicle
- Rear Liftgate - Improved Gas Spring
- Windshield - Wind Noise
- Rear Mud Guard - Poor Adhesion
- Cup Holder - Breakage
- Driver Side Knee Protector Surface Peeling
- Instrument Panel - Rattling Noise
- Propeller Shaft (Driveshaft)- Vibration
- Differential - Whining Noise
- Audio System - Static/Popping/Poor Sound/Distortion
- Interior - Cargo Area Wheel Housing Carpet Loose
- Transfer Case Shift Lever - Stuck in 4H
- Manual Transmission - Shift Lever Rattle
- Brakes - Judder (vibration) Diagnosis and Repair
- Recommended Repairs
- Superceded Bulletins
- 98-42A-007R - 11/01/98
- 98-42A-007 - 09/01/98
- 98-31-001 - 02/01/98
- 98-27-001 - 06/01/98
- 98-23-005 - 05/01/98
- 97-54-015 - 12/01/97
- 97-51-002 - 12/01/97
- 91-52B-002 - 02/01/97
- 05-54-002 - 02/01/04
- 03-55-005 - 06/01/03
- 01-00-011 - 07/01/01
- 00-42A-003 - 04/01/00
- 00-23-004 - 05/01/00
- Lighting - Moisture In Headlamps
- Speedometer/Odometer - Replacement/Mileage Setting
- Audio System - Diagnosis
- Remote Keyless Entry - Service Information
- Scan Tool - Warranty Coverage/Repair Return Procedures
- OBD II Monitor Readiness - Drive Cycle Procedures
- Engine - Testing for Excessive Oil Consumption
- Engine - Oil Economy Test/Consumption Diagnosis
- Cylinder Block - Heater Installation Procedure
- Engine Block Heater - Application and Installation
- A/C - Rattling/Pulsating Noise With A/C ON
- All Technical Service Bulletins
- Fender - Rear Flare Trim Loose
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Sealant/Adhesive/Chemical - Interchange Information
- Tools - Multi-Use Tester Warranty
- VIN - Decoding Information
- VIN - Decoder Chart
- Electrical Wiring - Circuit Diagram Changes
- A/C & Heated Seats - Corrections to Wiring Diagrams
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- Tool - Battery/Starting/Charging System Analyzer
- Fuel Pump Relay - Circuit Identification Corrections
- Spark Plug - Fouling
- A/C - Musty/Moldy Odors In Passenger Compartment
- Engine - Piston & Connecting Rod Reassembly Revision
- Crankshaft Bearing - Procedure Correction
- Crankshaft - Identification Mark Revision
- Engine - Valve Lash Adjuster Cleaning Procedure
- Piston Pin - Installation Tool Instructions
- Engine - Replacement Piston Selection
- Piston - Oil Ring Identification & Color Revision
- Engine - MIL ON/P0300 - P0306 Misfire DTCs/Knock
- Cooling System - Upper Radiator Fan Shroud Crack
- Steering - Cautions for Steering Angle Adjustment
- Ball Joint Dust Cover - Grease Application Revision
- Snow Tires - List of Recommendations
- Tires - Vibration Diagnosis
- Tires - Chain Use Tables
- Tires - Goodyear(R) Product Service Locations
- Vehicle - Body Vibration
- Interior - Wind Noise Diagnosis
- Front Door - Weatherstrip Wind Noise
- Sunroof - Changed Sunroof Water Test
- Steering - Column Rattle/Steering Wheel Vibration
- Differential Whine - Revision
- Propeller Shaft - Installation Procedure
- Differential - Revised Gear Oil Specification
- A/T Oil Cooler - Backflush Alternative
- A/T - Perform Cooler Flow Test When Replacing A/T
- Clutch Pedal Interlock Switch/Return Spring - Revisions
- Engine Controls - PCM Reprogramming Procedure
- Vehicle Speed Sensor & Power Window Switch - Correction
- Brakes - Caliper Bolt Revised Tightening Torque
- Battery - Application Guide/Cold Cranking Amp Specs.
