Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Generals
- Safety
- Recall 12V195000: Rear Axle Reinforcement Bracket
- Recall 12V194000: Front Subframe Lower Control Arm Bracket
- Recall 12V193000: Rear Axle Beam Reinforcement
- Recall - Rear Subframe/Control Arm Mount/Body Mount Repair
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Overview
- Table of Contents
- I. Repair Flowchart
- II. Subframe Rear Body Mount Inspection
- III. Lower Control Arm (LCA) Rear Attachment Flange Inspection
- IV. Subframe Front LCA Reinforcement Bracket and Rear Body Mount Attachment Reinforcement Bracket Installation
- V. Subframe LCA Flange Cutting
- VI. Digital Imaging Instructions
- VII. Subframe Removal and Replacement
- Attachment IV - Dealer Q and A
- Recall - Rear Axle Inspection And Repair
- Recall 11V030000: Front Lower Control Arm Separation
- Recall - Revised Rear Auxiliary Blower Wiring Harness
- Recall 01V262000: Heater Blower Motor Circuit Protection
- Recall 01V207000: Floor Mat/Accelerator Interference
- Recall - Accelerator Pedal Hang's Up On Floor Mat
- Recall - Personal Safety (Restraint) System Defect
- Overview
- Dealer Letter
- Demonstration/Deliver Hold
- Demonstration/Deliver Hold - Dealer Letter
- Demonstration/Deliver Hold - Attachment I
- Demonstration/Deliver Hold - Attachment II
- Demonstration/Deliver Hold - Attachment III
- Demonstration/Deliver Hold - Attachment IV
- Demonstration/Deliver Hold - Attachment V
- Demonstration/Deliver Hold - Owner Letter
- Recall 00V412000: RCM Improperly Assembled
- Recall - Front Crash Sensor Inspection
- Recall - Defective Wiper Motor Gear Cover Assembly
- Recall 02V072000: Rear Lighting/Electrical Malfunction
- Recall 01V261000: Windshield Wiper Defect
- Recall 03V459000: Child Restraint Non-Compliance
- Recall - Electrical Connector/Sealer Strip Defect
- Recall 00V270000: Restraint Module Defect
- Recall 01V227001: Seat Belt Buckle Defect
- Recall - Outboard Seats Belt May Not Fully Latch
- Recall - 2nd and 3rd Row Seat to Floor Latch Defect
- Recall - Rear A/C Blower Wiring
- Recall 09V399000: Cruise Control Deactivation Switch
- Recall 10V385000: Rear Axle Reinforcement Installation
- Customer Interest
- Brakes - Adjustable Brake Pedal Adjustment Inoperative
- A/T - TCC Not Engaging, DTCs P0741 or P1744
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Suspension (Front) - Grunting/Popping Noise on Turns
- Steering Rack - Fluid Leaks
- Engine Controls/Fuel System - MIL ON/DTC's P0171/P0174
- Suspension - Pop/Clunk Noise From Front Springs
- Interior - Coat Hook/Lamp Loose In Headliner
- Interior - Headliner Creased Near A-Pillar
- Interior - Headliner Sagging Near Rear Hatch
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - Spark Knock on Acceleration
- Engine Controls, A/T - Various Driveability Issues/DTC's
- ABS Module - Low Tire Warning Indicator ON/No Codes Set
- Air Bag Lamp - Intermittently ON/DTC's Stored in Memory
- Restraint System - SRS Lamp ON/DTC B1342 Set
- Restraint System - Air Bag Lamp ON/DTC B2290 Set
- Body - Roof Ditch Material Cracking
- Overview
- Service Procedure
- Information
- Application Tips & Steps Common to All Repairs
- AKZO - SIKKENS - National Rule
- AKZO - SIKKENS Rule 45 and 1151
- BASF - R-M
- BASF - Glasurit
- PPG Deltron System
- PPG Global System
- Spies Hecker(R) Low VOC Recommendation
- Spies Hecker(R) National Rule Recommendation
- Standox(R) Low VOC Recommendation
- Standox(R) National Rule Recommendation
- Dupont California Recommendation 800-3DuPont
- Dupont National Rule Recommendation 800-3DuPont
- Sherwin-Williams National Rule Recommendation
- Sherwin-Williams Low VOC Recommendation
- EVAP System - MIL ON/ Possible DTC's Set
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Body - Corrosion At Bottom of Door or Tailgate
- Restraints - Seat Belts Slow to Retract
- Steering - `Grunt' Noise While Turning
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Remote Keyless Entry - Unknown Key Code Condition
- Fuel System - Fuel Tank is Slow to Fill
- A/T - Inadvertent Shift Interlock Disabling
- Body - Cowl Panel Grille Breakage
- Parking Assist System - False Warnings
- A/C - Heater Core Electrolysis/Leakage
