Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Power Steering System - Noisy
- Engine - Carbon Knock On Acceleration
- Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
- Fuel Pump - Noise/Whine
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Front Brakes - Popping or Clunking Noise
- Front Disc Brakes - Popping/Clunking Noise
- Engine - Multiple Oil Leaks
- Rear Crankshaft Oil Seal/Dipstick Tube - Leaks Oil
- A/C - Poor Cooling In High Amnient Temperatures
- Steering - Rapping or Clanging Noise
- Bumper - Loose or Unattached Ends
- Door Lock Cylinder - Loose in Replacement Door
- Sliding Door Weatherstrip - Worn or Damaged
- Rear Axle - Whine/Howl At Light Throttle
- Driveline (E4WD) - Popping/Tires Chirping/Wheel Hop
- M/T Clutch Housing - Fluid Inside
- Engine - Lean Driveability Symptoms
- Accessory Drive Belt - Squeal or Hoot Noise
- Rear Brakes - Squeal Noise When Cold
- Brakes - Sticking/Binding/Grabbing
- Battery - No Engine Crank/Low Battery Charge
- Alternator - Discharge
- Instrument Cluster Warning Lights - Dimly Lit
- Fuel Line - Knocking Noises
- Heated Backlite - Inoperative
- Electric Rear Window Defroster - Inoperative
- Safety Belts - Front/Rear Twisted at `D' Ring
- Digital Fuel Gauge - Displays CO Error Code
- Electronic Fuel Gauge - Erratic Readings
- Temperature Gauge - Fluctuation/Inaccurate
- Speedometer - Indicates High Speed When Cold
- Instrument Cluster - Dim or Blank Display
- Steering - Clunk/Rattle/Premature Tire Wear
- Rocker Panel - Front/Rear Rust Perforation
- Differential - Chatter On Turns
- Front Drive Axle - Fluid Leak From Vent
- Rear View Mirror - Detaches From Windshield
- Parking Brake - Does Not Ratchet On First Application
- Engine - Noise/Vibration/No Crank/No A/T Engagement
- Exterior Clearcoat - Cracking/Eroding/Peeling Off
- A/C System - Chemical/Refrigerator Type Odor
- A/T - Increase In RPM During Light Throttle 2-3 Upshifts
- A/T - A4LD Harsh 2nd - 3rd Gear Backout Upshift
- M/T - M50D Hard Shift Condition
- M/T - Crunching Shifting From 2nd to 3rd Gear
- Front Door Glass - Binds During Downward Travel
- Transfer Case - (E4WD) Noise/Vibration
- Engine - Rough Idle/Hesitation/Backfire/Stalling
- Climate Control - Improper Operation
- Air Conditioning - Poor Performance
- Passenger Seat Back - Rattles When Unoccupied
- Transfer Case - E4WD Fluid Leaks
- A/T - Torque Converter Slip/DTC 628/P0741 Set
- Chemicals,Additives
- Labor/Parts Updates
- Seals, Gaskets
- Superceded Bulletins
- 92914 - 04/22/92
- 92412 - 02/12/92
- 9174 - 04/05/91
- 91512 - 03/06/91
- 91118 - 05/30/91
- 91109 - 05/15/91
- 902314 - 11/07/90
- 90148 - 07/05/90
- 90137 - 06/20/90
- 90119 - 05/23/90
- 89252 - 12/13/89
- 89165 - 08/09/89
- 8856 - 03/03/88
- 88246 - 11/23/88
- 88245 - 11/23/88
- 87716 - 04/08/87
- 872013 - 10/07/87
- 831915 - 09/20/83
- Door Glass - Tipping/Binding During Downward Travel
- Roof - Seam and Drip Rail Repairs
- Frame Rivets - Damaged/Loose
- Sliding Door Handle - Kit For Increase Theft Resistance
- A/C - Identification Of Non Approved Refrigerants
- A/C - R134A Retrofit Kit Availability
- A/C - R12 to R134a Retrofit Kit Availability
- A/C - Approved Flushing Procedures
- Air Conditioning - Musty or Mildew Type Odors
- A/C System - Musty/Mildew Odors
- A/C - O Ring Removal From Spring Lock Coupling
- Frame - Rivet Replacement With Bolts, Service Tip
- Frame - Damaged or Loose Rivets
- Power Steering Pump - Noise
- Power Steering Pump - Noisy
- Power Steering Pump - Noises
- Power Steering - Rapping or Clanging Sound
