Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Generals
- Safety
- Customer Interest
- Vehicle - Pull Or Drift Diagnostics/Service Procedures
- Overview
- Service Procedure
- Pull/Drift Diagnostic Procedure
- Road Test
- Diagnostic Procedure # 1 - Tire Mismatch
- Diagnostic Procedure # 2 - Alignment
- Diagnostic Procedure # 3 - Tires
- Diagnostic Procedure # 4 - Steering Gear Valve Off Center
- Diagnostic Procedure # 5 - RBS Linkage
- Diagnostic Procedure # 6 - Brake Imbalance
- Diagnostic Procedure # 7 - Miscellaneous
- Diagnostic Check List
- A/C - Musty Odor Coming From Vents
- Power Steering System - Noisy
- Steering/Suspension - Pull/Drift Diagnostic Procedure
- Overview
- Service Procedure
- Pull Drift Diagnostic Procedure
- The Road Test
- Diagnostic Procedure # 1 - Tire Mismatch
- Diagnostic Procedure # 2 - Alignment
- Diagnostic Procedure # 3 - Tires
- Diagnostic Procedure # 4 - Steering Gear Valve Off Center
- Diagnostic Procedure # 5 - Rbs Linkage
- Diagnostic Procedure # 6 - Brake Imbalance
- Diagnostic Procedure # 7 - Miscellaneous
- Diagnostic Check List
- Fuel Pump - Buzzing/Humming After Engine Shut Down
- Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Front Brakes - Popping or Clunking Noise
- Engine - Stalls/Hesitates/Long Cranking Times
- A/C Compressor - Noise/Vibration
- Steering Gear - Leak At the Input Shaft
- Timing Belt - Warbling Noise
- Engine - Oil Pan Gasket Leaks
- Heater - Air Flow From Panel During Heavy Acceleration
- Frame/Crossmember - Snapping/Popping Noise
- Driveshaft - Boom/Vibration At 20-65 MPH
- Rear Suspension - Low Ride Height When Loaded
- Driveline - Vibration/Shudder During Acceleration
- Door Lock Cylinder - Loose in Replacement Door
- Driveline - Vibration Between At 25 And 50 MPH
- A/T, Driveline - Leaks/Vibration
- Driveline - Vibration/Boom
- Clutch Disc - Scraping/Rattling/Clicking/Popping
- Front Hub - (4WD) Noise or Failure
- M/T Clutch Housing - Fluid Inside
- M/T Clutch - Growling/Clicking Noise
- MIL ON/Code 41 Displayed
- Engine - Hard Start/Knock/Stall/Rough Idle
- Engine - Lean Driveability Symptoms
- Rear Brakes - Grab/Stick On First Few Applications
- Brakes - Sticking/Binding/Grabbing
- Battery - No Engine Crank/Low Battery Charge
- Alternator - Discharge
- Instrument Cluster Warning Lights - Dimly Lit
- Speed Control - Intermittent or Inoperative
- Radio - AM Band Noise With Speed Control ON
- Radio - Poor AM Reception
- Electric Rear Window Defroster - Inoperative
- Safety Belts - Front/Rear Twisted at `D' Ring
- Speedometer - Indicates High Speed When Cold
- A/C Compressor Shaft Seal - Leaks
- Brakes - False or Dropping Pedal
- Differential - Chatter On Turns
- Steering Column - Rattles
- Liftgate Trim Panel - Cracking
- Front Seat Center Armrest - Loose/Wobbles
- A/T - Shift Selector Indicates Incorrect Gear
- Exterior Clearcoat - Cracking/Eroding/Peeling Off
- A/C System - Chemical/Refrigerator Type Odor
- Heater - Lack of Heat to the Floor Area
- A/T - A4LD Harsh 2nd - 3rd Gear Backout Upshift
- Radio - Poor AM Reception/Fading/Engine Noise
- M/T - M50D Hard Shift Condition
- M/T - Crunching Shifting From 2nd to 3rd Gear
- Engine - Rough Idle/Hesitation/Backfire/Stalling
- Passenger Seat Back - Rattles When Unoccupied
- A/T - Torque Converter Slip/DTC 628/P0741 Set
- Vehicle - Pull Or Drift Diagnostics/Service Procedures
- Labor/Parts Updates
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- 9174 - 04/05/91
- 9138 - 02/02/91
- 911510 - 07/24/91
- 91118 - 05/30/91
- 91109 - 05/15/91
- 90819 - 04/11/90
- 90158 - 07/19/90
- 90148 - 07/05/90
- 90137 - 06/20/90