- A/T - Erratic Fluid Level Readings/Filler Tube Leaks
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Engine - Spark Knock on Light Load/Acceleration
- Superceded Bulletins
- 10S13S1 - 09/15/10
- 10S13S9 - 05/13/11
- 11S16 - 01/26/11
- 10S13S5 - 12/23/10
- 10S13S4 - 11/30/10
- 10S13S3 - 10/30/10
- 02M01S3 - 01/01/04
- 02M01S2 - 01/01/04
- 02M01 - 01/01/04
- 02M01 - 11/01/03
- 02M01S5 - 04/01/04
- Rear Window Defroster - Inoperative
- Body - Power Sliding Door Diagnostic Tips
- Parking Assist System - False Tone Activation
- Parking Assist System - False Activation
- Rear Defroster/Integral Antenna - Diagnose and Repair
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- SRS - DTC B1342 (Restraints Control Module Fault)
- Restraint System - Seat Belts Slow to retract
- Air Bag System - Advanced Restraint Deployment Strategy
- Recall - Front Subframe/Control Arm Flange Corrosion
- Recall - Front Lower Control Arm/Rear Body Mount
- 11S16S5 - 06/03/11
- Recall - Front Control Arm/Subframe Flange Corrosion
- Recall - Control Arm Bracket/Body Mount Inspect/Repair
- Recall - Front Lower Control Arm/Body Mount Corrosion
- Recall - Potential Front Lower Control Arm Separation
- Recall - Inspect/Repair Rear Axle
- Recall - Rear Axle Corrosion Inspection/Repair
- Recall - Inspection/Repair Of Rear Axle
- Recall - Rear Axle Corrosion Inspection and Repair
- Recall - Rear Axle Inspection and Repair
- 10S13 - 08/26/10
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wiring Soldering/Crimping Tips
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- Shift Interlock (BRAKE) - Inadvertent Disabling
- A/T - Erratic Fluid Level Reading/Leaks at Dipstick Tube
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- Recall - EGR Pressure Sensor Replace/Warranty Extension
- Emissions - MIL ON, DTC's P0401, P1400 or P1401
- Emissions - MIL ON/Possible DTC's/Driveability Issues
- Emissions - MIL ON/DTC's Set/Driveability Concerns
- EVAP - MIL ON, DTCs P0442, P0455, P0456, P0457
- Emissions - MIL ON/EVAP System DTC's Set
- Engine Controls - Engine/Transmission Driveability Issue
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- Engine - Oil Recommendations/Applications
- Emissions- DTC's Set/MIL ON/Driveability Concerns
- All Technical Service Bulletins
- Recall 12V195000: Rear Axle Reinforcement Bracket
- Recall 12V194000: Front Subframe Lower Control Arm Bracket
- Recall 12V193000: Rear Axle Beam Reinforcement
- Recall - Rear Subframe/Control Arm Mount/Body Mount Repair
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Overview
- Table of Contents
- I. Repair Flowchart
- II. Subframe Rear Body Mount Inspection
- III. Lower Control Arm (LCA) Rear Attachment Flange Inspection
- IV. Subframe Front LCA Reinforcement Bracket and Rear Body Mount Attachment Reinforcement Bracket Installation
- V. Subframe LCA Flange Cutting
- VI. Digital Imaging Instructions
- VII. Subframe Removal and Replacement
- Attachment IV - Dealer Q and A
- Recall - Rear Axle Inspection And Repair
- Brakes - Adjustable Brake Pedal Adjustment Inoperative
- Recall 11V030000: Front Lower Control Arm Separation
- Recall - Revised Rear Auxiliary Blower Wiring Harness
- Recall 01V262000: Heater Blower Motor Circuit Protection
- A/C System - Diagnosis and Service Tips
- A/T - TCC Not Engaging, DTCs P0741 or P1744
- Driveability - Vacuum Leak Detection
- Aluminum Engine - New Cleaners/Service Tips
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Suspension (Front) - Grunting/Popping Noise on Turns
- Steering Rack - Fluid Leaks
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- Engine Controls/Fuel System - MIL ON/DTC's P0171/P0174
- Suspension - Pop/Clunk Noise From Front Springs
- Wheels/Tires - Road Force Measurement Equipment
- Warranty - Guide Supplement
- Information
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor Information
- Attachment III - Technical Information
- Owner Letter
- Supplement # 1 - Information
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 1 - Owner Letter
- Supplement # 2 - Information
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment I
- Supplement # 2 - Attachment II
- Supplement # 2 - Attachment III
- Supplement # 2 - Apology Letter
