Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Accessory Drive Belt - Slips Off Pulley When Wet
- Exhaust System - Leaks/Noise
- Interior - Headliner Sags in Rear
- M/T - Hard To Shift Into 1st or Reverse When Stopped
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Drivetrain - Limited Slip Differential Chatter
- Interior - Passenger Seat Squeaking Sound
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Convertible Top Boot - Poor Fit
- Interior - 'A' Pillar Area Wind Noise
- A/T - Inadvertent Shift Interlock Disabling
- M/T - TR36550 5spd Jumps Out of Gear/ Gear Clash
- Steering - Squeak/Creak Noise While Turning
- A/C - Instrument Panel Vents Rattle
- A/C - Heater Core Electrolysis/Leakage
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Engine - Spark Knock on Light Load/Acceleration
- Superceded Bulletins
- 02M01S3 - 01/01/04
- 02M01S2 - 01/01/04
- 02M01S5 - 04/01/04
- Rear Window Defroster - Inoperative
- Rear Defroster/Integral Antenna - Diagnose and Repair
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- Restraint System - Seat Belts Slow to retract
- Steering - Leather Coming Loose From Steering Wheel
- Steering - Squeak/Creak Noise on Turns
- Electrical - Wiring Soldering/Crimping Tips
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- Drivetrain - L/S Differential Chatter on Low Speed Turns
- Drivetrain - L/S Rear Axle Shudder/Chatter
- Engine Controls - General PCM Reprogramming Procedures
- Recall - EGR Pressure Sensor Replace/Warranty Extension
- Emissions - MIL ON, DTC's P0401, P1400 or P1401
- Emissions - MIL ON/Possible DTC's/Driveability Issues
- Emissions - MIL ON/DTC's Set/Driveability Concerns
- Emissions - MIL ON/EVAP System DTC's Set
- PCM - DTC's P1635 or P1639 Set/4X4 Lamp ON
- Exhaust System - Leaks From R/H Exhaust Pipe
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- Cooling System - 'Premium Gold Coolant' Service Tips
- Ignition System - Engine Misfire Diagnostics Tips
- Ignition System - Engine Misfire Diagnostic Tips
- Emissions- DTC's Set/MIL ON/Driveability Concerns
- All Technical Service Bulletins
- A/C System - Diagnosis and Service Tips
- Aluminum Engine - New Cleaners/Service Tips
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- Accessory Drive Belt - Slips Off Pulley When Wet
- Exhaust System - Leaks/Noise
- Wheels/Tires - Road Force Measurement Equipment
- Interior - Headliner Sags in Rear
- A/T - Cooler Flushing Service Tips
- M/T - Hard To Shift Into 1st or Reverse When Stopped
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- Emissions - MIL ON/Driveability Issues/DTC's Set
- Recall - Tube Mounted EGR Pressure Sensor Defect
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- Engine Controls - General PCM Programming Procedures
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- A/C - Rear Window Defroster/Antenna Diagnosis/Repair
- Restraints - Seat Belt Stop Button Service
- Engine - Oil Level Indicator Markings
- Engine Head Gasket - Approved Replacement Procedures
- Sheet Metal (Primed) - Preparation Procedure
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Engine Controls - MIL ON/Lean DTC Service Tips
- Drivetrain - Limited Slip Differential Chatter
- Interior - Passenger Seat Squeaking Sound
- Body - Exterior Mirror Glass/Motor Service Tips
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- Cooling System - Premium Gold Coolant Service Info
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Engine - Oil System Priming Procedures
- Electrical - Wiring Soldering/Crimping Service Tips
- Cruise Control - Diagnostic Updates
- Convertible Top Boot - Poor Fit
- Keyless Entry System - Service Tips
- Interior - 'A' Pillar Area Wind Noise
- Paint - Plastic Bumper/Fascia Service Tips
- Paint - Hood Pin Holes and/or Paint Delamination
- A/T - Inadvertent Shift Interlock Disabling
- M/T - TR36550 5spd Jumps Out of Gear/ Gear Clash
- A/T - 4R70W Needle Bearing/Race Kit Service Tip
- Steering - Squeak/Creak Noise While Turning
- A/C - Instrument Panel Vents Rattle
- Engine - Reman Engine Head Gasket Identification
- A/C - Heater Core Electrolysis/Leakage
- Keyless Entry - Keypad Diagnostics
- Steering - Mercon V(R) Fluid Usage
- M/T - Mercon(R) V ATF Usage Information
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Engine - Spark Knock on Light Load/Acceleration