- 90128 - 06/07/90
- 90119 - 05/23/90
- 90107 - 05/09/90
- 89311 - 02/08/89
- 89252 - 12/13/89
- 89165 - 08/09/89
- 891012 - 05/17/89
- 88246 - 11/23/88
- 88245 - 11/23/88
- 881710 - 08/17/88
- 87812 - 04/24/87
- 87716 - 04/08/87
- 872013 - 10/07/87
- 83426 - 02/22/83
- 831915 - 09/20/83
- Speed Control - Intermittent Operation or Inoperative
- Frame Rivets - Damaged/Loose
- Running Boards - Installation Precautions
- A/C - Identification Of Non Approved Refrigerants
- A/C - R134A Retrofit Kit Availability
- A/C - R12 to R134a Retrofit Kit Availability
- A/C - Approved Flushing Procedures
- Air Conditioning - Musty or Mildew Type Odors
- A/C System - Musty/Mildew Odors
- A/C - O Ring Removal From Spring Lock Coupling
- Heater Panel Registers - Air Flow In the OFF Mode
- Frame - Rivet Replacement With Bolts, Service Tip
- Frame - Damaged or Loose Rivets
- Frame Crossmember - Snapping/Popping Sounds
- Power Steering Gear - Leak Fluid At the Input Shaft
- Power Steering Pump - Noise
- Power Steering Pump - Noisy
- Power Steering Pump - Noises
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Wire Harness - Terminal Repair And Wire Splice Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Repair
- Wire Harness - Terminal Repair Kit/Splice Procedure
- Electrical - Wiring Harness Terminal Repair Kit
- Wire Harness - Terminal Repair Kits
- Wire Harness Terminal and Connector - Repair Kit
- Wire Harness - New Terminal Repair Kit
- Radio - Whining/Buzzing Noise
- Rear Brakes - Grabbing/Sticking
- Rear Brakes - Grab/Squeal When Cold
- Brakes - Special Lubricant Requirements
- Brake Rotor - Machining With On-Vehicle Equipment
- Front Brakes - Stick/Bind/Grab
- Driveline - Pinging/Creaking When Vehicle Put In Gear
- Driveline - Pinging/Creaking
- Driveline - Ping/Creak When Engaging Transmission
- Driveline - Boom/Vibration At 20 - 65 MPH
- Driveshaft - Boom/Vibration At 20-55 MPH
- Driveline - Vibration or Shudder On Acceleration
- M/T Clutch - Growl/Vibration
- Clutch Disc - Scraping/Rattling/Clicking/Popping
- A/T - New Transmission Cooler Flusher/Service Tip
- A/T - A4LD Shift Position Indicator Misalignment
- Fuel Economy - Customer Expectations Vs. Vehicle Usage
- Fuel Economy - Expectations Versus Usage
- Speaker - Whining/Buzzing Noise
- Speakers - Whining/Buzzing Noise
- Fuel Pump - Buzz/Whine Through Radio Speakers
- Fuel Pump - Whine/Buzz Noise Heard In Speakers
- Radio - Whine/Buzz
- Radio - Buzzing/Whining Noise
- Exhaust System - Buzz or Rattle Noise
- Exhaust System - Buzzing/Rattling Noises
- Exhaust System - Rattling/Buzzing Noise
- Exhaust System - Buzz/Rattle Noise
- Heater Core - Repeated Failure
- Cooling System - Diagnosis Procedure
- Engine Oil Pan Gasket - Oil Leaks
- Engine Oil Pan - Removal/Installation Procedure
- Engine - Hesitation/Stall/Rough Idle
- A/T - Fluid Application Charts
- A/C System - New A/C Filter Kit
- A/C - New Filter to Prevent Compressor Damage
- A/C System - New Filter Kit
- Air Conditioning - Prevent Damage to Compressor
- A/C - Refrigerant Filtering Tips
- A/C - Refrigerant Filtering Service Tips
- A/C System - Refrigerant Filtering Service Tips
- Brake/Steering - Pull/Drift Diagnostic Procedure
- Wheels - Proper Lug Torque Procedures
- Brakes - Vibration Prevention Service tip
- Propylene Glycol Coolant - Recommendations
- Recycled Engine Coolant - Service Tip
- A/T - Transmission Fluid Usage Charts
- Automatic Transmission - Fluid Usage Charts
- A/C - Filter Kit Installation After Replacing Compressor
- A/C Compressor Replacement - Refrigerant Filtering
- A/C System - Use of R12 Refrigerant Substitutes
