Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Campaign - Supplemental Child Restraint Information
- Dealer Letter
- Owner Letter - For Installation of a Child Restraint System
- CRS Label Installation Instructions
- Owner Letter - For Correction to the Tire and Loading Information Label
- Updated Tire and Loading Information Label Installation Instructions
- Questions and Answers
- Technical Instructions
- I. Operation Flow Chart
- II. Identification of Affected Vehicles
- III. Preparation
- IV. Background
- V. Components
- VI. Work Procedure
- Campaign - Supplemental Child Restraint Information
- Safety
- Recall - Air Bag Spiral Cable Replacement
- Recall 12V092000: Air Bag Clockspring Replacement
- Recall 06V061000: Tire Inspection/Replacement
- Recall 06V096000: Various Air Bag Defects
- Recall - 05V482000: Tire Label Non-Compliance
- Recall - Side Air Bag Replacement
- Recall 09V388000: Floor Mat/Accelerator Interference
- Recall - Floor Mat/Accelerator Pedal Interferance
- Generals
- Customer Interest
- Canada - Steering - Intermediate Shaft Rattling Noise
- M/T - Clutch Pedal Squeaks When Actuated
- Body - Rust Stains Below Exterior Door Handle(s)
- Canada - Body - Truck Bed Deck Side Panel Rattle
- M/T - Clutch Pedal Slow To Return To Released Position
- Canada - Glass - Upper/Lower Windshield Tick Noise
- Canada - Interior - Water Condensation Dripping From Headliner
- Canada - Instruments - Overhead Compass And Tempature Display
- Canada - Interior - front Seat Squeak Noise
- Canada - Suspension - Rear Spring Harsh Ride
- Canada - Drivetrain - Driveline Vibration Between 24-40 KM/H
- Canada - Interior - Seat Back Upholstery Wire
- Canada - M/T - Clutch Pedal Feel Improvement
- Canada - Interior - Various Interior Trim Panels Loose
- Canada - Interior - Front Seat Squeaking Noises
- Canada - A/C - Blower Motor Noise At Low Temperature
- Canada - Fuel System - Undercab Knocking Noises
- Canada - Engine Controls - MIL ON/DTC P0102 Set
- Canada - Body - Rear Side Panel Skirts Loose
- Canada - Body - Front End Rattle/Squeak On Rough Roads
- Canada - Body - Front/Rear Window Runs Are Deformed
- Canada - Engine Controls - MIL ON/Multiple O2 Sensor DTC's Set
- Canada - A/C - Blower Motor Ticking/Clicking/Squealing Noises
- Canada - Compuetrs/Controls - CAN Module Fails to Initialize
- Canada - A/C - Blower Motor Only Operates On High
- Canada - Suspension - Rear End Squeaking Noise On Bumps
- Canada - M/T - Clutch Slipping In Forward Gears And Reverse
- A/C/Interior - Water Leak From Cowl Area
- Steering - Rattling Noises On Rough Roads
- Body - Squeak Or Rattle From Rear Of Vehicle
- A/C - Blower Motor Ticking/Clicking/Squealing Noises
- A/C - Blower Motor Only Operates On High
- Lighting - DRL/Turn Signal Lens Bubbled/Distorted
- Suspension - Rear End Squeaking Noise On Bumps
- M/T - Rattling Noise In Neutral
- M/T - Clutch Slipping In Forward Gears And Reverse
- Suspension - Harsh Ride - Rear Suspension
- Body - Front End Rattle/Squeak on Bumps
