Powertrain Management: Technical Service Bulletins
- Recalls
- Customer Interest
- Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
- Engine - Hard Starting/Lack of Power
- Radio/Two-Way Communications - Whine/Buzz
- Fuel Pump - Whine Heard Through Radio Speakers
- Engine - Stalls/Quits Running
- Audio System - Whining/Buzzing Noise From Speakers
- Engine - Lack of Power/No Start Condition
- EEC Processor - MIL ON/Code 173 Set
- A/T - E4OD Harsh/Double Bump On Reverse Engagement
- Engine - High Idle After Highway Cruise
- Instrument Cluster Warning Lights - Dimly Lit
- EVAP System - MIL ON/Codes 171/173/179 Set
- A/T - E4OD Shift Concerns/DTC's Set
- EGR Tube - Exhaust System Noise
- Engine - Rough Idle/Hesitation/Backfire/Stalling
- By Symptom
- Customer Interest
- Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
- Engine - Hard Starting/Lack of Power
- Radio/Two-Way Communications - Whine/Buzz
- Fuel Pump - Whine Heard Through Radio Speakers
- Engine - Stalls/Quits Running
- Audio System - Whining/Buzzing Noise From Speakers
- Engine - Lack of Power/No Start Condition
- EEC Processor - MIL ON/Code 173 Set
- A/T - E4OD Harsh/Double Bump On Reverse Engagement
- Engine - High Idle After Highway Cruise
- Instrument Cluster Warning Lights - Dimly Lit
- EVAP System - MIL ON/Codes 171/173/179 Set
- A/T - E4OD Shift Concerns/DTC's Set
- EGR Tube - Exhaust System Noise
- Engine - Rough Idle/Hesitation/Backfire/Stalling
- Driveability
- Erratic Operation
- Erratic Shifting
- False instrument warning light/gauges
- EEC Processor - MIL ON/Code 173 Set
- Instrument Cluster Warning Lights - Dimly Lit
- EVAP System - MIL ON/Codes 171/173/179 Set
- EEC IV - Self Test Codes and MIL Service Tips
- Overview
- Overview of Three Digit EEC-IV Self-Test Codes
- 1) Technician Not Familiar With Self-Test Code Output
- 2) Inadvertent Erasure of Continuous Memory Self-Test Codes
- 3) Concern Setting Continious Memory Code Isn't Present
- 4) Grounded STO/MIL Circuit
- 5) Engine Running In Hlos
- 6) Misinterpretation of MIL Bulb Check
- 7) MIL Flashes During Self-Test
- 8) Processor KAM Is Erased or Fails
- 9) Damaged Star Tester
- 10) KOEO Processor Ram Test Failed
- 11) Intermittent VSS Fault Detected In Wiggle Mode
- 12) IDM Pulswidth Not Recognized By Processor (EDIS Vehicles)
- 13) Intermittent Ignition System Fault
- 14) Intermittent Open STI Circuit
- 15) Power Lost to EEC Processor
- 16) Other Warning Lamps Mistaken For MIL
- 17) Development Testing /Wrong Processor Released to Production
- Hard Shifting
- Noise
- Overheating
- Poor performance
- Recalls
- Slipping
- Starting problems
- Customer Interest
- All Technical Service Bulletins
- Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
- Engine - Hard Starting/Lack of Power
- Radio/Two-Way Communications - Whine/Buzz
- Fuel Pump - Whine Heard Through Radio Speakers
- Engine - Stalls/Quits Running
- Audio System - Whining/Buzzing Noise From Speakers
- Engine - Lack of Power/No Start Diagnosis
- Engine - Spark Knock Diagnostic Procedure
- Engine - Lack of Power/No Start Condition
- Fuel Injector - New Cleaning Method
- Engine - Rough Idle or Stumble
- Fuel Injector Cleaner - Parts and Service Tips
- Deposit Resistant Fuel Injectors - Identification
- EEC Processor - MIL ON/Code 173 Set
- A/T - E4OD Harsh/Double Bump On Reverse Engagement
- Heated Exhaust Gas Oxygen Sensor - Application Chart
- EGO Sensors - Silicone Contamination
- Engine - High Idle After Highway Cruise
- Instrument Cluster Warning Lights - Dimly Lit
- Nylon Fuel Lines - Servicing Procedure
