Body - Rear Power Windows Slow/Stick/Bind
TSB 08-19-409/29/08
REAR POWER WINDOWS OPERATE SLOW / BIND /
STICK - BUILT ON OR BEFORE 10/8/2007
FORD:
2008 Expedition
LINCOLN:
2008 Navigator
This article supersedes TSB 08-13-4 to update the Service Labor Times.
ISSUE
Some 2008 Expedition and Navigator vehicles built on or before 10/8/2007 may exhibit rear power windows that operate slow or stick I bind when operating.
ACTION
Follow the Service Procedure steps to correct the condition.
SERVICE PROCEDURE
1. Verify the power window sticks I binds or is slow by visual inspection.
2. Replace the rear door glass top run for the affected window. It will be necessary to remove the door glass prior to glass run removal per Work Shop Manual (WSM), Section 501-11.
3. Inspect the outer glass weatherstrip while door panel is off for correct positioning. Incorrect positioning could cause a binding concern due to excessive pressure on window.
a. Correct positioning of the outer glass weatherstrip would have the inside lip sitting flush against the inner door sheet metal.
b. No gaps would be felt between the outer glass weatherstrip and inner door sheet metal.
c. Make sure the four (4) retaining tabs are aligned and inserted correctly in the retaining holes.
d. Replace the outer glass weatherstrip if retaining tabs do not seat or the outer glass weatherstrip does not stay in position, refer to WSM, Section 501-11 Glass, Frames and Mechanisms.
4. Recheck power window operation.
Parts Block
WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.
OPERATION DESCRIPTION TIME
081904A 2008 Expedition, Navigator 0.7 Hr.
Built On Or Before
10/8/2007: Replace The
Rear Door Top Glass Run
And, Outer Glass
Weatherstrip If Necessary
Includes Time To Remove
And Install Door Glass And
Inspections: One Rear
Door (Do Not Use With
27406B, 27406B14,
27406B12, 21456A)
081904B 2008 Expedition, Navigator 1.3 Hrs.
Built On Or Before
10/8/2007: Replace The
Rear Door Top Glass Run
And, Outer Glass
Weatherstrip If Necessary
Includes Time To Remove
And Install Door Glass And
Inspections: Both Rear
Doors (Do Not Use With
27406B, 27406B14
27406B12, 21456A)
DEALER CODING
CONDITION
BASIC PART NO. CODE
7825766 07
Disclaimer