Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Safety
- Recall 00V225001: Possible Steering Defect
- Recall 01V011001: A/T Cooler Line Replacement
- Recall 01V005001: Driver's Seat Mounting Bolts Defect
- Recall - A/T Cooler Line Replacement
- Recall 01V011001: Transaxle Oil Cooler Hose Defect
- Recall 00V299001: Possible CKP Sensor Harness Defect
- Recall - Fuel Return Hose Replacement
- Recall - Fuel Tank Replacement
- Recall 01V069000: Fuel Tank Defect
- Recall 00V320001: Possible Fuel Hose Leak
- Recall - Seat Anchor Bolt Defect
- Customer Interest
- Audio System/A/C Blower - Intermittent Operation
- A/T - Shudder/Surge/Vibration From 35 - 50 Mph
- Engine Controls - Rough Idle/DTC's P0300-P0306
- A/C - Musty/Moldy Odors In Passenger Compartment
- Rear Wheel Bearing - Noise
- Engine Controls - Hard Hot Start/Rough Idle
- Door/Glass - Wind Noise/Water Leaks/High Closing Effort
- Brakes - Front Brake Ringing Noise
- Speakers - Popping Noise During Seat Switch Operation
- Audio System - Speaker Static/Buzzing/Inoperative
- Lighting - Headlamp Lens Fogging
- Front Stabilizer Bushings - Creaking/Popping Noise
- Fuel/Emissions - Sulfur Odor From Exhaust
- Body - Liftgate Half-Latching Condition
- Door Window - Musty Odor
- Sunroof - Judder/Vibration During Operation
- Body - Sunroof Judder/Vibration
- Body - Water Leak to Interior From Mirror Trim
- Engine - Overheating/Low Coolant Level/Noise
- A/T - 2-3 Shift Flare/Slipping
- Suspension - Rear Trailing Arm Squeaking/Rubbing Noise
- Audio System - Static/Popping/Poor Sound/Distortion
- A/C - Water Leaks to The Interior
- Interior - Difficult Front Seat Sliding Effort
- Side Air Bag Module - DTC 72 or 82 Set
- Electrical - Radio/Dome Lamp/Keyless Entry Inoperative
- Superceded Bulletins
- 05-23-004R - 08/01/05
- 05-54-002 - 02/01/04
- 03-55-005 - 06/01/03
- 01-00-011 - 07/01/01
- 00-51-001 - 09/01/00
- 00-42A-002 - 04/01/00
- Door Window - Odor
- Door Window - Wind Noise/Water Leaks
- Lighting - Moisture In Headlamps
- Speedometer/Odometer - Replacement/Mileage Setting
- Sunroof - Judder/Vibration
- Sunroof - Judder/Vibration On Operation
- Body - Bumper Facia Preparation for Painting
- Keyless Entry - ID Mode Canceling Conditions Revision
- Rear Suspension - Squeaking/Rubbing Noise
- A/T - Shudder/Surge/Vibration
- A/T - 2-3 Shift Flare
- Engine Controls - Hard Hot Restart/Rough Idle/DTC's Set
- Engine - Testing for Excessive Oil Consumption
- Engine - Oil Economy Test/Consumption Diagnosis
- Tires/wheels - Tire Chain Usage Information
- Radio/Electronics - Intermittent Loss of Power
- A/C - Receiver Outlet Pipe Replacement
- A/C - Water Leaks Into The Passenger Compartment
- Engine Controls - Hard Hot Re-Start/Rough Idle
- Engine Controls - Cold Engine Misfire Condition
- Engine Controls - Cold Engine Misfire
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Restraints - SRS Component Disposal Information
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Body - Bumper Fascia/Plastic Fender Paint Preparation
- Vehicle - Load Capacity Reduction Label Information
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- General Specifications
- Audio System/A/C Blower - Intermittent Operation
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- A/T - Shudder/Surge/Vibration From 35 - 50 Mph
- Tool - Battery/Starting/Charging System Analyzer
- Audio System - No Radio/Audio Controls Locked-Up
- Engine Controls - Rough Idle/DTC's P0300-P0306
- A/C Magnetic Clutch - Corrected Service Procedures
- A/C - Musty/Moldy Odors In Passenger Compartment
- Rear Wheel Bearing - Noise
- Recall 00V225001: Possible Steering Defect
- Engine - Valve Lash Adjuster Cleaning Procedure
- Engine - Replacement Piston Selection
- Engine Controls - Hard Hot Start/Rough Idle
- Suspension - Ball Joint End Play Procedure Revision
- Tire Chains - Usage Precautions
- Tires - Goodyear(R) Product Service Locations
- Door/Glass - Wind Noise/Water Leaks/High Closing Effort
- Recall 01V011001: A/T Cooler Line Replacement
- Recall 01V005001: Driver's Seat Mounting Bolts Defect
- Vehicle - Aftermarket Accessories Precautions
- Recall - A/T Cooler Line Replacement
- Recall 01V011001: Transaxle Oil Cooler Hose Defect
- A/T Solenoid Valve Harness - Update
- Camshaft Position Sensor - Manual Correction
- Engine Controls - PCM Reprogramming Procedure
- DTC P0134 & P0154 (O2S) - Diagnosis Corrections
- Brakes - Front Brake Ringing Noise
- Battery - Application Guide/Cold Cranking Amp Specs.