- Engine Controls - MIL ON/DTC P0102 Set
- Fuel System - Under Cab Knocking Noise On Cold Start Up
- Emissions - MIL ON/DTC's P043E/P043F/P2401/P2402/P2419
- Body - Interior Trim Panels/Garnish Loose
- Body - Front/Rear Window Runs Deformed
- M/T - Grinding/Hard to Engage 4WD Low
- Interior - Driver's Side Lower Dash Panel Poor Fit
- Engine - Crankshaft Oil Seal Leak
- Brakes - Front Brake Noise When Applied Backing Up
- Body - Windshield Wind Noise at Highway Speeds
- Lighting - Rear License Plate Lamp Dislodged
- Body - Truck Bed Tailgate is Bent
- Body - Wind Noise Between Front and Rear Doors
- Drivetrain - Rear Differential Whine/Howl At 50-70 MPH
- Interior - Wires Felt Through Seat Back Upholstery
- Engine, A/T Controls - Torque Converter Lock Up Shudder
- Interior - Glove Box Falls Open After Filter Replace
- Tire Monitor System - 'Lost Communication With ECU' Mssg
- Instruments - Compass/Temperature Display Inoperative
- Interior - Squeaking Noises From The Front Seat
- Suspension - Rear Suspension Squeaking Noises
- A/T Controls - MIL ON/DTC P0705 Set
- Suspension - Harsh Rear Suspension Ride With Heavy Load
- Audio System - Distorted Sound From The Sub-Woofer
- Interior - Rattle Noise From Glove Box Area
- Steering - Rattling Noise On Rough Roads
- Body - Water Leaks Onto Rear Carpet Area
- Body - Windshield/Back Glass Ticking Noise
- Interior - Dash Rattles/Ticks Below Glove Box
- Canada - Brakes - Front Brake Noise When Applied Backing Up
- Canada - Drivetrain - Rear Differential Whine/Howl At 50-70 MPH
- Canada - Engine, A/T Controls - Torque Converter Lock Up Shudde
- Canada - Engine - Crankshaft Oil Seal Leak
- Canada - Body - Water Leaks Onto Rear Carpet Area
- Canada - Body - Windshield Wind Noise at Highway Speeds
- Canada - Lighting - Rear License Plate Lamp Dislodged
- Canada - A/T Controls - MIL ON/DTC P0705 Set
- Canada - Audio System - Distorted Sound From The Sub-Woofer
- Canada - Interior - Rattle Noise From Glove Box Area
- Canada - Interior - Dash Rattles/Ticks Below Glove Box
- Canada - Interior - Glove Box Falls Open After Filter Replace
- Canada - Interior - Driver's Side Lower Dash Panel Poor Fit
- Canada - Tire Monitor System - Lost Communication With ECU Mssg
- Canada - Body - Truck Bed Tailgate is Bent
- Canada - Body - Wind Noise Between Front and Rear Doors
- Drivetrain - Rear Driveshaft Clunk/Thunk Noise
- Canada - M/T - Clutch Pedal Squeak/Creak When Operated
- Drivetrain - Driveline Vibration Between 15 - 25 MPH
- Factory Modifications
- Labor/Parts Updates
- Superceded Bulletins
- Body - Squeak/Rattle From Rear of Vehicle
- SU006R-07 - 08/28/07
- SU001-08 - 01/19/08
- BO002-08 - 01/01/08
- Vehicle - Replacement Certification Labels
- EL010-07 - 11/09/07
- Body - Upper/Lower Windshield Tick Noise
- Body - Upper/Lower Windshield Ticking Noise
- Body - Windshield/Back Glass Ticking Noises
- Body - Ticking Noise From Windshield/Back Glass
- Instruments - Digital Compass/Temperature Display Inop.