- Power Steering - 'Rapping' or 'Clanging' Noise
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Wire Harness - Terminal Repair And Wire Splice Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Repair
- Wire Harness - Terminal Repair Kit/Splice Procedure
- Electrical - Wiring Harness Terminal Repair Kit
- Wire Harness - Terminal Repair Kits
- Wire Harness Terminal and Connector - Repair Kit
- Wire Harness - New Terminal Repair Kit
- Radio - Whining/Buzzing Noise
- Brakes - Service Tips
- Brakes - Special Lubricant Requirements
- Brake Rotor - Machining With On-Vehicle Equipment
- Front Brakes - Stick/Bind/Grab
- Rear Axle - Whine or Howl During Light Throttle
- A/T - New Transmission Cooler Flusher/Service Tip
- A/T - A4LD Harsh 2nd - 3rd Gear Upshift
- A/T - A4LD Slight Engine Flare On Upshifts
- Fuel Economy - Customer Expectations Vs. Vehicle Usage
- Fuel Economy - Expectations Versus Usage
- Fuel Line - Knocking Noise
- Speaker - Whining/Buzzing Noise
- Speakers - Whining/Buzzing Noise
- Fuel Pump - Buzz/Whine Through Radio Speakers
- Fuel Pump - Whine/Buzz Noise Heard In Speakers
- Radio - Whine/Buzz
- Radio - Buzzing/Whining Noise
- Exhaust System - Buzz or Rattle Noise
- Exhaust System - Buzzing/Rattling Noises
- Exhaust System - Rattling/Buzzing Noise
- Exhaust System - Buzz/Rattle Noise
- Heater Core - Repeated Failure
- Cooling System - Diagnosis Procedure
- Temperature Gauge - Fluctuates/Inaccurate
- Engine - Oil Leaks From Rear Of Engine
- Engine - Oil Leaks From Rear of Engine
- Engine - Oil Leaks
- Valve Cover - Oil Leaks
- Engine - Oil Leak Diagnosis/Repair
- Rocker Cover Gasket - Oil Leaks
- A/T - Fluid Application Charts
- A/C System - New A/C Filter Kit
- A/C - New Filter to Prevent Compressor Damage
- A/C System - New Filter Kit
- Air Conditioning - Prevent Damage to Compressor
- Front Disc Brake - Popping/Clunking Noise
- A/C - Refrigerant Filtering Tips
- A/C - Refrigerant Filtering Service Tips
- A/C System - Refrigerant Filtering Service Tips
- Wheels - Proper Lug Torque Procedures
- Brakes - Vibration Prevention Service tip
- Propylene Glycol Coolant - Recommendations
- Recycled Engine Coolant - Service Tip
- A/T - Transmission Fluid Usage Charts
- Automatic Transmission - Fluid Usage Charts
- A/C - Filter Kit Installation After Replacing Compressor
- A/C Compressor Replacement - Refrigerant Filtering
- A/C System - Use of R12 Refrigerant Substitutes
- Air Conditioning - Filtering Refrigerant
- A/C - Non Approved Refrigerants
- A/C - Approved/Alternate Refrigerants
- A/C - Identification of Non-Approved Refrigerants
- A/C - Identifying Non-Approved Refrigerants
- Vehicle - Towing Guidelines
- All Technical Service Bulletins
- Vehicle - Towing Behind RVs Guidelines
- A/C System - Service TSB List
- Air Conditioning - R12 to R134A Retrofit Kit
- Air Conditioning - Return of Obsolete Filter Kits
- A/C - Filtering Refrigerant After Compressor Replacement
- Power Steering System - Noisy
- Engine - Revised Torque Procedures and Specifications
- Engine Gasket Surface - Cleaning Procedures
- Engine - Repair Tips to Avoid Potential Damage
- Engine - Carbon Knock On Acceleration
- Electrical - New Terminal Grease Released For Service
- Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
- Fuel Pump - Noise/Whine
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Front Brakes - Popping or Clunking Noise
- Front Disc Brakes - Popping/Clunking Noise
- Brakes - Intermittent Brake Squeal
- A/C Compressor - Oil Recovery/Measuring Procedures
