Powertrain Management: Technical Service Bulletins

• Recalls
  • Generals
    • Campaign - Fuel Tank Replacement
  • Safety
    • Recall 01V196000: A/T Switch Circuit Defect
    • Recall - A/T Selector Position Switch Replacement
      • Overview
      • Owner Letter
• Customer Interest
  • Fuel System - Fuel Cap Tether Is Broken Or Lost
  • Emissions - MIL ON/Codes 81 and 81 in DME Memory
    • Overview
    • Repair Procedure
  • Engine Controls - Intermittent No Start Condition
  • Fuel Level Sensor - Incorrect Gauge Readings
  • Engine - MIL ON/Codes Set/Tapping/Rattling Noise
  • Engine Controls - MIL ON/Crank But No Start/FC164 Stored
  • ABS/DCS - Warning Lamp ON/Code 30 or 31 Set
  • Fuel System - MIL ON, Tank Leakage Fault Codes
  • Fuel System - Accelerator Pedal Feels 'Notchy'
  • A/T - MIL ON/Fault Code 34 Stored in Memory
  • A/T Selector Switch - Shift Concerns/Engine No Start
  • A/T - Erratic Shifting/Trans Light ON/FC 60 Set
  • A/T - Shifter LED Stays Illuminated
  • Fuel System - Damage Caused By Fuel Contaminants
  • SRS - Air Bag Lamp ON/OC3 Mat Fault Code Set
  • SRS - Air Bag Lamp ON/Multiple Fault Codes Set
    • Overview
    • Attachments
      • E36
      • E38 and E39
      • E46
      • E53
      • Z3
  • Battery - Discharges With Key Left In Ignition Switch
  • Engine - Blue Smoke/Misfire/Oil Loss In Extreme Cold
• By Symptom
  • Abnormal wear/deterioration
    • Emissions - MIL ON/Codes 81 and 81 in DME Memory
      • Overview
      • Repair Procedure
    • Fuel System - Damage Caused By Fuel Contaminants
    • Engine - Blue Smoke/Misfire/Oil Loss In Extreme Cold
  • Customer Interest
    • Fuel System - Fuel Cap Tether Is Broken Or Lost
    • Emissions - MIL ON/Codes 81 and 81 in DME Memory
      • Overview
      • Repair Procedure
    • Engine Controls - Intermittent No Start Condition
    • Fuel Level Sensor - Incorrect Gauge Readings
    • Engine - MIL ON/Codes Set/Tapping/Rattling Noise
    • Engine Controls - MIL ON/Crank But No Start/FC164 Stored
    • ABS/DCS - Warning Lamp ON/Code 30 or 31 Set
    • Fuel System - MIL ON, Tank Leakage Fault Codes
    • Fuel System - Accelerator Pedal Feels 'Notchy'
    • A/T - MIL ON/Fault Code 34 Stored in Memory
    • A/T Selector Switch - Shift Concerns/Engine No Start
    • A/T - Erratic Shifting/Trans Light ON/FC 60 Set
    • A/T - Shifter LED Stays Illuminated
    • Fuel System - Damage Caused By Fuel Contaminants
    • SRS - Air Bag Lamp ON/OC3 Mat Fault Code Set
    • SRS - Air Bag Lamp ON/Multiple Fault Codes Set
      • Overview
      • Attachments
        • E36
        • E38 and E39
        • E46
        • E53
        • Z3
    • Battery - Discharges With Key Left In Ignition Switch
    • Engine - Blue Smoke/Misfire/Oil Loss In Extreme Cold
  • Driveability
    • Engine Controls - MIL ON/Crank But No Start/FC164 Stored
    • Engine - Blue Smoke/Misfire/Oil Loss In Extreme Cold
  • Erratic Operation
    • A/T Selector Switch - Shift Concerns/Engine No Start
  • Erratic Shifting
    • A/T - Erratic Shifting/Trans Light ON/FC 60 Set
  • False instrument warning light/gauges
    • Fuel Level Sensor - Incorrect Gauge Readings
  • Hard Shifting
    • A/T - Erratic Shifting/Trans Light ON/FC 60 Set
  • Leaks
    • Fuel System - Evaporative System Vacuum Leak Diagnosis
    • Engine - Blue Smoke/Misfire/Oil Loss In Extreme Cold
  • Low, Dead battery
    • Battery - Discharges With Key Left In Ignition Switch
  • No shift/Incorrect gear engagement
    • A/T - MIL ON/Fault Code 34 Stored in Memory
    • A/T Selector Switch - Shift Concerns/Engine No Start
  • Noise
    • Engine - MIL ON/Codes Set/Tapping/Rattling Noise
  • Poor performance
    • Recall - A/T Selector Position Switch Replacement
      • Overview
      • Owner Letter
  • Recalls
    • Campaign - Fuel Tank Replacement
    • Recall 01V196000: A/T Switch Circuit Defect
    • Recall - A/T Selector Position Switch Replacement
      • Overview
      • Owner Letter
  • Smoke, Fumes
    • Engine - Blue Smoke/Misfire/Oil Loss In Extreme Cold
  • Starting problems
    • Engine Controls - Intermittent No Start Condition
    • Engine Controls - MIL ON/Crank But No Start/FC164 Stored
  • Sticking/Binding
    • Fuel System - Accelerator Pedal Feels 'Notchy'
• All Technical Service Bulletins
  • Emissions - Pressure Cont. Crankcase Ventilation Info.