- Canada - Body - Squeak Or Rattle From Rear Of Vehicle
- Body - Sealing Hem-Flanges And Body Seams
- Body - Body Sectioning
- Tires/Wheels - Spare Tire Carrier Operation
- Interior - Front Seat Squeak Noise
- Interior - Water Dripping From Headliner/Dome Lamp Area
- SB0397-09 - 12/18/09
- Body - Bent Rear Tailgate
- Audio System - Quick Reference Troubleshooting Guide
- Restraints - Seat Belt Extender Availability/Application
- Restraint System - Seat Belt Extender Availability
- Restraints - Seat Belt Tongue Plate Stopper Service
- Recall C0B - Spiral Cable Replacement
- A/C - Blower Motor Ticking/Clicking Sound
- A/C - Blower Motor Squealing Noise When Cold
- Suspension - Shock Absorber Replacement Criteria
- Suspension - Harsh Ride From Rear Springs
- Suspension - Harsh Ride From Rear With Heavy Load
- Suspension - Rear Suspension Squeak on Bumps
- Suspension - Harsh/Rough Ride From Rear Suspension
- Suspension - Harsh Rear Spring Ride With Heavy Loads
- Suspension - Harsh Ride From Rear Suspension
- Canada - Steering - Rattling Noise On Rough Roads
- Steering - Intermediate Shaft Rattling Noises
- BR005-07 - 08/30/07
- Drivetrain Rear Differential Whine/Howl at 50-70 MPH
- Canada - M/T - Clutch Pedal Squeaks When Operated
- M/T - Clutch Pedal Squeaking Noise
- A/T - Remanufactured Transmission Serial Number Location
- A/T - Location Of Serial Numbers
- A/T - Reman Transmission Serial Number Locations
- A/T - Serial Number Locations
- Fuel System - Injector Cleaning Procedure
- Engine Controls - ECU Flash Reprogramming Procedure
- Engine Controls - Techstream(R) ECU Re-Flash Procedure
- Engine - Serial Number Locations
- Electrical Battery Maintenance and Testing
- Engine - Oil Standard/Viscosity Requirements
- Steering - Vehicle Pulls to One Side Manual Supplement
- Steering - Vehicle Pulls To One Side Manual Supplement
- Steering/Suspension - Vehicle Pull Manual Supplement
- A/T - 'World Standard' Transmission Fluid Information
- Tires - Inflation Pressure Compensation/Adjustment
- Vehicle - Long Term Storage Information
- Tires - Pressure Compensation/Adjustment
- All Technical Service Bulletins
- Vehicle - Flood Damage Inspection And Handling
- Canada - Engine Controls - Accelerator Pedal Sensor Precaution
- Canada - Steering - Intermediate Shaft Rattling Noise
- Tires - Tire Repair Resources
- M/T - Clutch Pedal Squeaks When Actuated
- Body - Sealing Hem Flanges And Body Seams
- Body - Rust Stains Below Exterior Door Handle(s)
- Canada - Body - Truck Bed Deck Side Panel Rattle
- Recall - Air Bag Spiral Cable Replacement
- M/T - Clutch Pedal Slow To Return To Released Position
- Canada - Powertrain - A/T Serial Number Location
- Canada - Glass - Upper/Lower Windshield Tick Noise
- Canada - A/T - Reman A/T Serial Number Location
- Canada - Interior - Water Condensation Dripping From Headliner
- Canada - Instruments - Overhead Compass And Tempature Display
- Canada - Restraints - Seat Belt Tongue Plate Stopper Replacemen
- Canada - Interior - front Seat Squeak Noise
- Canada - A/T - A/T Serial Number Location
- Canada - Suspension - Rear Spring Harsh Ride
- Canada - A/T - Installation Precautions
- Canada - Body - Front Fender Liner Pin Hold Clip
- Canada - Drivetrain - Driveline Vibration Between 24-40 KM/H
- Canada - A/C - A/C Condensor Line Bolts
- Canada - Alignment - Zero Point Calibration On VSC
- Canada - Interior - Seat Back Upholstery Wire
- Fuel System - Accelerator Pedal Sensor Service Precaution
- Canada - M/T - Clutch Pedal Feel Improvement
- Canada - Interior - Various Interior Trim Panels Loose
- Canada - Interior - Front Seat Squeaking Noises
- Canada - A/C - Blower Motor Noise At Low Temperature
- Canada - Fuel System - Undercab Knocking Noises