- Air Conditioning - Filtering Refrigerant
- A/C - Non Approved Refrigerants
- A/C - Approved/Alternate Refrigerants
- A/C - Identification of Non-Approved Refrigerants
- A/C - Identifying Non-Approved Refrigerants
- Vehicle - Towing Guidelines
- Engine - Hesitation/Rough Idle/Stall
- All Technical Service Bulletins
- Ford RTV Sealer - Shelf Life
- Vehicle - Towing Behind RVs Guidelines
- Vehicle - Pull Or Drift Diagnostics/Service Procedures
- Overview
- Service Procedure
- Pull/Drift Diagnostic Procedure
- Road Test
- Diagnostic Procedure # 1 - Tire Mismatch
- Diagnostic Procedure # 2 - Alignment
- Diagnostic Procedure # 3 - Tires
- Diagnostic Procedure # 4 - Steering Gear Valve Off Center
- Diagnostic Procedure # 5 - RBS Linkage
- Diagnostic Procedure # 6 - Brake Imbalance
- Diagnostic Procedure # 7 - Miscellaneous
- Diagnostic Check List
- A/C - Musty Odor Coming From Vents
- A/C System - Service TSB List
- Air Conditioning - R12 to R134A Retrofit Kit
- Air Conditioning - Return of Obsolete Filter Kits
- A/C - Filtering Refrigerant After Compressor Replacement
- Power Steering System - Noisy
- Steering/Suspension - Pull/Drift Diagnostic Procedure
- Overview
- Service Procedure
- Pull Drift Diagnostic Procedure
- The Road Test
- Diagnostic Procedure # 1 - Tire Mismatch
- Diagnostic Procedure # 2 - Alignment
- Diagnostic Procedure # 3 - Tires
- Diagnostic Procedure # 4 - Steering Gear Valve Off Center
- Diagnostic Procedure # 5 - Rbs Linkage
- Diagnostic Procedure # 6 - Brake Imbalance
- Diagnostic Procedure # 7 - Miscellaneous
- Diagnostic Check List
- Engine Gasket Surface - Cleaning Procedures
- Engine - Repair Tips to Avoid Potential Damage
- Electrical - New Terminal Grease Released For Service
- Fuel Pump - Buzzing/Humming After Engine Shut Down
- Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
- Power Steering Pump - New Design Fitting At Pump Outlet
- Fuel Pump/Sender - Defective Parts Return
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Front Brakes - Popping or Clunking Noise
- Brakes - Intermittent Brake Squeal
- Engine - Stalls/Hesitates/Long Cranking Times
- Campaign - Spark Plug Replacement Label
- Recall - Spark Plug Replacement Label
- A/C Compressor - Oil Recovery/Measuring Procedures
- A/C Compressor - Noise/Vibration
- A/C Compressor - Oil Recovery and Measuring Procedure
- A/C Clutch - Slips At High Ambient Temperature
- Air Conditioning - Approved Flushing Procedures
- Steering Gear - Leak At the Input Shaft
- Timing Belt - Warbling Noise
- Engine Oil Pan Removal/Installation - Manual Revision
- Engine - Oil Pan Gasket Leaks
- Cooling System - New System Diagnostics
- Cooling Fan Blade - Revised Design Available
- Heater - Air Flow From Panel During Heavy Acceleration
- Frame/Crossmember - Snapping/Popping Noise
- Driveshaft - Boom/Vibration At 20-65 MPH
- Lug Nuts - Proper Torqueing Procedure
- Rear Suspension - Low Ride Height When Loaded
- Driveline - Vibration/Shudder During Acceleration
- Lug Nuts - Proper Installation/Torqueing Procedure
- Frame - Rivet Replacement with Bolts Service Tip
- Door Lock Cylinder - Loose in Replacement Door
- Power Window Regulator - Counterbalance Spring
- Driveline - Vibration Between At 25 And 50 MPH
- A/T, Driveline - Leaks/Vibration
- Driveline - Vibration/Boom
- Clutch Disc - Scraping/Rattling/Clicking/Popping
- Front Hub - (4WD) Noise or Failure
- Torque Converter - Cleaning and Replacement Guidelines
- A/T Torque Converter - Leak Test Procedure
- M/T Clutch Housing - Fluid Inside
- M/T Clutch - Growling/Clicking Noise
