Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall - Firestone Tire Recall Supplement
- Recall 00V394000: Hood Striker Fracture/Failure
- Recall 01V227001: Seat Belt Buckle Defect
- Recall - Outboard Seats Belt May Not Fully Latch
- Recall 07V336000: Cruise Control Fire Hazard
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Recall 09V399000: Cruise Control Deactivation Switch
- Recall - Cruise Control Deactivation Switch Overheating
- Customer Interest
- Fuel Pump - Whine Heard Through Radio Speakers
- Fuel Pump/Sender - Erratic Gauge Operation
- Audio System - Whining/Buzzing Noise From Speakers
- Brakes/Steering - Pull to The Left or Right Upon Braking
- Exhaust System/Engine Controls - Idle Boom/Rough Idle
- Driveline - Thump/Bump on Acceleration
- M/T Clutch - Hooting/Eeking/Moaning Noise
- Clutch - Pedal Stays On Floor/Does Not Disengage
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- Engine Controls - No Start/Hard Start/Rough Idle
- Engine - Inability to Reach Wide Open Throttle
- Electrical - Water Intrusion Into Connectors
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- A/T - No 2nd, 3rd Gear/No Engine Braking/DTC's Set
- Restraints - Seat Belts Slow to Retract
- Fog Lamps - Moisture/Condensation Inside
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- A/T - Inadvertent Shift Interlock Disabling
- Interior - Interior Door Pull Handle Loose
- A/T - 5R44E/5R55E Fluid Leak at Servo Cover
- Air Bag System - Warning Lamp ON/DTC's B1877 or B1881
- Interior - Driver/Passenger Seat Track Rattles
- Power Windows - Chatter/Binding When Operating
- Tailgate - Squeaking/Binding Condition
- Quarter Trim Panel - Poor Fit/No Mounting Holes
- Body - Tonneau Cover Latches/Locks/Struts Inoperable
- A/C - Heater Core Electrolysis/Leakage
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Superceded Bulletins
- Recall - Speed Control Deactivation Switch Defects
- Recall - Cruise Control Switch Circuit Defect
- 05S28S12 - 08/20/07
- 05S28S11 - 08/03/07
- Body - Aluminum Corrosion Service Tip
- Interior - Front Seat Tracks Rattle
- Interior - Seat Belt Pretensioner DTC's B1877/B1881
- Restraint System - Seat Belts Slow to retract
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wiring Soldering/Crimping Tips
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- Driveshaft - Thump/Bump on Acceleration/Braking
- A/T - No 2nd/3rd Gear/Possible DTC's Set
- A/T - Slipping Shifts/Delayed Engagements/DTC's Set
- Shift Interlock (BRAKE) - Inadvertent Disabling
- Instruments - Fuel Gauge, Inaccurate Readings
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- Emissions - MIL ON, DTC's P0401, P1400 or P1401
- Emissions - MIL ON/DTC's Set/Driveability Concerns
- Emissions - MIL ON/EVAP System DTC's Set
- PCM - DTC's P1635 or P1639 Set/4X4 Lamp ON
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Engine - Crankshaft Pulley Bolt Service Precaution
- Engine - Crankshaft Pulley Bolt Service Precautions
- Engine - Crankshaft Pulley Bolt Removal Precaution
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- Brakes - Pull to Left or Right
- A/T - Slipping/Delayed Engagement/DTC P1762 Set
- Engine - Oil Recommendations/Applications
- Emissions- DTC's Set/MIL ON/Driveability Concerns
- All Technical Service Bulletins
- Driveability - Vacuum Leak Detection
- Fuel Pump - Whine Heard Through Radio Speakers
- Fuel Pump/Sender - Erratic Gauge Operation
- Audio System - Whining/Buzzing Noise From Speakers
- Brakes/Steering - Pull to The Left or Right Upon Braking
- Exhaust System/Engine Controls - Idle Boom/Rough Idle
- Warranty - Guide Supplement
- Information
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor Information
- Attachment III - Technical Information
- Owner Letter
- Supplement # 1 - Information
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 1 - Owner Letter
- Supplement # 2 - Information
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment I
- Supplement # 2 - Attachment II
- Supplement # 2 - Attachment III
- Supplement # 2 - Apology Letter
- Supplement # 2 - Owner Letter
- Recall - Firestone Tire Recall Supplement
- Body - Frame Mounted Front Bumper Service
- Driveline - Thump/Bump on Acceleration
- M/T Clutch - Hooting/Eeking/Moaning Noise
- A/T - Cooler Flushing Service Tips
- Clutch - Pedal Stays On Floor/Does Not Disengage
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- Emissions/Engine Controls - Driveability Diagnosis
- Emissions - MIL ON/Driveability Issues/DTC's Set
- Engine Controls - No Start/Hard Start/Rough Idle
- Engine Controls - General PCM Programming Procedures
- Engine - Inability to Reach Wide Open Throttle
- Restraints - Seat Belt Stop Button Service
- Electrical - Water Intrusion Into Connectors
- PATS System - Diagnostic Service Tips
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- A/T - No 2nd, 3rd Gear/No Engine Braking/DTC's Set
- Engine Controls - MIL ON/Lean DTC Service Tips
- Recall 00V394000: Hood Striker Fracture/Failure
- Restraints - Seat Belts Slow to Retract
- Body - Rear Bolt-In Glass Installation/Removal Tips
- Body - Exterior Mirror Glass/Motor Service Tips
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- A/T - 'Prior To Repair' Tag Procedure Notice
- A/T - In Line Fluid Filter Kit
- Fog Lamps - Moisture/Condensation Inside
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Electrical - Wiring Soldering/Crimping Service Tips
- Cruise Control - Diagnostic Updates
- Keyless Entry System - Service Tips
- A/T - Inadvertent Shift Interlock Disabling
- Interior - Interior Door Pull Handle Loose
- A/T - 5R44E/5R55E Fluid Leak at Servo Cover
- Seat Belts - Warning System Operation
- Air Bag System - Warning Lamp ON/DTC's B1877 or B1881
- Interior - Driver/Passenger Seat Track Rattles
- Power Windows - Chatter/Binding When Operating
- Recall 01V227001: Seat Belt Buckle Defect
- Recall - Outboard Seats Belt May Not Fully Latch
- Tailgate - Squeaking/Binding Condition
- Steering/Suspension - Alignment Procedure Revision
- Quarter Trim Panel - Poor Fit/No Mounting Holes
- Body - Bed Extender Component Replacement Tips
- Body - Tonneau Cover Latches/Locks/Struts Inoperable
- Engine - Reman Engine Head Gasket Identification
- A/C - Heater Core Electrolysis/Leakage
- Engine Crankshaft - Pulley Bolt Service Precautions
- A/T - 5R44E/5R55E Part Level Change/Compatibility
- Body - Aluminum Body Panels - Corrosion
- Keyless Entry - Keypad Diagnostics
- Steering - Mercon V(R) Fluid Usage
- M/T - Mercon(R) V ATF Usage Information
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Recall 07V336000: Cruise Control Fire Hazard
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Recall 09V399000: Cruise Control Deactivation Switch
- Recall - Cruise Control Deactivation Switch Overheating