Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall 00V355000: Heater/Defroster Malfunction
- Recall - Intake Manifold Replacement
- Recall 00V349000: Hood Striker Fracture/Failure
- Recall - Safety Belt Retractor Inspection/Replacement
- Recall - Park Brake Control Modification
- Overview
- Dealer Letter - October 2000
- Dealer Letter - November 2000
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Example Mustang Owner Guide
- Owner Letter
- Supplement #1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 1 - Attachment IV
- Supplement # 1 - Owner Letter
- Customer Interest
- Cooling System - Intake Manifold Gasket Leak
- Engine - Oil Leak From R/H Cylinder Head Gasket
- A/T Cooler - Fluid Leaks at Radiator
- Intake Manifold - Cross-Over Channel Coolant Seepage
- Driveline - Whining Noise On Coastdown
- M/T - Hard To Shift Into 1st or Reverse When Stopped
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- PCM - Hesitation Backfires When Cold
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Speedometer Defective,, 4X4 Lamp ON, DTCs P1635/P1639
- Hood - Difficult to Close
- Windshield Wipers - Operate While Switch is OFF
- Interior - Passenger Seat Squeaking Sound
- A/T - 4R70W Ticking Noise In 1ST Gear
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- A/T - Inadvertent Shift Interlock Disabling
- A/T - 4R70W Clunk Noise on 2nd to 1st Gear Downshift
- M/T - T45 Stuck In Reverse/Pops Out Of Reverse
- A/C - Heater Core Electrolysis/Leakage
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Factory Modifications
- Recommended Repairs
- Superceded Bulletins
- Rear Window Defroster - Inoperative
- Front Wipers - Operate While Switch is in OFF Position
- Front Wipers - Operate While Switch Is In Off Position
- Passive Antitheft System (PATS) - Diagnostics Tips
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- Restraint System - Seat Belts Slow to retract
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wiring Soldering/Crimping Tips
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- A/T - New Transmission Cooler Flusher/Service Tip
- Shift Interlock (BRAKE) - Inadvertent Disabling
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- Emissions - MIL ON/EVAP System DTC's Set
- PCM - DTC's P1635 or P1639 Set/4X4 Lamp ON
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- Engine - Oil Recommendations/Applications
- Ignition System - Engine Misfire Diagnostics Tips
- Ignition System - Engine Misfire Diagnostic Tips
- All Technical Service Bulletins
- A/C System - Diagnosis and Service Tips
- Driveability - Vacuum Leak Detection
- Aluminum Engine - New Cleaners/Service Tips
- Cooling System - Intake Manifold Gasket Leak
- Steering - Correct Placement of P/S Pump Bolt/Washer
- Recall 00V355000: Heater/Defroster Malfunction
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- Engine - Oil Leak From R/H Cylinder Head Gasket
- A/T Cooler - Fluid Leaks at Radiator
- Recall - Intake Manifold Replacement
- Intake Manifold - Cross-Over Channel Coolant Seepage
- Campaign - Intake Manifold Extended Warranty Coverage
- Wheels/Tires - Road Force Measurement Equipment
- Driveline - Whining Noise On Coastdown
- A/T - Cooler Flushing Service Tips
- Clutch Pedal - Vibration Heard or Felt
- M/T - Hard To Shift Into 1st or Reverse When Stopped
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- Emissions/Engine Controls - Driveability Diagnosis
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- PCM - Hesitation Backfires When Cold
- Engine Controls - General PCM Programming Procedures
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- Restraints - Seat Belt Stop Button Service
- Engine Head Gasket - Approved Replacement Procedures
- PATS System - Diagnostic Service Tips
- EVAP - DTC's P0442/P0455/MIL ON/No Driveability Concerns
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Speedometer Defective,, 4X4 Lamp ON, DTCs P1635/P1639
- Engine Controls - MIL ON/Lean DTC Service Tips
- Hood - Difficult to Close
- Recall 00V349000: Hood Striker Fracture/Failure
- Windshield Wipers - Operate While Switch is OFF
- Interior - Passenger Seat Squeaking Sound
- Recall - Safety Belt Retractor Inspection/Replacement
- Body - Exterior Mirror Glass/Motor Service Tips
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- A/T - 4R70W Ticking Noise In 1ST Gear
- A/T - 4R70W Green Service Tag Service procedure
- A/T - In Line Fluid Filter Kit
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Electrical - Wiring Soldering/Crimping Service Tips
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Cruise Control - Diagnostic Updates
- Keyless Entry System - Service Tips
- Locks - Lock Service Packages Available
- A/T - Inadvertent Shift Interlock Disabling
- Seat Belts - Warning System Operation
- A/C - Identification of Non Approved Refrigerants
- A/T - 4R70W Clunk Noise on 2nd to 1st Gear Downshift
- M/T - T45 Stuck In Reverse/Pops Out Of Reverse
- A/T - 4R70W Needle Bearing/Race Kit Service Tip
- Brakes - Vibration/Inspection Service Tips
- Recall - Park Brake Control Modification
- Overview
- Dealer Letter - October 2000
- Dealer Letter - November 2000
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Example Mustang Owner Guide
- Owner Letter
- Supplement #1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 1 - Attachment IV
- Supplement # 1 - Owner Letter
- Engine - Reman Engine Head Gasket Identification
- A/C - Heater Core Electrolysis/Leakage
- Keyless Entry - Keypad Diagnostics
- Steering - Mercon V(R) Fluid Usage
- M/T - Mercon(R) V ATF Usage Information
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Engine - Spark Plug Hole Thread Repair Procedure