- Universal Joint - Greasable Design Availability
- Fuel Injector - New Cleaning Method
- Fuel Injector Cleaner - Parts and Service Tips
- MIL ON/Code 41 Displayed
- Body/Frame - Arc Welding Precautions
- EGO Sensors - Silicone Contamination
- Engine - Hard Start/Knock/Stall/Rough Idle
- Engine - Lean Driveability Symptoms
- Rear Brakes - Grab/Stick On First Few Applications
- Brake Computer Module - Obsolete Service Part Return
- Antilock Brakes - Service Tips
- Brake Caliper - Lubrication Of Top and Bottom Groove
- Brakes - Sticking/Binding/Grabbing
- Battery - Test Procedure
- Battery - No Engine Crank/Low Battery Charge
- Alternator - Discharge
- EEC IV Quick Test - Code 16 Set
- Instrument Cluster Warning Lights - Dimly Lit
- Nylon Fuel Lines - Servicing Procedure
- Fuel Tank - Thud or Clunk Sound
- Throttle Body - New Design
- Accelerator Cable - Service Procedures/Tips
- EEC IV EGR Pinpoint Test - Manual Correction
- Speed Control - Intermittent or Inoperative
- Radio - AM Band Noise With Speed Control ON
- Audio Systems - Authorized Service Centers
- Radio - Poor AM Reception
- Electric Rear Window Defroster - Inoperative
- Safety Belts - Front/Rear Twisted at `D' Ring
- Seat Shoulder/Lap Belt - Production Updates
- Brake Rotor - Machining Equipment/Warranty Information
- Recall 98E010000: Brake Rotor Cracking
- Ignition Pinpoint Tests - Service Tips
- DIS Connector Pin Numbers - Manual Revision
- EEC IV - Revised Pinpoint Test Steps
- IDM and Spark Timing Diagnosis - Manual Revision
- Starter Motor Brushes - Replacement Revision
- Fuel Sender Assemblies - Now Available For Service
- Temperature Gauge - Reads Low/Erratic
- Speedometer - Indicates High Speed When Cold
- Grille Assembly - Headlamp Attachment
- A/C Compressor Shaft Seal - Leaks
- Cylinder Head Gasket and Bolts - Revised
- Antilock Control Test Step 4B - Manual Revision
- Rear Anti-Lock Brakes - Adverse Characteristics
- Brakes - False or Dropping Pedal
- Steering Wheel - Removal Precautions
- Front Drive Axle - Identification Tags
- Emission Control System - Technician's Glossary
- Wiring Circuit 16 Wire Color - Revision
- EEC Connector - Color Code Changes
- EEC System Electrical Schematic - Manual Revision
- Electronic Modules - Protection From Static Electricity
- Vehicle - Welding Precautions
- Electrical/Electronic/Fuel Induction - Glossary
- Automatic Hublock - Diagnosis/Service Tips
- Differential - Chatter On Turns
- Steering Column - Rattles
- Door Latches - Adjustment/Modification Prohibition
- Liftgate Trim Panel - Cracking
- Windshield - Material Usage Procedure
- Windshield/Interior Glass - Fog/Film
- Glass - Iridescence or Mottling In Tempered Glass
- Mirrors - Optional Right Side Mirror Head
- Rear View Mirror - Reattachment
- Front Seat Center Armrest - Loose/Wobbles
- Motor Oil - Viscosity Grade Recommendation
- Cooling System - Proper Fluid Concentrations
- Engine Coolant - Recycled Coolant Not Authorized
- Recycled Engine Coolant - Service Tips
- Engine Coolant - Propylene Glycol Recommendations
- Brake Hoses - Wet Appearance
- A/T - A4LD/4R44E/5R55E New Center Support
- A/T - A4LD Converter Channel Spring Addition
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - In Line Fluid Filter Kit
- A/T - Transmission Flush and Fill Tool Available
- A/T - A4LD Slipping or Soft Shifts After Rebuild
- A/T - A4LD Front Seal Blow Out
- A/T - Engine Vacuum Testing
- A/T - Slips or No 3 or Reverse, 2-3 Flare
- A/T - A4LD No Reverse After Rebuild
- A/T - A4LD No Movement After Rebuild
- A/T - How To Use A Pressure Gauge
- A/T - EEC Trouble Codes
- A/T - Diagnostic Trouble Codes for 1983-1992
