Repair and Diagnosis
- A L L Diagnostic Trouble Codes ( DTC )
- Relays and Modules
- Sensors and Switches
- Sensors and Switches - Cooling System
- Sensors and Switches - Cruise Control
- Sensors and Switches - HVAC
- Sensors and Switches - Lighting and Horns
- Sensors and Switches - Powertrain Management
- Sensors and Switches - Starting and Charging
- Sensors and Switches - Transmission and Drivetrain
- Maintenance
- Engine, Cooling and Exhaust
- Engine
- Cooling System
- Exhaust System
Technical Service Bulletins
- Powertrain Management
- Relays and Modules - Powertrain Management
- Sensors and Switches - Powertrain Management
- Tune-up and Engine Performance Checks
- Computers and Control Systems
- Data Link Connector
- Engine Control Module
- Engine Speed Sensor
- Malfunction Indicator Lamp
- Oxygen Sensor
- Relays and Modules - Computers and Control Systems
- Sensors and Switches - Computers and Control Systems
- Throttle Position Sensor
- Transmission Position Sensor/Switch
- Vehicle Speed Sensor
- Technical Service Bulletins
- Emission Control Systems
- Fuel Delivery and Air Induction
- Ignition System
- Transmission Control Systems
- Technical Service Bulletins
- Transmission and Drivetrain
- Actuators and Solenoids - Transmission and Drivetrain
- Automatic Transmission/Transaxle
- Actuators and Solenoids - A/T
- Control Module
- Drain Plug
- Fill Plug
- Fluid - A/T
- Relays and Modules - A/T
- Sensors and Switches - A/T
- Shift Interlock
- Transmission Position Sensor/Switch
Testing and Inspection- Initial Inspection and Diagnostic Overview
- Reading and Clearing Diagnostic Trouble Codes
- Clearing Trouble Codes - 4 Speed Automatic 01P
- Clearing Trouble Codes - 4 Speed Automatic 098
- Description Of On-Board Diagnostics - 4 Speed Automatic 01P
- Description Of On-Board Diagnostics - 4 Speed Automatic 098
- Displaying and Reading Trouble Codes - 4 Speed Automatic 01P
- Displaying and Reading Trouble Codes - 4 Speed Automatic 098
- Component Tests and General Diagnostics
- Scan Tool Testing and Procedures
- Scan Tool Testing - 4 Speed Automatic 01P
- Scan Tool Testing - 4 Speed Automatic 098
Locations
Service and Repair
Specifications- Technical Service Bulletins
- Clutch
- Differential Assembly
- Drive Axles, Bearings and Joints
- Manual Transmission/Transaxle
- Relays and Modules - Transmission and Drivetrain
- Sensors and Switches - Transmission and Drivetrain
- Transmission Control Systems
Service Precautions- Technical Service Bulletins
Tools and Equipment- VW/Audi ATF Adapter - AST Tool # ATF 103
- VW/Audi Drive Line Filler - AST Tool # ATF 1033 VW
- VW/Audi Drive Line Filler - AST Tool # ATF 1033-5 VW
- VW/Audi ATF Adapter - AST Tool # ATF 104
- VW/Audi ATF Adapter - AST Tool # ATF 105
- DSG ATF Adapter - AST Tool # ATF 16 DSG
- VW/Audi "CVT" ATF Adapter - AST Tool # ATF 17 CVT
- Brakes and Traction Control
- Starting and Charging
- Power and Ground Distribution
- Steering and Suspension
- Heating and Air Conditioning
- Air Door
- Air Duct
- Air Register
- Blower Motor
- Blower Motor Resistor
- Blower Motor Switch
- Cabin Air Filter / Purifier
- Compressor HVAC
- Condenser HVAC
- Control Assembly
- Control Module HVAC
- Coolant Temperature Sensor / Switch HVAC
- Coupler HVAC
- Evaporator Case
- Evaporator Core
- Evaporator Drain Tube
- Evaporator Temperature Sensor / Switch
- Expansion Valve
- Heater Control Valve
- Heater Core
- Heater Core Case
- Heater Core Temperature Sensor / Switch
- High Pressure Safety Valve HVAC
- Hose/Line HVAC
- Receiver Dryer
- Refrigerant
- Refrigerant Oil
- Refrigerant Pressure Sensor / Switch
- Relays and Modules - HVAC
- Sensors and Switches - HVAC
- Service Port HVAC
- Sight Glass
- Service Precautions
Description and Operation- Testing and Inspection
- A/C Cooling Performance
- A/C Refrigerant System
- A/C System Cooling Performance, Checking
- Auxiliary Heater B2L, Troubleshooting
- Tool Requirements
- Don't Come on/No Sound Within 5 Seconds After Being Switched on
- Heater Shuts Off After Approx. 10 Seconds
- Heater Shuts Off After 3 Minutes, Fuel Pump Clicks
- Heater Shuts Off After 3 Minutes, Fuel Pump Does Not Click
- Heater Malfunction Light Flashes, Heater Emits Soot or Smoke
- Run-on Cycle Exceeds 4 Minutes After Heater Is Switched Off
- Don't Run-on After Switched Off & Ventilation Function Is Inop.