- Canada - Audio System - Quick Reference Guide
- Canada - Engine Controls - MIL ON/DTC P0102 Set
- Canada - Body - Rear Side Panel Skirts Loose
- Canada - Body - Front End Rattle/Squeak On Rough Roads
- Canada - Engine - 0W20 and 5W20 Engine Oil Introduction
- Canada - Body - Front/Rear Window Runs Are Deformed
- Canada - Audio System - CD Skip Verification Procedure
- Canada - Engine Controls - MIL ON/Multiple O2 Sensor DTC's Set
- Canada - Tire Monitor System - Activation Procedure
- Canada - A/C - Blower Motor Ticking/Clicking/Squealing Noises
- Canada - Tire Monitor System - Tire Dismounting Precautions
- Canada - Wipers/Washers - Wiper Blade Maintenance
- Canada - Body - Accessory Skid Plate Vibration
- Canada - Restraints - Seat Cover Replacement On Side Air Bag
- Canada - Suspension - Shock Absorber Replacement Criteria
- Canada - Compuetrs/Controls - CAN Module Fails to Initialize
- Canada - A/C - Blower Motor Only Operates On High
- Canada - Electrical - Interior Electrical Component Precautions
- Canada - Suspension - Rear End Squeaking Noise On Bumps
- Canada - M/T - Clutch Slipping In Forward Gears And Reverse
- Canada - Cooling System - Water Pump Leak Inspection/Diagnostic
- Canada - A/C - Sensor Inspection Procedures
- Canada - A/T - Torque Converter Bolt Installation Precautions
- Canada - Engine Controls - VIN Entering During PCM Replacement
- Canada - Instruments - Compass Calibration Procedure
- A/C/Interior - Water Leak From Cowl Area
- Canada - Engine Controls - AF Sensor Identification
- Canada - A/T - World Standard Automatic Transmission Fluid
- Recall 12V092000: Air Bag Clockspring Replacement
- Steering - Rattling Noises On Rough Roads
- Body - Welding Specifications & Substitutions
- Body - Squeak Or Rattle From Rear Of Vehicle
- A/C - Blower Motor Ticking/Clicking/Squealing Noises
- Body - Collision Repair Information
- A/C - Blower Motor Only Operates On High
- Suspension - Shock Absorber Replacement Criteria
- Lighting - DRL/Turn Signal Lens Bubbled/Distorted
- Restraints - Seat Cover Replacement On Side Air Bag Veh.
- Cooling System - Water Pump Leak Inspection/Diagnostics
- Suspension - Rear End Squeaking Noise On Bumps
- M/T - Rattling Noise In Neutral
- Electrical - Interior Electrical Component Precautions
- A/T - Replacement Precautions
- M/T - Clutch Slipping In Forward Gears And Reverse
- A/T - Park/Neutral Switch Installation
- A/T - Torque Converter Bolt Installation Precautions
- A/T - World Standard Automatic Transmission Fluid
- Suspension - Harsh Ride - Rear Suspension
- Vehicle - Usage Of Non-OE Parts
- Vehicle - VIN Plate/Certification Label Replacement
- Vehicle - Certification Label Information
- Vehicle - Replacement VIN Plate Information
- Tire Monitor System - Tire Dismounting Precautions
- Recall 06V061000: Tire Inspection/Replacement
- Body - Front End Rattle/Squeak on Bumps
- Engine Controls - Entering VIN When Replacing PCM/ECM
- Engine Controls - MIL ON/DTC P0102 Set
- Fuel System - Under Cab Knocking Noise On Cold Start Up
- Emissions - MIL ON/DTC's P043E/P043F/P2401/P2402/P2419
- Instruments - Compass Calibration Procedure
- Recall 06V096000: Various Air Bag Defects
- Engine - ILSAC GF-4 Engine Oil Standard
- Engine Lubrication - ILSAC GF-4 Oil Recommendations
- Audio System - CD Player Skip Verification
- Recall - 05V482000: Tire Label Non-Compliance
- Body - Interior Trim Panels/Garnish Loose
- Paint - Paint Stains Under Rapgard
- Body - Front/Rear Window Runs Deformed
- SRS/Interior - Seat Cover Replacement Caution
- Tire Pressure Monitor - Sensing Transmitter Activation
- M/T - Grinding/Hard to Engage 4WD Low
- Fuel System - Fuel Injector Cleaning Procedure
- Electrical - Battery Maintenance and Testing