- A/T - A4LD No 4th Gear
- A/T - A4LD No Reverse
- A/T - A4LD 4-3 Gear Flare, No Engagement in O/D
- A/T - Pump Damage After Overhaul
- A/T - Binding Condition In Park
- A/T - E40D Second Gear Starts
- A/T - A4LD Cooler Line Fittings
- A/T - A4LD Bellhousing and Pump Interchange
- A/T - A4LD, 4R44E/4R55E Pump Interchangeability
- A/T - A4LD Support Ring Identification
- A/T - A4LD/C3 Front Pump Support Inspection
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - A4LD Overdrive Sun Gear Support Inspection
- A/T - A4LD Delay In Reverse/Occasional No-Reverse
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T Assembly Procedure - Revision
- A/T - Mercon V ATF Usage
- A/T - Shift Selector Indicates Incorrect Gear
- A/C - FX 15 Compressor Clutch Shaft and Hub Assembly
- Recall 89V234000: Air Inlet Tube Replacement
- Recall 90V044000: Air Inlet Tube Replacement
- Octane Adjust Shorting Bar - Revised Procedures
- Driveability TSB's - Summary
- Engine - New Gasket Sealer
- Wire Harness - Terminal Repair Kit
- Wire Harness Terminal and Connector - Service Kit
- Fuel System - Fuel Stabilizer For Extended Storage
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Speed Control - Diagnostic Tips
- Recall 94V167000: Incorrect Quarter Glass Markings
- Lower Body Stone Protection - Repair Procedure
- Paint - Preparation Procedure And MSDS Information
- Exterior Clearcoat - Cracking/Eroding/Peeling Off
- Exterior Paint - Comprehensive Repair Procedures
- Overview
- Section A Has Been Superseded By TSB # 9264, Dated 3/92.
- (B) Paint Exterior Color Peeling From Ultra Violet Light
- (C) Lower Body Stone Protection Repair Tips
- (D) Procedure For PVC Body Side Moldings
- (E) Lower Body-Side Stone Chip Protection Program
- (F) Surface Defect Removal Without Repainting
- (G) Color Compatible Spray Primer Chart
- (H) Paint Repair For Tinted Clear Coat
- (I) Paintable Plastics
- (J) 1992 Paint Color Codes
- Paint - Iron Particle Removal
- A/C System - Chemical/Refrigerator Type Odor
- Electrical Diode - Identification and Replacement
- Center Bearing Support - Service Procedure
- Running Boards - Noise/Vibration Installation Tips
- Headlamp - Horizontal Adjuster Difficult Access
- Heater - Lack of Heat to the Floor Area
- A/T - A4LD Harsh 2nd - 3rd Gear Backout Upshift
- Campaign - Running Light Module, Extended Coverage
- Recall - A/T A4LD Park Pawl Spring Replacement
- Recall - A/T A4LD Park Pawl Spring Update
- Recall 91V189000: Park Pawl Defect
- Hood Lamp Switch - Revised
- Radio - Poor AM Reception/Fading/Engine Noise
- A/C - R12 Refrigerant Service Tips
- A/C - R12 Refrigerant Substitutes Service Tip
- R-12 Refrigerant - Substitutes
- Air Conditioning - Use of Correct Fluorescent Tracer Dye
- A/C - Identification of Non Approved Refrigerants
- M/T - M50D Hard Shift Condition
- M/T - Crunching Shifting From 2nd to 3rd Gear
- A/C Coupling - Cleaning Procedures
- Air Conditioning - O Ring Removal Service Tip
- A/C - New Refrigerant O-Rings
- Door Window Bracket Assembly - Part Return
- Running Lights - Flicker On and Off
- Brakes - New Silicone Compound/Grease
- Engine - Rough Idle/Hesitation/Backfire/Stalling
- Ignition Timing Procedure - Manual Update
- Fuel - California Reformulated Gasoline
- Fuel - Volatility Related Driveability Concerns
- Front Alignment - Specifications
- A/C - Adding Refrigerant Oil Service Tip
- A/C Compressor - Service Tips
- Seat Leather - Cleaning Procedure Tips
- Passenger Seat Back - Rattles When Unoccupied
- M/T - Mercon(R) V ATF Usage Information
- A/T - Torque Converter Slip/DTC 628/P0741 Set