- Supplement # 2 - Owner Letter
- Interior - Coat Hook/Lamp Loose In Headliner
- Interior - Headliner Creased Near A-Pillar
- Interior - Headliner Sagging Near Rear Hatch
- A/T - Cooler Flushing Service Tips
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - Spark Knock on Acceleration
- Engine Controls, A/T - Various Driveability Issues/DTC's
- Emissions/Engine Controls - Driveability Diagnosis
- Emissions - MIL ON/Driveability Issues/DTC's Set
- Recall - Tube Mounted EGR Pressure Sensor Defect
- ABS Module - Low Tire Warning Indicator ON/No Codes Set
- Battery - Drain Diagnosis Tips
- Engine Controls - General PCM Programming Procedures
- Recall 01V207000: Floor Mat/Accelerator Interference
- Recall - Accelerator Pedal Hang's Up On Floor Mat
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- Restraints - Seat Belt Stop Button Service
- Recall - Personal Safety (Restraint) System Defect
- Overview
- Dealer Letter
- Demonstration/Deliver Hold
- Demonstration/Deliver Hold - Dealer Letter
- Demonstration/Deliver Hold - Attachment I
- Demonstration/Deliver Hold - Attachment II
- Demonstration/Deliver Hold - Attachment III
- Demonstration/Deliver Hold - Attachment IV
- Demonstration/Deliver Hold - Attachment V
- Demonstration/Deliver Hold - Owner Letter
- Recall 00V412000: RCM Improperly Assembled
- Recall - Front Crash Sensor Inspection
- Air Bag Lamp - Intermittently ON/DTC's Stored in Memory
- Restraint System - SRS Lamp ON/DTC B1342 Set
- Restraint System - Air Bag Lamp ON/DTC B2290 Set
- Recall - Defective Wiper Motor Gear Cover Assembly
- Engine Head Gasket - Approved Replacement Procedures
- Body - Roof Ditch Material Cracking
- Overview
- Service Procedure
- Information
- Application Tips & Steps Common to All Repairs
- AKZO - SIKKENS - National Rule
- AKZO - SIKKENS Rule 45 and 1151
- BASF - R-M
- BASF - Glasurit
- PPG Deltron System
- PPG Global System
- Spies Hecker(R) Low VOC Recommendation
- Spies Hecker(R) National Rule Recommendation
- Standox(R) Low VOC Recommendation
- Standox(R) National Rule Recommendation
- Dupont California Recommendation 800-3DuPont
- Dupont National Rule Recommendation 800-3DuPont
- Sherwin-Williams National Rule Recommendation
- Sherwin-Williams Low VOC Recommendation
- Recall 02V072000: Rear Lighting/Electrical Malfunction
- PATS System - Diagnostic Service Tips
- EVAP System - MIL ON/ Possible DTC's Set
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Engine Controls - MIL ON/Lean DTC Service Tips
- Recall 01V261000: Windshield Wiper Defect
- Body - Corrosion At Bottom of Door or Tailgate
- Restraints - Seat Belts Slow to Retract
- Recall 03V459000: Child Restraint Non-Compliance
- Body - Exterior Mirror Glass/Motor Service Tips
- Recall - Electrical Connector/Sealer Strip Defect
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- Steering - `Grunt' Noise While Turning
- A/T - 'Prior To Repair' Tag Procedure Notice
- Campaign - A/T AX4N Inspection/Replacement
- Recall 00V270000: Restraint Module Defect
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Electrical - Wiring Soldering/Crimping Service Tips
- Cruise Control - Diagnostics Updates
- Remote Keyless Entry - Unknown Key Code Condition
- Keyless Entry System - Service Tips
- Fuel System - Fuel Tank is Slow to Fill
- A/T - Inadvertent Shift Interlock Disabling
- Accessories - Trailer Tow Harness Kit Service Tip
- Seat Belts - Warning System Operation
- Body - Cowl Panel Grille Breakage
- Recall 01V227001: Seat Belt Buckle Defect
- Recall - Outboard Seats Belt May Not Fully Latch
- Recall - 2nd and 3rd Row Seat to Floor Latch Defect
- Recall - Rear A/C Blower Wiring
- Parking Assist System - False Warnings
- Body - Power Sliding Door Operation/Diagnostics
- Engine - Reman Engine Head Gasket Identification
- A/C - Heater Core Electrolysis/Leakage
- Advanced Restraint System - Operational Characteristics
- Keyless Entry - Keypad Diagnostics
- A/T - Erratic Fluid Level Readings/Filler Tube Leaks
- Steering - Mercon V(R) Fluid Usage
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Engine - Spark Knock on Light Load/Acceleration
- Recall 09V399000: Cruise Control Deactivation Switch
- Recall 10V385000: Rear Axle Reinforcement Installation