- Interior - Driver's Side Lower Dash Panel Poor Fit
- Body - Replacement Bumper Cover Refinishing
- Drivetrain - Drive/Axle Shaft Replacement Precautions
- Air Bag Systems - Repair Manual Supplement
- A/T - Identification/Serial Number Location
- Audio System - Quick Reference Diagnostic Guide
- Restraints - Seat Belt Extenders
- Engine Controls - Bank 1/Bank 2 O2 Sensor identification
- Engine - Crankshaft Oil Seal Leak
- Body - Paintless Dent Repair Information
- Brakes - Front Brake Noise When Applied Backing Up
- Battery - Absorbed Glass Mat Battery (AGM) Information
- Restraints - SRS Component Disposal
- Wheels/Tires - Spare Tire Carrier Operation Information
- Body - Windshield Wind Noise at Highway Speeds
- Lighting - Rear License Plate Lamp Dislodged
- Keyless Entry - Programming Remote Transmitters
- Keyless Entry - Remote Transmitter Programming Guide
- Body - Truck Bed Tailgate is Bent
- Body - Wind Noise Between Front and Rear Doors
- Engine - Cylinder Head Cover Baffle Precautions
- A/C - Condenser Line Bolt Installation
- Drivetrain - Rear Differential Whine/Howl At 50-70 MPH
- ABS/TCS - Zero Point Calibration Information
- A/T, M/T - Alignment Pin Service Precaution
- Interior - Wires Felt Through Seat Back Upholstery
- Body - Front Fender Liner Pin Hold Clip Procedure
- Restraints - Seat Belt Tongue Plate Stopper Replacement
- Body/Frame - Protective Wax Coating Information
- A/T - Fluid Level Inspection/Temperature Ranges
- Steering/Suspension - Vehicle Pull Repair Supplement
- Engine, A/T Controls - Torque Converter Lock Up Shudder
- Body/Frame - Sectioning Information
- Body - Panel Adhesive Information
- Body - Collision Damage Repair Precautions
- Body - Acid Rain Paint Damage Prevention/Repair
- Body/Interior - Trim Removal And Installation
- Restraints - SRS Service Precautions
- Interior - Glove Box Falls Open After Filter Replace
- A/T - A340E Solenoid Identification
- Body - Sheet Molded Compound Pick Up Bed Repair
- Tire Monitor System - 'Lost Communication With ECU' Mssg
- Body - Plastic Bumper Refinishing
- Body - Bumper Component Repair
- Instruments - Compass/Temperature Display Inoperative
- Paint - Refinishing Information
- Recall - Side Air Bag Replacement
- Campaign - Supplemental Child Restraint Information
- Dealer Letter
- Owner Letter - For Installation of a Child Restraint System
- CRS Label Installation Instructions
- Owner Letter - For Correction to the Tire and Loading Information Label
- Updated Tire and Loading Information Label Installation Instructions
- Questions and Answers
- Technical Instructions
- I. Operation Flow Chart
- II. Identification of Affected Vehicles
- III. Preparation
- IV. Background
- V. Components
- VI. Work Procedure
- Interior - Squeaking Noises From The Front Seat
- Engine - Serial Number Locations/Identification
- Suspension - Rear Suspension Squeaking Noises
- Recall 09V388000: Floor Mat/Accelerator Interference
- Electrical - SRS And HV Wiring Repairs
- A/T - Serial Number Identification/Locations
- A/T - Reman A/T Serial Number Identification/Locations
- A/T Controls - MIL ON/DTC P0705 Set
- Vehicle - Long Term Storage Guidelines
- Suspension - Harsh Rear Suspension Ride With Heavy Load
- Tires - Pressure Compensation And Adjustment
- Engine Controls - A/F And O2 Sensor Identification
- Recall - Floor Mat/Accelerator Pedal Interferance
- Audio System - Distorted Sound From The Sub-Woofer
- Interior - Floor Carpet Grommet Serviceability
- Interior - Rattle Noise From Glove Box Area
- Steering - Rattling Noise On Rough Roads
- Body - Water Leaks Onto Rear Carpet Area
- Body - Windshield/Back Glass Ticking Noise
- Interior - Dash Rattles/Ticks Below Glove Box
- Body - Corrosion Prevention And Sound Absorption Info.
