Operation CHARM: Car repair manuals for everyone.

A/C - Large Side To Side Temperature Differences

TSB 09-12-15

06/29/09

LARGE TEMPERATURE DIFFERENCES - BUILD
BEFORE 11/6/2008

FORD:
2008-2009 F-Super Duty

ISSUE
Some 2008-2009 F-Super Duty vehicles with a build date before 1 1/06/08, and equipped with DATC (Dual Automatic Temperature Control) may exhibit a side-to-side temperature difference greater than 15 degrees Fahrenheit (8.3 degrees Celsius). A temperature difference of less than 15 degrees Fahrenheit (8.3 degrees Celsius) would be considered normal and no repair attempt should be made. Also, it is not necessary to replace the EATC control head or the HVAC.

If equipped with manual climate control, vehicles may exhibit periods where the cabin temperature cannot be maintained with the control knob. Some customers may also complain the heat cannot be reduced without rotating the control knob well into the Cool/Blue range.

ACTION
Follow the Service Procedure steps to correct the condition.

SERVICE PROCEDURE

Check Actuator Activity:

DATC systems may be monitored with the IDS PID ($9910 and $9911 ). Manual A/C systems may be observed through the right side of the instrument panel with the glove compartment door positioned downward.

Erratic PID activity or an actuator that appears to be erratically hunting for correct position during the condition should be replaced. Refer to Workshop Manual, Section 412-01, for removal and installation details.

The ignition key must be off when replacing the actuator, energizing the actuator before installation on the HVAC case will cause the part to become mis-positioned and correct orientation will be lost. Incorrect actuator operation may result.





Parts Block

WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are determined by the identified causal part.

OPERATION DESCRIPTION TIME

091215A 2008-2009 F-Super Duty 1.1 Hrs.
With Manual Climate
Control: Replace The
Actuator Motor Assembly
Includes Time For
Diagnosis (Do Not Use
With Any Other Labor
Operations)

091215B 2008-2009 F-Super Duty 1.2 Hrs.
With Dual Electronic
Automatic Temperature
Control (DEATC): Replace
The Right Actuator Motor
Assembly Includes Time
For Diagnosis; Depower
And Repower
Supplemental Restraint
System (Do Not Use With
Any Other Labor
Operations)

091215C 2008-2009 F-Super Duty 3.0 Hrs.
With Dual Electronic
Automatic Temperature
Control (DEATC): Replace
The Left Actuator Motor
Assembly Includes Time
For Diagnosis; Depower
And Repower
Supplemental Restraint
System; Recover,
Evacuate And, Charge The
A/C System; Remove And
Install The Evaporator
Core Housing (Do Not Use
With Any Other Labor
Operations)

091215D 2008-2009 F-Super Duty 3.1 Hrs.
With Dual Electronic
Automatic Temperature
Control (DEATC): Replace
The Right And Left
Actuator Motor Assemblies
Includes Time For
Diagnosis; Depower And
Repower Supplemental
Restraint System; Recover,
Evacuate And, Charge The
A/C System; Remove And
Install The Evaporator
Core Housing (Do Not Use
With Any Other Labor
Operations)

091215E 2008-2009 F-Super Duty 1.2 Hrs.
6.4L With Dual Electronic
Automatic Temperature
Control (DEATC): Replace
The Right Actuator Motor
Assembly Includes Time
For Diagnosis; Depower
And Repower
Supplemental Restraint
System (Do Not Use With
Any Other Labor
Operations)

091215F 2008-2009 F-Super Duty 3.9 Hrs.
6.4L With Dual Electronic
Automatic Temperature
Control (DEATC): Replace
The Left Actuator Motor
Assembly Includes Time
For Diagnosis; Depower
And Repower
Supplemental Restraint
System; Recover,
Evacuate And, Charge The
A/C System; Remove And
Install The Evaporator
Core Housing (Do Not Use
With Any Other Labor
Operations)

091215G 2008-2009 F-Super Duty 4.0 Hrs.
6.4L With Dual Electronic
Automatic Temperature
Control (DEATC): Replace
The RIGHT And Left
Actuator Motor Assemblies
Includes Time For
Diagnosis; Depower And
Repower Supplemental
Restraint System; Recover,
Evacuate And, Charge The
A/C System; Remove And
Install The Evaporator
Core Housing (Do Not Use
With Any Other Labor
Operations)

091215H 2008-2009 F-Super Duty 2.1 Hrs.
6.4L With Dual Electronic
Automatic Temperature
Control (DEATC) And
Auxiliary Electric Heat:
Replace The Right
Actuator Motor Assembly
Includes Time For
Diagnosis; Depower And
Repower Supplemental
Restraint System; Remove
And Install Instrument
Panel (Do Not Use With
Any Other Labor
Operations)

091215J 2008-2009 F-Super Duty 4.0 Hrs.
6.4L With Dual Electronic
Automatic Temperature
Control (DEATC) And
Auxiliary Electric Heat:
Replace The Left Actuator
Motor Assembly Includes
Time For Diagnosis;
Depower And Repower
Supplemental Restraint
System; Recover,
Evacuate And, Charge The
A/C System; Remove And
Install The Evaporator
Core Housing (Do Not Use
With Any Other Labor
Operations)

091215K 2008-2009 F-Super Duty 4.0 Hrs.
6.4L With Dual Electronic
Automatic Temperature
Control (DEATC) And
Auxiliary Electric Heat:
Replace The RIGHT And
LEFT Actuator Motor
Assemblies Includes Time
For Diagnosis; Depower
And Repower
Supplemental Restraint
System; Recover,
Evacuate And, Charge The
A/C System; Remove And
Install The Evaporator
Core Housing (Do Not Use
With Any Other Labor
Operations)

DEALER CODING
CONDITION
BASIC PART NO. CODE
19E616 42





Disclaimer