- A/T - E4OD Turbocharger/Supercharger Incompatible
- Accelerator Cable - Service Procedures/Tips
- EVAP System - MIL ON/Codes 171/173/179 Set
- Ignition System - Diagnostic Procedures Revision
- Overview
- Ignition System Applications
- Initial Timing Set Procedure
- TFI-IV Ignition System
- Description and Schematic
- Preliminary Checkout, Equipment and Notes
- System Description
- Sensor Description
- Acronyms, Module, and Pin-Out
- Waveforms
- Block Diagram
- Wiring Schematic With Diagnostic Harness Installed
- Diagnostic Cable
- Testing
- Pinpoint Test Symptom Index
- Pinpoint Test A1 Thru A13
- Pinpoint Test A14 Thru A19
- Pinpoint Test A20 Thru A25
- Pinpoint Test AA1 Thru AA9
- Pinpoint Test AA10 Thru AA14
- Pinpoint Test AA15 Thru AA19
- Pinpoint Test AA20 Thru AA25
- Pinpoint Test AA26 Thru AA31
- Pinpoint Test B1 Thru B8
- Pinpoint Test C1 Thru C8
- Checkout and Notes For Intermittent Diagnosis
- Intermittent Diagnosis D1 Thru D10
- Secondary Ignition System Diagnosis
- Duraspark II Non-EEC Spark Timing Advance Test
- Symptom Index For Part I and II
- Part 1 Secondary System
- Part 2 Ignition System Test
- Visual Inspection, Equipment and Notes
- Test 1 Start Circuit
- Test 2 Run Circuit
- Test 3 Module Voltage
- Test 4 Ballast Resistor
- Test 5 Supply Voltage Circuits
- Test 6 Ign. Coil Supply Voltage
- Test 7 Distributor Stator and Wiring Harness
- Test 8 Ign. Module to Distributor Stator
- Test 9 Ign. Coil Secondary Resistance
- Test 10 Module to Coil Wire
- Test 11 Distributor Stator Assembly
- Test 12 Ign. Coil Primary Resistance
- Test 13 Primary Circuit Continuity
- Test 14 Ground Circuit Continuity
- Test 15 Distributor GRD. Circuit Continuity
- Intermittent Diagnosis
- IDM and Spark Timing Diagnosis - Manual Revision
- Recall - Vehicle Emission Control Label Replacement
- Key On Engine Off Self Test Code 79/539 - Revision
- EEC IV Quick Test - Manual Revision
- MIL ON/No Codes Set Explanation
- EEC IV - Self Test Codes and MIL Service Tips
- Overview
- Overview of Three Digit EEC-IV Self-Test Codes
- 1) Technician Not Familiar With Self-Test Code Output
- 2) Inadvertent Erasure of Continuous Memory Self-Test Codes
- 3) Concern Setting Continious Memory Code Isn't Present
- 4) Grounded STO/MIL Circuit
- 5) Engine Running In Hlos
- 6) Misinterpretation of MIL Bulb Check
- 7) MIL Flashes During Self-Test
- 8) Processor KAM Is Erased or Fails
- 9) Damaged Star Tester
- 10) KOEO Processor Ram Test Failed
- 11) Intermittent VSS Fault Detected In Wiggle Mode
- 12) IDM Pulswidth Not Recognized By Processor (EDIS Vehicles)
- 13) Intermittent Ignition System Fault
- 14) Intermittent Open STI Circuit
- 15) Power Lost to EEC Processor
- 16) Other Warning Lamps Mistaken For MIL
- 17) Development Testing /Wrong Processor Released to Production
- EEC IV Pinpoint Test H - Manual Correction
- Vehicle - Welding Precautions
- A/T - E4OD TCIL Flashing/DTC's 62/628/1728 Stored
- A/T - E4OD Diagnostics Revision/Correction
- A/T - Electronics Diagnostic and Repair Chart
- A/T - Electronic Transmission Repair Process Chart
- A/T - E4OD Shift Concerns/DTC's Set
- A/T - E4OD New Design Transmission Range Sensor
- Recall 91V146000: Fuel Tank Selector Malfunction
- Recall - Fuel Tank Selector Valve Replacement
- Fuel Tank Switching Valve - Service Tips
- Fuel System - Fuel Stabilizer For Extended Storage
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- EGR Tube - Exhaust System Noise
- Engine - Rough Idle/Hesitation/Backfire/Stalling
- Fuel - California Reformulated Gasoline