- Body - HSS/UHSS Cabin Reinforcement Repair/Replacement
- Body - Approved Collision Repair Methods
- Restraints - OCS System Initialization
- Canada - Steering/Suspension - Vehicle Pull Repair Supplement
- Canada - Drivetrain - Drive/Axle Shaft Replacement Precautions
- Canada - Brakes - Front Brake Noise When Applied Backing Up
- Canada - Engine - Cylinder Head Cover Baffle Precautions
- Canada - Drivetrain - Rear Differential Whine/Howl At 50-70 MPH
- Canada - Engine Controls - ECU Flash Reprogramming Process
- Canada - Engine, A/T Controls - Torque Converter Lock Up Shudde
- Canada - Engine Controls - Techstream(R) ECU Re-Flash Procedure
- Canada - Battery - Absorbed Glass Mat Battery (AGM) Information
- Canada - Restraints - Seat Belt Tongue Plate Stopper Replacemen
- Canada - Restraints - SRS Service Tips
- Canada - Engine - Crankshaft Oil Seal Leak
- Canada - Keyless Entry - Scantool Immobilizer Key Code Utility
- Canada - Keyless Entry - Immobilizer Key Code Reset
- Canada - Body - Water Leaks Onto Rear Carpet Area
- Canada - Body - Windshield Wind Noise at Highway Speeds
- Canada - Lighting - Rear License Plate Lamp Dislodged
- Canada - A/T Controls - MIL ON/DTC P0705 Set
- Canada - Audio System - Distorted Sound From The Sub-Woofer
- Canada - Interior - Rattle Noise From Glove Box Area
- Canada - Interior - Dash Rattles/Ticks Below Glove Box
- Canada - Interior - Glove Box Falls Open After Filter Replace
- Canada - A/T - A340E Solenoid Identification
- Canada - Trailer Harness - Updated Design/Diagnostics
- Canada - Keyless Entry - Diagnostic Tester Immobilizer Function
- Canada - Interior - Driver's Side Lower Dash Panel Poor Fit
- Canada - Interior - Floor Carpet Grommet Serviceability
- Canada - Tire Monitor System - Lost Communication With ECU Mssg
- Canada - Keyless Entry - Programming Remote Transmitters
- Canada - Wheels/Tires - Spare Tire Carrier Operation Informatio
- Canada - Body - Truck Bed Tailgate is Bent
- Canada - Tires - Tire Pressure Warning System Diagnostic Tips
- Canada - Body - Wind Noise Between Front and Rear Doors
- Drivetrain - Rear Driveshaft Clunk/Thunk Noise
- Canada - M/T - Clutch Pedal Squeak/Creak When Operated
- Drivetrain - Driveline Vibration Between 15 - 25 MPH
- Computers/Controls - Techstream(R) Reprogramming Procedure
- Body/Frame - Body Sectioning Information
- Emissions - CA/FED Emissions Underhood Label Ordering