- A/C Compressor - Oil Recovery and Measuring Procedure
- A/C Compressor - Noise
- A/C Clutch - Slips At High Ambient Temperature
- Air Conditioning - Approved Flushing Procedures
- Cooling System - New System Diagnostics
- Cooling Fan Blade - Revised Design Available
- Engine - Multiple Oil Leaks
- Rear Crankshaft Oil Seal/Dipstick Tube - Leaks Oil
- Rear Main Oil Seal Replacement - Service Tip
- Muffler - Corrodes Prematurely
- A/C - Poor Cooling In High Amnient Temperatures
- A/C - FX15 Clutch Application Chart
- Lug Nuts - Proper Torqueing Procedure
- Steering - Rapping or Clanging Noise
- Lug Nuts - Proper Installation/Torqueing Procedure
- Frame - Rivet Replacement with Bolts Service Tip
- Bumper - Loose or Unattached Ends
- Door Lock Cylinder - Loose in Replacement Door
- Sliding Door Weatherstrip - Worn or Damaged
- Rear Axle - Whine/Howl At Light Throttle
- Noise/Vibration/Ride Harshness - Diagnostic Chart
- Driveline (E4WD) - Popping/Tires Chirping/Wheel Hop
- Torque Converter - Cleaning and Replacement Guidelines
- A/T Torque Converter - Leak Test Procedure
- M/T Clutch Housing - Fluid Inside
- Universal Joint - Greasable Design Availability
- Fuel Injector - New Cleaning Method
- Fuel Injector Specifications - Manual Revisions
- Fuel Injector Cleaner - Parts and Service Tips
- Heated Exhaust Gas Oxygen Sensor - Application Chart
- EGO Sensors - Silicone Contamination
- Engine - Lean Driveability Symptoms
- Accessory Drive Belt - Squeal or Hoot Noise
- Rear Brakes - Squeal Noise When Cold
- Brake Computer Module - Obsolete Service Part Return
- Antilock Brakes - Service Tips
- Brakes - Sticking/Binding/Grabbing
- Battery - Test Procedure
- Battery - No Engine Crank/Low Battery Charge
- Alternator - Discharge
- Starter Solenoids and Drives - Obsolete Parts Return
- Instrument Cluster Warning Lights - Dimly Lit
- Recall - Ignition Switch Replacement
- Recall 96V071000: Ignition Switch Short Circuit
- Connector, DIS Ignition Revised
- Nylon Fuel Lines - Servicing Procedure
- Fuel Line - Knocking Noises
- Engine Idle Adjustment Procedures - Revision
- Idle Airflow - Adjustment Procedures Revision
- Accelerator Cable - Service Procedures/Tips
- Audio Systems - Authorized Service Centers
- Heated Backlite - Inoperative
- Electric Rear Window Defroster - Inoperative
- Safety Belts - Front/Rear Twisted at `D' Ring
- Recall 91V164000: Seat Belt Anchor Replacement
- Brake Rotor - Machining Equipment/Warranty Information
- Recall 98E010000: Brake Rotor Cracking
- Ignition Pinpoint Tests - Service Tips
- Ignition System - Diagnostic Procedures Revision
- Overview
- Ignition System Applications
- Initial Timing Set Procedure
- TFI-IV Ignition System
- Description and Schematic
- Preliminary Checkout, Equipment and Notes
- System Description
- Sensor Description
- Acronyms, Module, and Pin-Out
- Waveforms
- Block Diagram
- Wiring Schematic With Diagnostic Harness Installed
- Diagnostic Cable
- Testing
- Pinpoint Test Symptom Index
- Pinpoint Test A1 Thru A13
- Pinpoint Test A14 Thru A19
- Pinpoint Test A20 Thru A25
- Pinpoint Test AA1 Thru AA9
- Pinpoint Test AA10 Thru AA14
- Pinpoint Test AA15 Thru AA19
- Pinpoint Test AA20 Thru AA25
- Pinpoint Test AA26 Thru AA31
- Pinpoint Test B1 Thru B8
- Pinpoint Test C1 Thru C8
- Checkout and Notes For Intermittent Diagnosis
- Intermittent Diagnosis D1 Thru D10
- Secondary Ignition System Diagnosis
- Duraspark II Non-EEC Spark Timing Advance Test
- Symptom Index For Part I and II
- Part 1 Secondary System
- Part 2 Ignition System Test
