Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Campaign - Additional Vehicles Added to List
- Campaign - Securing Distributor Rotor
- Campaign - Inspection of Electrical Cables and Wiring
- Campaign - Throttle Cable/Fuel Rail Modification
- Campaign - Updated News Listing
- Campaign - Inspect Power Steering Hose
- Campaign - Turbocharger Bypass Valve Installation
- Safety
- Generals
- Customer Interest
- Interior - Water Leakage
- A/C - Evaporator Icing
- Engine - Runs On After Shutting Off
- Fuel Pump - Poor Driveability, Noisy
- Fuel Pump - Poor Driveability, Noisy Operation
- Front Brakes - Noise/Squeal
- Wheel Bearing, Front - Clunking Noise
- Front Wheel Bearings - Rattling Noise
- Crankshaft Pulley - Damaged
- Engine Block - Oil Leakage
- Exhaust - Sulfur Smell
- Sunroof - Rattles While Driving
- Drive Axles - Vibration at Idle
- Clutch - Shrieking Noise On Engagement
- Clutch Release Bearing - Noisy
- A/T - Oil Pan Leakage
- A/T - Loss of Drive
- A/T Cooler Line - Contacts Battery Heat Shield
- Engine - Surging When Re-Applying Throttle
- Turbocharger Inlet Pipe - Hooting Noise
- Fuel Gauge - Erratic Function
- Fuel Gauge - Incorrect Readings
- Reverse Lamps - Stay ON
- Engine - Oil Leaks At Valve Cover Seal
- Front Anti-Roll Bar - Clunking/Groaning Noise
- Vehicle - Tracing Noise Complaints
- Rear Hatch - Correcting A Latching Complaint
- Door Latch - Inoperative
- Hatchback Lid - Service Kit to Reduce Helicopter Noise
- Window Trim - Missing/Loose
- Clutch - Noise
- Engine - Poor Driveability, Hard Starting
- Engine - Difficult Cold Starting and Drive-Away
- Overview
- Cold Start Diagnosis For 1981-83 900, 900S, Turbo
- Cold Start Diagnosis For 1984-85 900, 900S; 1984 Turbo
- Cold Start Complaint - Advice to Owner
- Cold Driveaway Diagnosis For 1981-83 900, 900S, Turbo
- Cold Driveaway Diagnosis For 1984-85 900, 900S; 1984 Turbo
- Cold Driveaway Complaint - Advice to Owner
- Engine - Cold Weather Starting Problems
- Convertible Top - Contacts Window Frame During Closing
- Heated Front Seat - Low Heat Output
- Heating - Flow of Heat From Heater Core Fluctuates
- Body - Stain/Film On Inside Perimeter Of Windshield
- Seals, Gaskets
- Tools, Equipment
- Superceded Bulletins
- 05-06-04-022C - 12/01/06
- 05-06-04-022A - 01/01/06
- 05-06-04-022 - 12/30/05
- 12871017 - 12/01/87
- 06900009 - 06/01/90
- 03891123 - 03/01/89
- 0387938 - 03/01/87
- 02910086 02/01/91
- Paint - Color Codes/Cross References
- Rear Hatch - Rattles
- A/C - R134a Compressors for Converted Systems
- Brake Pads, Front - Service Recommendations
- Brake Pads - New Service Recommendations
- Fuel Tank - Updated Version Available
- Fuel System - Top Tier Gasoline Usage (Canada)
- Fuel System - TOP-TIER Gasoline Usage (Canada)
- Spark Plug - Reference
- All Technical Service Bulletins
- TSB 068911490 Dated 06/01/89 is No Longer Available.