  • Computer/Controls - Replacement DME Programming
  • Fuel System - Evaporative System Vacuum Leak Diagnosis
  • Computers, Controls - Programming VS Veh. Data Status
  • Fuel System - Fuel Tank Lock Ring Torque Spec Missing
  • Emissions System - Evaporative System Leak Testing
  • Compuetrs/Controls - Recommended Diagnostic Procedures
  • Fuel System - Alcohol Fuel Blend Usage
  • Fuel System - High Alcohol Fuel Detection
  • Fuel System - Fuel Cap Tether Is Broken Or Lost
  • Emissions - MIL ON, Multiple DTC's Stored
  • Progman(R) - Programming/Coding/Individualization
    • Overview
    • General_Rules_For_Programming
    • Procedure_A_Module_Replacement
    • Procedure_B_Software_Update
    • Procedure_C_Troubleshooting
      • Index
      • Introduction
      • Section I: Preparing A Progman Session
      • Section II: Progman Session Initialization
      • Section III: Before Programming/Coding
      • Section IV: After Programming Coding
      • Illustrations and Table
    • Procedure_E_Coding
  • Emissions - MIL ON/Codes 81 and 81 in DME Memory
    • Overview
    • Repair Procedure
  • Engine Controls - Updated DISplus/GT1 Software
  • Computers/Controls - 'Retrofit' Update Programming
  • Engine Controls - Various Driveability Complaints
  • Engine Controls - Intermittent No Start Condition
  • Engine Controls - Progman(R) V22.1/V22.1.1 and V22.1.2
  • Engine Controls - False Maintenance Interval in Progman
  • Engine Controls - Progman(R) V21.0 Software Errors
  • Fuel Level Sensor - Incorrect Gauge Readings
  • Spark Plug (HP Platinum) - Application Chart
  • Engine - MIL ON/Codes Set/Tapping/Rattling Noise
  • Engine Control Module - MS 43 Removal Precautions
  • Engine Controls - MIL ON/Crank But No Start/FC164 Stored
  • ABS/DCS - Warning Lamp ON/Code 30 or 31 Set
  • Campaign - Fuel Tank Replacement
  • Fuel System - MIL ON, Tank Leakage Fault Codes
  • Fuel System - Accelerator Pedal Feels 'Notchy'
  • Check Engine Lamp ON/DTC's Stored
  • Fuel Level Sensor - Installation Tips
  • Engine Controls/Emissions - OBD Readiness Code Setting
  • Emissions - Evaporative Emission Fault Diagnostics
  • Recall 01V196000: A/T Switch Circuit Defect
  • A/T - MIL ON/Fault Code 34 Stored in Memory
  • A/T Selector Switch - Shift Concerns/Engine No Start
  • Recall - A/T Selector Position Switch Replacement
    • Overview
    • Owner Letter
  • A/T - Erratic Shifting/Trans Light ON/FC 60 Set
  • A/T - Shifter LED Stays Illuminated
  • Fuel System - Damage Caused By Fuel Contaminants
  • Ignition System - Platinum Spark Plug Application Chart
  • Engine Controls - Progman(R) V21.01 and V21.02.01 Errors
  • Computers/Controls - Progman(R) V22.0/V22.0.1 Errors
  • SRS - Air Bag Lamp ON/OC3 Mat Fault Code Set
  • SRS - Air Bag Lamp ON/Multiple Fault Codes Set
    • Overview
    • Attachments
      • E36
      • E38 and E39
      • E46
      • E53
      • Z3
  • Battery - Discharges With Key Left In Ignition Switch
  • Electrical - Oil Level Sensor Diagnostic Hints
  • Engine - Blue Smoke/Misfire/Oil Loss In Extreme Cold
  • Fuel System - TOP TIER Gasoline Usage Recommendations
  • Fuel System - Fuel Quality and Additive Information
  • Emissions - Evaporative Emissions System Testing
  • Computers/Controls - ISTA/D DTC S0001 After Quick Delete
  • Computers/Controls - ISTA Test Plan Priority Error Info.
  • Computers/Control - Loading/Activation Of Enabling Codes
  • Fuel System - BMW Group Fuel System Cleaner Plus Info.