- Visual Inspection, Equipment and Notes
- Test 1 Start Circuit
- Test 2 Run Circuit
- Test 3 Module Voltage
- Test 4 Ballast Resistor
- Test 5 Supply Voltage Circuits
- Test 6 Ign. Coil Supply Voltage
- Test 7 Distributor Stator and Wiring Harness
- Test 8 Ign. Module to Distributor Stator
- Test 9 Ign. Coil Secondary Resistance
- Test 10 Module to Coil Wire
- Test 11 Distributor Stator Assembly
- Test 12 Ign. Coil Primary Resistance
- Test 13 Primary Circuit Continuity
- Test 14 Ground Circuit Continuity
- Test 15 Distributor GRD. Circuit Continuity
- Intermittent Diagnosis
- IDM and Spark Timing Diagnosis - Manual Revision
- Starter Motor Brushes - Replacement Revision
- Digital Fuel Gauge - Displays CO Error Code
- Electronic Fuel Gauge - Erratic Readings
- Temperature Gauge - Fluctuation/Inaccurate
- Temperature Gauge - Reads Low/Erratic
- Speedometer - Indicates High Speed When Cold
- Instrument Cluster - Dim or Blank Display
- Rocker Cover Gasket - Installation Revision
- Rear Anti-Lock Brakes - Adverse Characteristics
- Steering - Clunk/Rattle/Premature Tire Wear
- Rear Pinion Angle Offset - Manual Correction
- Body - Roof Panel and Drip Rail Repairs
- Sheet Molding Composite - Body Repair
- Rocker Panel - Front/Rear Rust Perforation
- EEC IV Quick Test - Manual Revision
- MIL ON/No Codes Set Explanation
- EEC IV - Self Test Codes and MIL Service Tips
- Overview
- Overview of Three Digit EEC-IV Self-Test Codes
- 1) Technician Not Familiar With Self-Test Code Output
- 2) Inadvertent Erasure of Continuous Memory Self-Test Codes
- 3) Concern Setting Continious Memory Code Isn't Present
- 4) Grounded STO/MIL Circuit
- 5) Engine Running In Hlos
- 6) Misinterpretation of MIL Bulb Check
- 7) MIL Flashes During Self-Test
- 8) Processor KAM Is Erased or Fails
- 9) Damaged Star Tester
- 10) KOEO Processor Ram Test Failed
- 11) Intermittent VSS Fault Detected In Wiggle Mode
- 12) IDM Pulswidth Not Recognized By Processor (EDIS Vehicles)
- 13) Intermittent Ignition System Fault
- 14) Intermittent Open STI Circuit
- 15) Power Lost to EEC Processor
- 16) Other Warning Lamps Mistaken For MIL
- 17) Development Testing /Wrong Processor Released to Production
- EEC IV Pinpoint Test H - Manual Correction
- Vehicle - Welding Precautions
- Rear Seat Headphone Speaker - Control Knob Available
- Differential - Chatter On Turns
- Front Drive Axle - Fluid Leak From Vent
- Door Latches - Adjustment/Modification Prohibition
- Windshield - Material Usage Procedure
- Windshield/Interior Glass - Fog/Film
- Glass - Iridescence or Mottling In Tempered Glass
- Rear View Mirror - Detaches From Windshield
- Rear View Mirror - Reattachment
- Bumper Cover - Repair Materials Update
- Paint - Procedure/Products For Plastic Service Parts
- Engine - Oil Fill Capacities
- Motor Oil - Viscosity Grade Recommendation
- Cooling System - Proper Fluid Concentrations
- Recycled Engine Coolant - Service Tips
- Engine Coolant - Propylene Glycol Recommendations
- Brake Hoses - Wet Appearance
- Parking Brake - Does Not Ratchet On First Application
- A/T - A4LD/4R44E/5R55E New Center Support
- A/T - A4LD Converter Channel Spring Addition
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - In Line Fluid Filter Kit
- A/T - Transmission Flush and Fill Tool Available
- A/T - A4LD Slipping or Soft Shifts After Rebuild
- A/T - A4LD Front Seal Blow Out
- A/T - Engine Vacuum Testing
- A/T - Slips or No 3 or Reverse, 2-3 Flare
- A/T - A4LD No Reverse After Rebuild
- A/T - A4LD No Movement After Rebuild
- A/T - How To Use A Pressure Gauge