- Alternator - FR Terminal Voltage Revision
- Recall 00V299001: Possible CKP Sensor Harness Defect
- Recall - Fuel Return Hose Replacement
- Recall - Fuel Tank Replacement
- Recall 01V069000: Fuel Tank Defect
- Recall - Emissions Vacuum Hose Routing Label
- Speakers - Popping Noise During Seat Switch Operation
- Audio System - Speaker Static/Buzzing/Inoperative
- Engine - Block Heater Update
- Lighting - Headlamp Lens Fogging
- A/C - Refrigerant Pipe Replacement
- TCL Solenoid Valve - Service Manual Corrections
- Brakes/Emissions - I/M Dynometer Testing on TCL Models
- Front Stabilizer Bushings - Creaking/Popping Noise
- Payload/Gross Vehicle Weight Rating Information
- Body - Noise Diagnosis
- Model VIN Codes Revised
- Engine Controls - Revised Vacuum Routing Diagrams
- Fuel/Emissions - Sulfur Odor From Exhaust
- Engine Controls/Emissions - OBDII Drive Cycle Revisions
- Engine Controls - DTC P0441
- DTC P0441 - Service Manual Update
- Scan Tool - Multi-Use Tester II Warranty Coverage
- Engine Controls - SCAN Tool Display Term Changes
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Body - Liftgate Half-Latching Condition
- Door Window - Musty Odor
- Sunroof - Judder/Vibration During Operation
- Body - Sunroof Judder/Vibration
- Window - Door Glass Alignment
- Wipers/Washers - Wiper Nut Torque Revisions
- Body - Water Leak to Interior From Mirror Trim
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- Engine - Overheating/Low Coolant Level/Noise
- A/T - 2-3 Shift Flare/Slipping
- A/T - Revised Bolt Torque Values
- A/T - Hydraulic Pressure Manual Update
- A/T - New End-Play and Preload Measurement
- Audio System - CD Player Functional Problems
- Heating, A/C - Mode/Temperature Control Parts
- Suspension - Rear Trailing Arm Squeaking/Rubbing Noise
- A/T - No Overdrive/Shift Delay
- A/C - Service Manual Revisions
- Engine - Oil Consumption/Oil Economy Test
- A/T - ATF Temperature Sensor/Harness Manual Revision
- Recall 00V320001: Possible Fuel Hose Leak
- Cruise Control - Troubleshooting Instructions
- Cruise Control - Revised Checking Procedures
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Remote Keyless Entry - Systems Identification
- Keyless Entry - ID Mode Canceling Conditions Update
- Keyless Entry - Answerback Switching Procedures Revision
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Audio System - Static/Popping/Poor Sound/Distortion
- Color Codes - Information and Cross Reference
- Fuel Tank Filler Valve Flap - Elimination
- A/C - Water Leaks to The Interior
- A/C - Compressor Pressure Relief Valve Service
- A/C - Compressor Pressure Relief Valve Service Revisions
- Recall - Seat Anchor Bolt Defect
- Interior - Difficult Front Seat Sliding Effort
- A/C Drain Hose - Service Manual Correction
- Fuel System - Tank Pressure Sensor Specification Update
- A/C System - In Car Filter Installation
- Engine - Pinging Condition
- Side Air Bag Module - DTC 72 or 82 Set
- A/C - Water On Passenger's Side Floor
- Brakes - Master Cylinder Service Revision
- Electrical - Radio/Dome Lamp/Keyless Entry Inoperative
- Body - Bumper Fascia Painting Preparation
- Emissions - Additional EGR System Diagnostics
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Restraints - Revised Clockspring Alignment Procedure
- Body/Frame - Corrosion Inhibitor Information
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Powertrain - DTC P0335 & P0340 After Engine Repair
- Powertrain, Antitheft - ECU & PCM Replacement
- Lighting - Headlamp Moisture Information
- Powertrain - DTC P0172 & P0175
- Powertrain - DTC's P0335 & P0340 After Engine Repair
- Alignment - Two Wheel Vs. Four Wheel
- Engine Controls - Revised Misfire DTC Information
- Body - Revised Door Adjustment Procedure
- Restraints - Revised SRS ECU Removal and Installation