- Heater Does Not Reduce Output
- Heater Output Inadequate or Heater Always Running At Low Output
- Don't Cycle Combustion Don't Resume Lower Temp. Is Selected
- Locations
- Service and Repair
- Auxiliary Heater B2L
- Auxiliary Heater B2L (Gasoline), Servicing (Canada Only)
- Auxiliary Heater B2L, Assembly
- Exhaust Pipe, Removing and Installing
- Fuel Flow Rate, Checking
- Glow Plug Thermoswitch & Temp. Limiting Switch, Replacing
- Ignition Coil -N152-, Junction Box -T-, Removing and Installing
- Transfer Fuel Pump -G23- Assembly
- Transfer Fuel Pump -G23-, Installed Position
- A/C Components, Servicing
- Heating and Ventilation System
- Auxiliary Heater B2L
Diagrams- Specifications
- Technical Service Bulletins
- Restraints and Safety Systems
- Repairs and Inspections Required After a Collision
- Air Bag Systems
- Air Bag(s) Arming and Disarming
- Air Bag
- Air Bag Control Module
- Clockspring Assembly / Spiral Cable
- Side Air Bag
- Service Precautions
- Testing and Inspection
- Service and Repair
- Technical Service Bulletins
- Tools and Equipment
- Knee Diverter
- Relays and Modules - Restraints and Safety Systems
- Seat Belt Systems
- Technical Service Bulletins
- Accessories and Optional Equipment
- Body and Frame
- Air Bag(s) Arming and Disarming
- Repairs and Inspections Required After a Collision
- Bumper
- Doors, Hood and Trunk
- Fender
- Grille
- Interior Moulding / Trim
- Locks
- Mirrors
- Paint, Striping and Decals
- Radiator Support
- Roof and Associated Components
- Sunroof / Moonroof
- Sun Shade
- Sunroof / Moonroof Motor
- Sunroof / Moonroof Drain
- Sunroof / Moonroof Frame
- Sunroof / Moonroof Panel
Adjustments- Locations
- Service and Repair
- Sunroof / Moonroof
- Seats
- Seat Temperature Element
- Service and Repair
- Front Seats
- Center Seats
- Single Seat
- Passenger Seats
- Eurovan CV Camper
- Driver's/Front Passenger Seat, Removing
- Bench Seat Rear, Removing and Installing (Eurovan CV Camper)
- Seat Cushion, Removing
- Backrest Cushion, Removing
- Bench Hardware, Removing
- Bench Seat Front Trim, Removing
- Bench Seat Side Trim, Removing
- Bench Seat Release Cable, Adjusting/Removing
- Bench Seat Sliding Blocks, Replacing
- Rear Seats
- Multivan
- Sound Proofing / Insulation
- Splash Guard
- Strut / Shock Tower
- Truck Bed
- Service Precautions
- Service and Repair
- Electrical Equipment, Removing (Eurovan CV Camper)
- Electrical Equipment, Removing (Multivan)
- Water Supply/Drain, Removing and Installing (Eurovan CV Camper)
- Propane Gas Tank, Removing and Installing
- Propane Gas Stove With Sink, Removing and Installing
- Cupboards And Storage Compartments, Removing and Installing (Eurovan CV Camper)
- Cruise Control
- Instrument Panel, Gauges and Warning Indicators
- Lighting and Horns
- Windows and Glass
- Wiper and Washer Systems
- Application and ID
- Diagrams
- Specifications
- Technical Service Bulletins
Diagnostic Trouble Codes