- A/T - Park/Neutral Position Switch Adjustment
- Rear Window Defogger Grid - Repair
- Audio - Malfunction/Failure
- Audio System - Speaker Static/Buzzing/Inoperative
- Air Bag - Minimizing Deployment Risk
- SRS Air Bag - Passenger Side Cover Fits Poorly
- SRS Air Bag - Label Position Revised
- SRS - Diagnostic Trouble Code (DTC) Erasure
- Brakes - Disc Run-Out Specification Limits
- Engine - Block Heater Update
- Crankshaft - Additional Bearing Descriptions
- A/C - Pulsating/Rattle Noise
- Recall 00V311000: Possible Loss of Power Steering
- Recall 00V311001: Crankshaft Pulley Bolt Loosens
- Antilock Brake System - Diagnosis
- ABS Troubleshooting - Service Manual Corrections
- Steering - Revised Tie Rod & Relay Rod Nut Torque
- Payload/Gross Vehicle Weight Rating Information
- Synthetic Resin Parts - Heat Resistance Specifications
- Recall 98V205000: Cargo Mat Prevents Third Seat Latch
- Body - Squeak Noise on Bumps
- Body - Noise Diagnosis
- Antitheft - Alarm Circuit Wiring Diagram Correction
- Fog Light & Antitheft Alarm - Circuits Revisions
- Emissions/Engine Controls - Readiness Test Updates
- Emissions - OBDII Readiness Code Information
- Emissions - OBD-II I/M Program Summary
- Fuel/Emissions - Sulfur Odor From Exhaust
- Engine Controls - DTC P0441
- Tools - Enhanced Diagnostic Testing & Feature Software
- MIL ON - DTC P1715 Procedure Correction
- A/T - DTC Set Conditions Revised
- A/T - Control Circuit Diagram Revisions
- A/T - Control Circuit Diagram Revisions
- A/T - DTCs 29, 30, 31, & 32 Set Criteria Corrections
- Cruise Control - DTC 12 Troubleshooting Revision
- Scan Tool - Multi-Use Tester II Warranty Coverage
- Engine Controls - SCAN Tool Display Term Changes
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Liftgate Hatch - Noise From Rear of Vehicle
- Rear Liftgate - Improved Gas Spring
- Rear Door Glass Holder - Installation Revisions
- Windshield - Wind Noise
- Wipers/Washers - Wiper Nut Torque Revisions
- Rear Mud Guard - Poor Adhesion
- Cup Holder - Breakage
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- Power Steering Hose - Mounting Nut Tightening Torque
- Recall 98V220000: Front Brake Lines Chafing
- Recall - Front Brake Tube
- A/T - V4AW3 Forward Clutch Piston Stroke Revisions
- A/T - New End-Play and Preload Measurement
- M/T - Recommended Maintainence
- Audio System - CD Player Functional Problems
- Fog Light - Relay Addition
- Electrical - Wiring Diagram/Component Location Revision
- SRS Clock Spring Check - Correction
- Driver Side Knee Protector Surface Peeling
- Instrument Panel - Rattling Noise
- A/C - Service Manual Revisions
- Engine - Oil Consumption/Oil Economy Test
- Fuel - Poor Driveability Using Premium
- Propeller Shaft (Driveshaft)- Vibration
- Differential - Whining Noise
- Remote Keyless Entry Security System - Troubleshooting
- Remote Keyless Entry - Update
- Interior - Buzz, Squeak, and Rattle Kit
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Audio System - Static/Popping/Poor Sound/Distortion
- Paint - Exterior Color Code & Cross Reference
- Interior - Cargo Area Wheel Housing Carpet Loose
- Recall - Rear Cargo Mat
- Seats - Heater Circuit Locator & Diagrams Revised
- A/C - Compressor Pressure Relief Valve Service
- Fluids, Refrigerants and Materials (Genuine Mitsubishi)
- A/C Refrigerant - Service Information
- Overview
- Refrigerants and Their Availability
- System Differences
- Refrigerant Differences
- Lubricant Differences
- Retrofitting Systems
- Recovery and Recycling of Refrigerants
- Storing Recycled Refrigerant
- Transferring Recycled Refrigerant
- System Flushing
- Typical Cause of A/C System Contamination
- Mixing Refrigerants
- Contaminated Service Equipment
- Disposing of Contaminated Refrigerant
- Transfer Case Shift Lever - Stuck in 4H
- Manual Transmission - Shift Lever Rattle
- Manual Transmission - Shift Lever R & R Procedure
- Power Lock System - Circuit Diagram Revision
- Brakes - Judder (vibration) Diagnosis and Repair
- Engine - Pinging Condition
- Suspension - Camber Adjustment Specification Changed
- A/T - Corroded Harness Splice Connections
- Interior - Child Safety Seat Upper Tether Anchor Kits
- Emissions - Additional EGR System Diagnostics
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Body/Frame - Corrosion Inhibitor Information
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Lighting - Headlamp Moisture Information
- Powertrain - DTC P0172 & P0175
- Alignment - Two Wheel Vs. Four Wheel
- Engine Controls - Revised Misfire DTC Information
- Restraints - Revised SRS ECU Removal and Installation