- A/T - Diagnostic Trouble Codes for 1983-1992
- A/T - A4LD No 4th Gear
- A/T - A4LD No Reverse
- A/T - A4LD 4-3 Gear Flare, No Engagement in O/D
- A/T - A4LD Premature Converter Bushing Failure
- A/T - Pump Damage After Overhaul
- A/T - Binding Condition In Park
- A/T - E40D Second Gear Starts
- A/T - A4LD Cooler Line Fittings
- A/T - A4LD Bellhousing and Pump Interchange
- A/T - A4LD, 4R44E/4R55E Pump Interchangeability
- A/T - A4LD Support Ring Identification
- A/T - A4LD/C3 Front Pump Support Inspection
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - A4LD Overdrive Sun Gear Support Inspection
- A/T - A4LD Delay In Reverse/Occasional No-Reverse
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Engine - Noise/Vibration/No Crank/No A/T Engagement
- A/T - Mercon V ATF Usage
- A/T - A4LD Parts Return of Obsolete Shift Cable
- A/C - FX 15 Compressor Clutch Shaft and Hub Assembly
- Octane Adjust Shorting Bar - Revised Procedures
- Speedometer - Service Replacements With Pre-Set Mileage
- Engine - New Gasket Sealer
- Wire Harness - Terminal Repair Kit
- Fuel System - Fuel Stabilizer For Extended Storage
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Speed Control - Diagnostic Tips
- Plastic Credit Card Keys - Cutting Procedure
- Paint - Preparation Procedure And MSDS Information
- Paint - Color Code Chart Revision
- Exterior Clearcoat - Cracking/Eroding/Peeling Off
- Exterior Paint - Comprehensive Repair Procedures
- Overview
- Section A Has Been Superseded By TSB # 9264, Dated 3/92.
- (B) Paint Exterior Color Peeling From Ultra Violet Light
- (C) Lower Body Stone Protection Repair Tips
- (D) Procedure For PVC Body Side Moldings
- (E) Lower Body-Side Stone Chip Protection Program
- (F) Surface Defect Removal Without Repainting
- (G) Color Compatible Spray Primer Chart
- (H) Paint Repair For Tinted Clear Coat
- (I) Paintable Plastics
- (J) 1992 Paint Color Codes
- Paint - Iron Particle Removal
- A/C System - Chemical/Refrigerator Type Odor
- Electrical Diode - Identification and Replacement
- A/T - Increase In RPM During Light Throttle 2-3 Upshifts
- A/T - A4LD Harsh 2nd - 3rd Gear Backout Upshift
- Campaign - Running Light Module, Extended Coverage
- Speaker - Static/ Popping Noise When Horn Is Blowing
- Recall - A/T A4LD Park Pawl Spring Replacement
- Recall 91V189000: Park Pawl Defect
- A/T - A4LD Servo Cover Heat Shield
- A/C - R12 Refrigerant Service Tips
- A/C - R12 Refrigerant Substitutes Service Tip
- R-12 Refrigerant - Substitutes
- Air Conditioning - Use of Correct Fluorescent Tracer Dye
- A/C - Identification of Non Approved Refrigerants
- M/T - M50D Hard Shift Condition
- M/T - Crunching Shifting From 2nd to 3rd Gear
- A/C Coupling - Cleaning Procedures
- Air Conditioning - O Ring Removal Service Tip
- A/C - New Refrigerant O-Rings
- Front Door Glass - Binds During Downward Travel
- Transfer Case - (E4WD) Noise/Vibration
- Brakes - New Silicone Compound/Grease
- Brake Service - Service Tips
- Engine - Rough Idle/Hesitation/Backfire/Stalling
- Fuel - California Reformulated Gasoline
- Fuel - Volatility Related Driveability Concerns
- Climate Control - Improper Operation
- Air Conditioning - Poor Performance
- A/C - Adding Refrigerant Oil Service Tip
- A/C Compressor - Service Tips
- Seat Leather - Cleaning Procedure Tips
- Passenger Seat Back - Rattles When Unoccupied
- Replacement Sliding Door - Service Tip
- Transfer Case - E4WD Fluid Leaks
- M/T - Mercon(R) V ATF Usage Information
- A/T - Torque Converter Slip/DTC 628/P0741 Set