Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall 99V028000: Fuel Pump/Sender Assembly Wire Harness
- Recall - Fused Jumper Harness Installation
- Recall - Tire Size Designation Label Replacement
- Recall 95V037000: Tire Certification Label Incorrect
- Recall - Mini-Spare Tire Replacement
- Recall 97V204000: Drivetrain Structural Failure
- Recall - Accessory Power Circuit Relay Installation
- Recall 98E010000: Brake Rotor Cracking
- Recall 99V029000: Accessory Electrical Short Circuit
- Recall 94V239000: Rear Brake Line Fracture
- Customer Interest
- Air Conditioning - Musty/Mildew Type Odors
- Engine - Carbon Knock On Acceleration
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- A/C - Insufficient Cooling/ Compressor Failure
- A/C - Little or No Cooling
- Blower Motor - Chirping/Squeaking
- Cooling System - Thump Noise/Gauge Fluctuation
- Steering - Rapping or Clanging Noise
- Door Lock Cylinder - Loose in Replacement Door
- Rear Axle - Whine/Howl At Light Throttle
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- PCM - MIL ON/Code 124 Set
- Engine - Hard Starting/Long Crank/Stalling
- Engine - Lean Driveability Symptoms
- Accessory Drive Belt - Squeal or Hoot Noise
- Engine Block Heater - Coolant Leak
- Left Rear Tire - Rubs On Wheelhouse Inner Panel
- A Pillar/Door - Wind Noise
- Differential - Chatter On Turns
- Front Drive Axle - Fluid Leak From Vent
- Sliding Door Latch - Damaged or Misadjusted
- Windshield - Water Leaks
- Instrument Panel/Windows - Rattle/Buzz
- Rear View Mirror - Detaches From Windshield
- Exhaust System - Buzzing/Rattling Noise
- Engine - Noise/Vibration/No Crank/No A/T Engagement
- Speedometer/Odometer - (Programmable) Pointer Waiver
- A/T - Inadvertent Shift Interlock Disabling
- Steering Wheel - Clicking Noise Heard When Turning
- A/T - Torque Converter Slip/DTC 628/P0741 Set
- Chemicals,Additives
- Factory Modifications
- Labor/Parts Updates
- Seals, Gaskets
- Superceded Bulletins
- Paint - Codes/Cross References
- A/C - Musty and Mildew Type Odors
- A/C - Identification Of Non Approved Refrigerants
- Air Conditioning - Musty Odors
- A/C - Approved Flushing Procedures
- Blower Motor - Chirping/Squeaking At Low Speeds
- Blower Motor - Chirping or Squeaking Noise
- Frame - Rivet Replacement With Bolts, Service Tip
- Power Steering - Rapping or Clanging Sound
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Wire Harness - Terminal Repair And Wire Splice Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Repair
- Wire Harness - Terminal Repair Kit/Splice Procedure
- Wire Harness - New Terminal Repair Kit
- Brakes - Service Tips
- Brakes - Special Lubricant Requirements
- Brakes - Roughness/Vibration
- Brake Rotor - Hub Mounted Machining Equipment
- Brakes - Rotor/Drum Sanding Elimination
- Rear Axle - Whine or Howl During Light Throttle
- A/T - New Transmission Cooler Flusher/Service Tip
- Shift Interlock (BRAKE) - Inadvertent Disabling
- Brake Shift Interlock - Inadvertent Disabling
- Fuel Economy - Customer Expectations Vs. Vehicle Usage
- Fuel Economy - Expectations Versus Usage
- Speaker - Whining/Buzzing Noise
- Speakers - Whining/Buzzing Noise
- Fuel Pump - Buzz/Whine Through Radio Speakers
- Fuel Pump - Whine/Buzz Noise Heard In Speakers
- Fuel - Volatility Related Driveability Information
- PCM - Out Of Vehicle Reprogramming
- PCM - MIL ON/Flashing/Continuous Code 124
- Engine - Stall or Hard Start After 1 to 4 Hour Soak
- Engine - Long Cranking Time To Start/Stall
- Engine - Long Crank/Stall After Hot Soak
- Engine - Hard Start/Stall After 1 to 4 Hour Soak
- Exhaust System - Buzzing/Rattling Noises
- Exhaust System - Rattling/Buzzing Noise
- Heater Core - Repeated Failure
- A/T - Fluid Application Charts
- A/C - Refrigerant Filtering Tips
- A/C - Refrigerant Filtering Service Tips
- A/C System - Refrigerant Filtering Service Tips
- Air Conditioning - Lack of Cooling/Compressor Failure
- Wheels - Proper Lug Torque Procedures
- Brakes - Vibration Prevention Service tip
- Recycled Engine Coolant - Service Tip
- A/T - Transmission Fluid Usage Charts
- Automatic Transmission - Fluid Usage Charts
- A/C - R134A Tracer Dye Factory Installed
- A/C - Non Approved Refrigerants
- A/C - Approved/Alternate Refrigerants
- A/C - R134A Tracer Dye Installed At Factory
- A/C - Identification of Non-Approved Refrigerants
- A/C - Identifying Non-Approved Refrigerants
- A/C - Lack of Cooling/Compressor Failure
- All Technical Service Bulletins
- Vehicle - Towing Behind RVs Guidelines
- A/C System - Service TSB List
- Air Conditioning - Musty/Mildew Type Odors
- A/C - Filtering Refrigerant After Compressor Replacement
- Engine - Carbon Knock On Acceleration
- Electrical - New Terminal Grease Released For Service
- Throttle Position Sensor - Function and Diagnostic Tips
- Recall 99V028000: Fuel Pump/Sender Assembly Wire Harness
- Recall - Fused Jumper Harness Installation
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Brake and Rotor - Service Tips
- A/C - Insufficient Cooling/ Compressor Failure
