Powertrain Management: Technical Service Bulletins
- Recalls
- Customer Interest
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Engine Controls - Low RPM, No Start, Runs Poorly
- A/T - E4OD Downshifts Too Often/No 4th Gear
- A/T - Harsh Shifts/Trouble Code 62/TCIL Lamp Flashes
- A/T - E4OD Harsh/Double Bump On Reverse Engagement
- Ignition Switch - Harness Connector Non-Mating
- Fuel System - Difficult or Slow Filling Fuel Tank
- Exhaust System - Buzzing/Rattling Noise
- Diesel Engine - Hard Start/No Start Condition
- A/T - E4OD Shift Concerns/DTC's Set
- Engine - Oil Leak at Valley Pan/Oil Pump
- Engine - Stalls When Coming to A Stop
- Diesel Engine - Hesitates/Stalls/Lack of Power/Stumbles
- By Symptom
- Abnormal wear/deterioration
- Customer Interest
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Engine Controls - Low RPM, No Start, Runs Poorly
- A/T - E4OD Downshifts Too Often/No 4th Gear
- A/T - Harsh Shifts/Trouble Code 62/TCIL Lamp Flashes
- A/T - E4OD Harsh/Double Bump On Reverse Engagement
- Ignition Switch - Harness Connector Non-Mating
- Fuel System - Difficult or Slow Filling Fuel Tank
- Exhaust System - Buzzing/Rattling Noise
- Diesel Engine - Hard Start/No Start Condition
- A/T - E4OD Shift Concerns/DTC's Set
- Engine - Oil Leak at Valley Pan/Oil Pump
- Engine - Stalls When Coming to A Stop
- Diesel Engine - Hesitates/Stalls/Lack of Power/Stumbles
- Driveability
- Erratic Shifting
- False instrument warning light/gauges
- A/T - Harsh Shifts/Trouble Code 62/TCIL Lamp Flashes
- EEC IV - Self Test Codes and MIL Service Tips
- Overview
- Overview of Three Digit EEC-IV Self-Test Codes
- 1) Technician Not Familiar With Self-Test Code Output
- 2) Inadvertent Erasure of Continuous Memory Self-Test Codes
- 3) Concern Setting Continious Memory Code Isn't Present
- 4) Grounded STO/MIL Circuit
- 5) Engine Running In Hlos
- 6) Misinterpretation of MIL Bulb Check
- 7) MIL Flashes During Self-Test
- 8) Processor KAM Is Erased or Fails
- 9) Damaged Star Tester
- 10) KOEO Processor Ram Test Failed
- 11) Intermittent VSS Fault Detected In Wiggle Mode
- 12) IDM Pulswidth Not Recognized By Processor (EDIS Vehicles)
- 13) Intermittent Ignition System Fault
- 14) Intermittent Open STI Circuit
- 15) Power Lost to EEC Processor
- 16) Other Warning Lamps Mistaken For MIL
- 17) Development Testing /Wrong Processor Released to Production
- Hard Shifting
- Incorrect gear selection
- Leaks
- Noise
- Poor performance
- Recalls
- Slipping
- Starting problems
- All Technical Service Bulletins
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Engine Control - Power Loss, MIL ON
- Fuel Injectors - Non Warranty Reimbursement Testing
- Fuel System - Injector Bore Scuffing After Replacement
- Fuel System - Injector Performance Analyzer
- Engine Controls - Low RPM, No Start, Runs Poorly
- A/T - E4OD Downshifts Too Often/No 4th Gear
- PCM - Reprogramming Tips
- A/T - Harsh Shifts/Trouble Code 62/TCIL Lamp Flashes
- A/T - E4OD Harsh/Double Bump On Reverse Engagement
- PCM - Reprogramming Out of Vehicle
- Recall 94V101000: Cruise Control Malfunction
- Heated Exhaust Gas Oxygen Sensor - Application Chart
- Emissions/Engine Controls - Driveability Diagnosis
- Ignition Switch - Harness Connector Non-Mating
- Campaign - Alarm System Update
- Fuel System - Difficult or Slow Filling Fuel Tank
- Accelerator Cable - Service Procedures/Tips
- EEC IV - Self Test Codes and MIL Service Tips
- Overview
- Overview of Three Digit EEC-IV Self-Test Codes
- 1) Technician Not Familiar With Self-Test Code Output
- 2) Inadvertent Erasure of Continuous Memory Self-Test Codes
- 3) Concern Setting Continious Memory Code Isn't Present
- 4) Grounded STO/MIL Circuit
- 5) Engine Running In Hlos
- 6) Misinterpretation of MIL Bulb Check
- 7) MIL Flashes During Self-Test
- 8) Processor KAM Is Erased or Fails
- 9) Damaged Star Tester
- 10) KOEO Processor Ram Test Failed
- 11) Intermittent VSS Fault Detected In Wiggle Mode
- 12) IDM Pulswidth Not Recognized By Processor (EDIS Vehicles)
- 13) Intermittent Ignition System Fault
- 14) Intermittent Open STI Circuit
- 15) Power Lost to EEC Processor
- 16) Other Warning Lamps Mistaken For MIL
- 17) Development Testing /Wrong Processor Released to Production
- A/T - E4OD TCIL Flashing/DTC's 62/628/1728 Stored
- Exhaust System - Buzzing/Rattling Noise
- Diesel Engine - Hard Start/No Start Condition
- A/T - E4OD Shift Concerns/DTC's Set
- A/T - E4OD New Design Transmission Range Sensor
- Engine - Oil Leak at Valley Pan/Oil Pump
- Engine - Stalls When Coming to A Stop
- Diesel Engine - Diagnostic Guide
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Diesel Engine - Hesitates/Stalls/Lack of Power/Stumbles
- Fuel - Volatility Related Driveability Concerns