Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall - Fuel Filler Pipe Inspection/Replacement
- Recall 05V409000: Brake Master Cylinder Defect
- Recall - Brake Master Cylinder Replacement
- Recall 06V068000: Potential Front Brake Caliper Defect
- Recall - Front Brake Caliper Inspection/Replacement
- Recall 05V069000: Park Brake Cable Lock Nut Torque
- Recall - Park Brake Cable Lock Nut Torque
- Recall 08V139000: Shift Interlock Defect
- Recall - A/T Shift Interlock Defect
- Recall 08V454000: Fuel Tank Mounting Strap Defect
- Recall - Fuel Tank Support Bracket Reinforcement
- Customer Interest
- Body - Creaking/Cracking From Quarter Panel Area
- Body - Roof Rack Side Rail Paint Fading/Peeling
- A/C - Sloshing Noise From Dash/Water Dripping Onto Carpet
- Tire Monitor System - Warning Lamp ON/Sensor DTC's Set
- A/C - Water Leaks Onto Driver's Side Floor
- A/T - Hard To Shift From PARK/Remove Key From Ignition
- Exhaust System - Heat Shield Rattling Noises
- Lighting - High Mount Brake Lamp Lens Cracked
- Engine Controls - Spark Knock/DTC's Set
- Engine Controls - MIL ON/Multiple DTC's Set
- A/T - 2-3 Shift Flare/Slipping
- Engine Controls - PCM Update for Misfire DTC Diagnostics
- Engine Controls - MIL ON/DTC P2100/P2138/P0736/P1784
- Body, A/C - Water Leak Onto Floorboard
- Body - Quarter Glass Molding Fading/Peeling
- Interior - Poor Power Seat Operation/Noise When Operated
- Body - Squeak From Rear Floor Area
- Superceded Bulletins
- 11-31-001 04/20/11
- 09-55-002 - 09/01/09
- 10-31-001 - 01/19/10
- 05-23-004R - 08/01/05
- SR-05-001 - 03/01/05
- Lighting - Moisture In Headlamps
- Lighting - High Mount Stop Lamp Lens Cracked
- Interior - Improper Power Driver's Seat Operation
- Body - Sunroof Wind Noise Water Leaks
- Body - Roof Rack Side Rail Paint Fading/Peeling
- Body - Paint Peeling From Roof Rack Side Rail
- Body - Quarter Glass Moulding Fading/Peeling
- 04-51-003 - 09/01/2004
- Body - Bumper Facia Preparation for Painting
- A/C - Water Leaks Onto Front Floor Area
- Suspension - Revised Rear Suspension Bushing Replacement
- SR-08-005 - 09/22/08
- A/T - 2-3 Shift Flare
- All Technical Service Bulletins
- Body - Creaking/Cracking From Quarter Panel Area
- Fuel System - Revised Fuel Pump/Leveling Valve Torque Specs.
- ABS/TCS - Revised Steering Wheel Sensor Service Procedures
- Body - Roof Rack Side Rail Paint Fading/Peeling
- Tire Monitor System - General Service Information
- A/C - Sloshing Noise From Dash/Water Dripping Onto Carpet
- Restraints - SRS Component Disposal Information
- Body - Revised Roof Rail Installation/Disassembly
- Body/Frame - Double-Sided Tape Application Revision
- Tire Monitor System - Warning Lamp ON/Sensor DTC's Set
- Tire Monitor Sys - Revised Sensor ID Registration Proc.
- Exhaust - Revised Exhaust Pipe Service Procedures
- A/C - Water Leaks Onto Driver's Side Floor
- Body - Sunroof Glass Adjustment Procedure
- Electrical - Corrected Rear Blower Motor Fuse Rating
- A/T - Hard To Shift From PARK/Remove Key From Ignition
- Exhaust System - Revised Front Exhaust Pipe Service
- Exhaust System - Heat Shield Rattling Noises
- Recall - Fuel Filler Pipe Inspection/Replacement
- Lighting - High Mount Brake Lamp Lens Cracked
- Fuel System - Fuel Filler Pipe Warranty Extension
- Interior - Floor Mat Selection/Installation Precautions
- ABS/TCS - Revised Self Check Sound Diagnosis
- Body - Bumper Fascia/Plastic Fender Paint Preparation
- Vehicle - Load Capacity Reduction Label Information
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- Transaxle - Gear Whine
- Engine - Gasket Service Parts
- Ignition System - Spark Plug Replacement Revision
- Engine - Valve Lash Adjuster Cleaning Procedure
- Engine - Valve Lifter Noise Diagnosis
- Interior - Driver Seat Side Cover Breakage
- Engine Controls - VIN Registration After ECM/PCM Change
- Recall 05V409000: Brake Master Cylinder Defect
- Recall - Brake Master Cylinder Replacement
- Recall 06V068000: Potential Front Brake Caliper Defect
- Recall - Front Brake Caliper Inspection/Replacement
- Battery - Elimination of Visual Test Indicator
- Alternator - FR Terminal Voltage Revision
- Charging System - Alternator B+ Terminal Replacement
- Engine Controls - Spark Knock/DTC's Set
- Engine Controls - MIL ON/Multiple DTC's Set