- TSB 0178291 Dated 01/01/78 is No Longer Available
- Expander Rivet Extraction Tool
- Tool - Revised Tip for Connector Pin & Socket Removal
- Maintenance - Lubricants, Fluids, and Other Supplies
- Test Vehicles With Pre-Series B202 Engines
- Tow Line - Availability
- Active Service Campaigns - Updated Listings
- Interior - Water Leakage
- Technical Highlights/Service Reminders
- Corporate Emblem - Program For Replacement
- Tool Kit - New Torx Bit
- A/C - Evaporator Icing
- A/C - Eligibility for Free Product Up Grade
- A/C - R12 to R134a Refrigerant Retrofit
- A/C System - R12 to R134a Conversion/Retrofit
- Campaign - Additional Vehicles Added to List
- Tool - PS Pump Puller Upgrade Adapter Button
- Engines - New Mounting Fixture
- Tool - Remote Starter
- Engine - Runs On After Shutting Off
- Tool - P/S Pump Puller (Upgrade) Adapter Button
- Power Steering Pump Puller - Adapter Upgrade
- Fuel Pump - Poor Driveability, Noisy
- Fuel Pump - Poor Driveability, Noisy Operation
- Fuel Pump - Removal/Installation Tool
- Tool - Flexdriver With 7mm Socket
- Brake Pad - Part Recommendation Changed
- Brakes - Installing Front Pads
- Brake Pads, Front - Revised
- Brake Pads - Approved Designs/Applications
- Brakes - Brake Pad Information
- Front Brakes - Noise/Squeal
- Engine - Valve Reconditioning Tools
- Spark Plug - Updated Replacement Recommendations
- Spark Plug - Application Reference
- A/C System - R134 Conversion Compressors
- Heater Fan Kit/Resistor - Return of Parts
- A/C Evaporator - Hose Clamp To Prevent Cracking
- Wheel Bearing, Front - Clunking Noise
- Front Wheel Bearings - Rattling Noise
- Steering Rack - New Seal Kits
- Campaign - Securing Distributor Rotor
- Crankshaft Pulley - Damaged
- Cylinder Head - Exchange Components
- Cylinder Head - New Torque Specification
- Cylinder Head - Resurfacing
- Engine Block - Oil Leakage
- Engine Block - Pitting Correction
- Radiators - Modifying Fan Shrouds
- Oil Pick-Up Pipe - Holding Tool
- Exhaust - Sulfur Smell
- Vacuum Tank - Noise During Cold Start
- Heater Valve - New Spare Part Installation
- Rims/Tires - Vibration Diagnosis
- Radial Tire - Repair Information
- Snow Tire - Recommendations
- Radial Tire - Repair
- Sunroof - Rattles While Driving
- Headliners - Microfiche Correction
- Drive Axles - Vibration at Idle
- Outboard Drive Shaft CV Joint - Normal Noises
- Clutch - Tools & Replacement Information
- Clutch - Shrieking Noise On Engagement
- Clutch Release Bearing - Noisy
- A/T - Oil Pan Leakage
- A/T - Loss of Drive
- A/T Cooler Line - Contacts Battery Heat Shield
- Clutch Slave Cylinder - Revised
- Clutch - Revised Slave Cylinder & Tools Available
- Lambda Sensor - Using ISAT to Check Pulse Ratio
- Engine - Surging When Re-Applying Throttle
- Automatic Idle Control Valve - Troubleshooting
- CV Joint - New Boot Clamps
- Tool - For Installing CV Joint Boot Clamps
- Brake Calipers - Exchange Program
- Front Brake Calipers - Exchange Components
- Campaign - Inspection of Electrical Cables and Wiring
- Recall - Alternator Cable Position
- Recall - Reposition Alternator Cable
- Alternator - Guarding Against Terminal Grounding
- Ignition Switch - Contacts Binding
- Knock Detector - Revised
- Ignition Distributor - Special Puller
- Ignition Distributor - Overhaul
- Campaign - Throttle Cable/Fuel Rail Modification
- Recall - Fuel Hose Position Inspection
- Recall 85V060000: Flexible Fuel Hose Bent or Twisted
- Recall - Fuel Hose Position/Replacement
- Fuel Tank - Replacement
- Throttle Valve - Basic Setting
- Throttle Valve - Basic Setting Information
- Turbocharger Inlet Pipe - Hooting Noise
- Campaign - Updated News Listing
- Turbocharger Air Bypass Valve - Problem Diagnosis