- A/C - Little or No Cooling
- Blower Motor - Chirping/Squeaking
- A/C Evaporator Core - On Vehicle Leak Test Requirement
- Air Conditioning - Approved Flushing Procedures
- Cooling System - Thump Noise/Gauge Fluctuation
- Radiator - New Manufacturing Process
- Steering - Rapping or Clanging Noise
- Recall - Tire Size Designation Label Replacement
- Recall 95V037000: Tire Certification Label Incorrect
- Lug Nuts - Proper Installation/Torqueing Procedure
- Frame - Rivet Replacement with Bolts Service Tip
- Door Lock Cylinder - Loose in Replacement Door
- Recall - Mini-Spare Tire Replacement
- Recall 97V204000: Drivetrain Structural Failure
- Rear Axle - Whine/Howl At Light Throttle
- Torque Converter - Cleaning and Replacement Guidelines
- A/T - Cooler Flushing Service Tips
- A/T Torque Converter - Leak Test Procedure
- Hydraulic Clutch - Bleeding Procedure Service Tips
- Universal Joint - Greasable Design Availability
- Fuel Injectors - Non Warranty Reimbursement Testing
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- PCM - MIL ON/Code 124 Set
- Engine - Hard Starting/Long Crank/Stalling
- Mass Air Flow Sensor - Assembly Replacement
- Engine - Lean Driveability Symptoms
- Accessory Drive Belt - Squeal or Hoot Noise
- Recall - Accessory Power Circuit Relay Installation
- Air Bag Modules - Discolored/Marred Covers
- Brake Rotor - Machining Equipment/Warranty Information
- Brakes - Elimination Of Sanding Rotors And Drums
- Hub-Mount Brake Rotor Machining Equipment
- Recall 98E010000: Brake Rotor Cracking
- Engine Block Heater - Coolant Leak
- Temperature Gauge - Reads Low/Erratic
- Left Rear Tire - Rubs On Wheelhouse Inner Panel
- A Pillar/Door - Wind Noise
- Sheet Molding Composite - Body Repair
- Recall 99V029000: Accessory Electrical Short Circuit
- EEC IV - Self Test Codes and MIL Service Tips
- Overview
- Overview of Three Digit EEC-IV Self-Test Codes
- 1) Technician Not Familiar With Self-Test Code Output
- 2) Inadvertent Erasure of Continuous Memory Self-Test Codes
- 3) Concern Setting Continious Memory Code Isn't Present
- 4) Grounded STO/MIL Circuit
- 5) Engine Running In Hlos
- 6) Misinterpretation of MIL Bulb Check
- 7) MIL Flashes During Self-Test
- 8) Processor KAM Is Erased or Fails
- 9) Damaged Star Tester
- 10) KOEO Processor Ram Test Failed
- 11) Intermittent VSS Fault Detected In Wiggle Mode
- 12) IDM Pulswidth Not Recognized By Processor (EDIS Vehicles)
- 13) Intermittent Ignition System Fault
- 14) Intermittent Open STI Circuit
- 15) Power Lost to EEC Processor
- 16) Other Warning Lamps Mistaken For MIL
- 17) Development Testing /Wrong Processor Released to Production
- Differential - Chatter On Turns
- Front Drive Axle - Fluid Leak From Vent
- Sliding Door Latch - Damaged or Misadjusted
- Interior Door Trim Panel - Replacement Tip
- Windshield - Material Usage Procedure
- Windshield/Interior Glass - Fog/Film
- Windshield - Water Leaks
- Instrument Panel/Windows - Rattle/Buzz
- Rear View Mirror - Detaches From Windshield
- Rear View Mirror - Reattachment
- Paint - Procedure/Products For Plastic Service Parts
- Motor Oil - Viscosity Grade Recommendation
- Recycled Engine Coolant - Service Tips
- Engine Coolant - Propylene Glycol Recommendations
- Exhaust System - Buzzing/Rattling Noise
- Recall 94V239000: Rear Brake Line Fracture
- A/T - A4LD/4R44E/5R55E New Center Support
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - In Line Fluid Filter Kit
- A/T - Transmission Flush and Fill Tool Available
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Pump Damage After Overhaul
- A/T - Binding Condition In Park
- A/T - A4LD Malfunction Indicator Lamp Flashing, Code 24
- A/T - A4LD Bellhousing and Pump Interchange
- A/T - A4LD, 4R44E/4R55E Pump Interchangeability
- A/T - A4LD Support Ring Identification
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Engine - Noise/Vibration/No Crank/No A/T Engagement
- A/T - Mercon V ATF Usage
- Speedometer/Odometer - (Programmable) Pointer Waiver
- Engine - New Gasket Sealer
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Paint - Preparation Procedure And MSDS Information
- Paint - Iron Particle Removal
- A/T - Inadvertent Shift Interlock Disabling
- Electrical Diode - Identification and Replacement
- Steering Wheel - Clicking Noise Heard When Turning
- A/C - Release of R134a Fluorescent Dye
- A/C - Identification of Non Approved Refrigerants
- Air Conditioning - O Ring Removal Service Tip
- A/C O Ring - Availability and Applications
- A/C - New O Ring Applications
- Brakes - New Silicone Compound/Grease
- Brake Service - Service Tips
- Brakes - Vibration/Inspection Service Tips
- A/C - Oil Visible At Spring Lock Couplers
- Fuel - California Reformulated Gasoline
- Fuel - Volatility Related Driveability Concerns
- A/C - Adding Refrigerant Oil Service Tip
- A/C - Refrigerant Oil Refill Capacity
- Seat Leather - Cleaning Procedure Tips
- M/T - Mercon(R) V ATF Usage Information
- A/T - Torque Converter Slip/DTC 628/P0741 Set