- Fuel System - Fuel Tank Hard To Fill
- Instruments - Center Display Compass Troubleshooting
- Instuments - Center Display Compass Troubleshooting
- Recall 05V069000: Park Brake Cable Lock Nut Torque
- Recall - Park Brake Cable Lock Nut Torque
- Brakes/Emissions - I/M Dynometer Testing on TCL Models
- Suspension - Rear Stabilizer Bar Installation Revision
- Ignition - Ignition Key Ring Antenna Manual Revisions
- Body - Noise Diagnosis
- Body - Water Leaks at Rear of Body
- Body/Audio System - Buzz or Rattle from Rear Speaker
- Antitheft System - Immobilizer System Information
- Campaign - Theft Alarm Installation
- Antitheft System - Key Registration Without MUT-III
- Engine Controls/Emissions - OBDII Drive Cycle Revisions
- Engine Controls - DTC P0441
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Engine Controls - Freeze Frame Data For DTC's
- Body - Delta Window Glass Installation Correction
- Glass - Wind Noise from Delta Glass Area
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- A/T - 2-3 Shift Flare/Slipping
- A/T - New End-Play and Preload Measurement
- A/C - Inoperative/A/C Light Blinks
- Instruments - Speedometer is Inoperative
- Tires/Wheels - Tire Chain Usage
- Drivetrain - Whistling Noise Above 20 MPH
- Keyless Entry - Answerback Switching Procedures Revision
- Keyless Entry - System Identification/Operation
- Body - Buzz or Rattle in Rear Speaker Area
- Body - Wind Buffeting
- Paint - Paint Codes
- A/C - New 3-Wire A/C Pressure Sensor
- Electrical - Trailer Hitch Wiring Installation
- Wiring - Trailer Hitch Wiring Installation
- A/C - Plugged HVAC Drain
- Interior - Seat Side Seam Tearing
- Engine - Pinging Condition
- Alignment - Camber Adjustment
- Alignment - Camber Adjustment
- Body - Rear Entertainment Unit Rattle
- Tire Monitor System - Operational Characteristics
- M/T, Fuel - Accelerator/Clutch Pedal Stopper Revision
- Engine Controls - PCM Update for Misfire DTC Diagnostics
- Restraints - Seat Belt Stopper Button Replacement
- Body - Bumper Fascia Painting Preparation
- Engine Controls - MIL ON/DTC P2100/P2138/P0736/P1784
- Instruments - Odometer Reset After Replacing Speedometer
- Engine - Corrected Valve Stem Projection Specs.
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Recall 08V139000: Shift Interlock Defect
- Tire Monitor System - Sensor Information/Registration
- Engine - Connecting Rod Identification Revision
- Computers/Controls - CAN-BUS DTC Additions
- Restraints - Revised Clockspring Alignment Procedure
- Recall - A/T Shift Interlock Defect
- Recall 08V454000: Fuel Tank Mounting Strap Defect
- Suspension - Revised Rear Control Arm Service/Tools
- Body/Frame - Various Body Repair Manual Updates
- Body/Frame - Corrosion Inhibitor Information
- Body, A/C - Water Leak Onto Floorboard
- Recall - Fuel Tank Support Bracket Reinforcement
- Instruments - Center Display DTC Addition
- Engine Controls - DTC P2252/P2253 Diagnostics
- Tire Monitor System - Service/Diagnostic Information
- Body - Quarter Glass Molding Fading/Peeling
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Interior - Poor Power Seat Operation/Noise When Operated
- Tire Monitor System - TPMS Sensor Service Information
- Brakes - Traction Control Lamp on and DTC U1120
- A/C - Revised A/C Indicator Lamp Flashing Diagnostics
- A/C - Revised Ambient Temperature Sensor Diagnosis
- A/T - A/T Learned Value Reset Procedure
- Engine - Oil Filter Installation Precaution
- Engine - Fouled Spark Plugs Causing Misfire
- Instruments - Multi-Center Display Bulb Replacement
- Suspension - Rear Bushing Replacement Tool
- Body - Rear Bumper Side Garnish Hardware
- Engine Controls - PCM VIN Writing Information
- Powertrain, Antitheft - ECU & PCM Replacement
- Lighting - Left Turn Signal Does Not Cancel
- Lighting - Headlamp Moisture Information
- Suspension - Front Camber Adjustment
- Powertrain - Freeze Frame Data & MFI Related DTC's
- Powertrain - DTC P0172 & P0175
- Powertrain - APS Related DTC Information
- Body - Crack at Bottom of Windshield Glass
- Alignment - Two Wheel Vs. Four Wheel
- Suspension - TPMS Update & Reminder
- Body - Squeak From Rear Floor Area
- Engine Controls - Revised Misfire DTC Information
- Body - Revised Door Adjustment Procedure
- Restraints - Revised SRS ECU Removal and Installation