- Radio - Interference When Tuned to Weak Stations
- Guard Alarm - Replacement Alarm Module
- Cruise Control Switch - Replacement Revisions
- Seat Belt Button - Replacing
- Engine Oil Filters/Drain Plug Gaskets - Part Numbers
- Brake Rotors - Resurfacing/Replacement Guidelines
- Engine Block Heater - Installation
- Fuel Gauge - Erratic Function
- Fuel Gauge - Incorrect Readings
- Oil Pressure Switch - Revised Design
- Reverse Lamps - Stay ON
- Cylinder Head Gasket - Revised
- Cylinder Head Gasket - Redesigned
- Engine - Oil Leaks At Valve Cover Seal
- Front Crankshaft Seal - Special Installation Tool
- Engine - Modifying Crankshaft Pulley Bolt Socket
- Front Anti-Roll Bar - Clunking/Groaning Noise
- Vehicle - Tracing Noise Complaints
- Alarm Pager System - Components & Installation
- Evaporative System - Leak/Pressure Testing
- ISAT Scan Tool Diagnostics Set - Changes
- Tools - ISAT TECH 2
- ISAT Scan Tool - Repair Procedure
- Rear Hatch - Correcting A Latching Complaint
- Door Latch - Inoperative
- Hatchback Lid - Service Kit to Reduce Helicopter Noise
- Center Console - Installing A New Style
- Windshield - Installation On Convertible Vehicles
- Wiper Blades - Care/Maintennance
- Window Trim - Missing/Loose
- Engine/MT/AT - Oil/Fluid Recommendations
- Engine Coolant - Draining Precautions
- Campaign - Inspect Power Steering Hose
- Hub Caps - New Clip Design
- A/T - Designations and Changes
- A/T - Oil Cooling System Flushing
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Clutch - Noise
- M/T - Manual Gearbox Revised
- M/T - Fifth Gear Engagement Noise
- Shift Indicator Light - Revised Description
- M/T - Loctite 510 Availability
- Engine - New Hydraulic Mounts
- Fog Lights - Applications/Part Numbers
- Tools - Adapter For Correcting Oil Line Leaks
- Engine Oil Cooler Hose - Revised
- Tool - New Test Cables for Breakout Box
- Tools - LH Injection System Tester
- Engine - Poor Driveability, Hard Starting
- Wiring - Terminal Repair Kit Contents
- Wiring - Repairing Damaged Splash Proof Connectors
- Recall - Fuel Hose Position
- Engine - Difficult Cold Starting and Drive-Away
- Overview
- Cold Start Diagnosis For 1981-83 900, 900S, Turbo
- Cold Start Diagnosis For 1984-85 900, 900S; 1984 Turbo
- Cold Start Complaint - Advice to Owner
- Cold Driveaway Diagnosis For 1981-83 900, 900S, Turbo
- Cold Driveaway Diagnosis For 1984-85 900, 900S; 1984 Turbo
- Cold Driveaway Complaint - Advice to Owner
- Engine - Cold Weather Starting Problems
- Engine - Cold Start Driveaway Improvement Kit
- New Required Special Tools
- Cruise Control - Testing & Tools
- Tool - Checking Toe In
- Tool - Clutch Release Bearing
- Convertible Top - New Adjustment Specification
- Convertible Top - Contacts Window Frame During Closing
- Antenna - Cleaning Underside When Installing
- Rubber Floor Mats - Availability
- Interior Trim - New Upholstery Material
- Part Numbers of Key Components
- Body - Repairing Paint Finish on Plastic Body Skirts
- Paint - Codes/Cross References
- Rear Mud Flap Kit - Installation
- Campaign - Turbocharger Bypass Valve Installation
- Heated Front Seat - Low Heat Output
- A/T - Front Band Adjustment Spacer
- Heating - Flow of Heat From Heater Core Fluctuates
- A/C - Refrigerant Recycling Equipment
- M/T - New Synchromesh Parts
- Recall - Fuel Hose Positioning
- Scheduled Maintenance - Labor Times
- Specialized Fluids, Lubricants and Supplies
- Maintenance Schedule
- CD Changer - Manually Releasing a CD
- Alignment - Toe-In Information
- Fuel System - TOP TIER Detergent Gasoline
- Body - Stain/Film On Inside Perimeter Of Windshield
- Wheels - Chrome Wheel Staining/Pitting/Corrosion