Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall - Firestone Steel Wheels Cracking Addendum
- Recall - Firestone Steel Wheels May Crack
- Recall - Fuel Tank Shield Installation
- Recall - Insufficient Fuel Tank Shield Spill Proctection
- Recall - Push-Pull Headlight Switch Replacement
- Recall - Headlight Switch R&R, Potential Headlight Loss
- Recall 86V056000: Headlight Switch Defect
- Recall - LH Lower Control Arm Cracking
- Recall - Roof Marker Lamps Not Installed
- Recall 93V187000: Seat Recliner Defect
- Recall - Incorrect Rear Brake Assemblies
- Customer Interest
- Interior - Eliminating Unwanted Odors in Vehicles
- Body - Broken Rear Window Defogger Grid Detection
- Audio System - Noise When Using Portable Playback Unit
- Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
- Power Steering - Fluid Leaks Due to Extreme Low Temps
- Restraints - Seat Belt Latching Issues/Warning Lights
- A/C - Musty Odors Emitted From (HVAC) System
- Electrical - MIL ON/DTC's Set By Various Control Modules
- Instrument Panel - Lights Inoperative With Switch ON
- A/T, Rear - Poor Performance
- Engine - Oil Leaks Diagnosis & Repair
- Cooling System - Leaks
- Fuel Filter - Leak Concerns, Hard Start
- Fuel - Hard Starting Cold
- Brake Pads - Front Brake Squeal
- Brakes - Pull/Lead When Braking
- Interior - Wind Whistling Noise From Vent Window
- Diesel Engine Rear Main Seal - Leaking
- Tires - Irregular/Premature Wear
- Frame - Cracking Under Severe Useage
- Door Locks - Binding or Sticking/Key Hard to Insert
- Tailgate Window - Closes Slowly/Sticking
- Seat (Rear) - Rattle/Chucking Noise
- Seat (Rear) - Squeaks and Rattles
- Doors - Wind Noise/Cold Air Intrusion
- Rear Inner Headliner Roof Molding - Sagging
- Differential - Chatter on Acceleration, 8.5 Inch Locking
- A/T - New Pump to Case Bolt and O-Ring Improves Sealing
- Oil Pump Body Seal - Fluid Leaks
- A/T - Fluid Out Vent Diagnostic Tips
- A/T - Fluid Leak Near Front Pump (Bushing Walkout)
- A/T - THM 700-R4 Pump Whine or Moan
- A/T - 700 R4 Pump Whine or Moan
- A/T - Replacement of the Pump Body Oil Seal Assembly
- A/T - Leaks From the Oil Pump Body
- Engine - Stops Running When Shifting to Reverse or Drive
- A/T - 4L60 Slipping or No 3rd/4th Gear
- A/T - Binding or Inoperative In Reverse
- Fuel - Return Line Cap & Clamp Updated Replacement Parts
- Brake Master Cylinder Cover - Leakage
- Brakes - Front Calipers
- Battery - Dead Due to Excessive Current Draw
- Backup Lamps/Tailgate Window Release - Inoperative
- Cruise Control - Engine Surge More Noticeable Low Speeds
- Radio - Alternator Noise Whine Left Channel
- Audio - Poor AM or FM Radio Reception
- Brakes - Pull While Braking
- Engine - Block Heater Leaks
- Brakes - Light Brake Drag While Driving
- A/C - Refrigerant Hose & Clamp Repairs
- Stabilizer Bar (Front) - Noise/Rattle
- Suspension - Modification To Rear & Affects On Braking
- Suspension - Vehicle Trim Height Low on One Side
- Electric Door Lock Switch - Separation
- Kick Panel Fresh Air Vent - Water Leak
- Door Handle - Air Leaks
- Door Trim Panel - Warp
- Tailgate Window - Chipping
- Hood - Sheet Metal Movement
- Tailgate Window Operation
- Side Door Glass Lower Seal - Wind Whistle
- Wiper Blades - Chattering and Poor Wipeability
- Windshield Washer System - Drips/Dribbles
- Body - Grille Mounting Tabs Crack or Break Off
- Grill Mounting Tabs - Cracking
- Water Pump Pulley - Cracked
- Console - Shake
- A/T - Premature Wear of Direct Clutch
- A/T - Slipping/Loss of Drive Range
- Slipping Condition - Loss of Drive Range
- A/T - Buzzing Noise at Idle
- M/T - Gear Oil Smell In Vehicles
- A/T - New Lube Window and Band Apply/Anchor Brackets
- A/T - Park/Neutral to Reverse Shift Feel
- A/T - Shudder in Reverse
- M/T - 3RD Gear Hop-Out on Acceleration or Deceleration
- M/T - Neutral/Drive Gear Rattle
- M/T Shifter Assembly - Stuck in Gear
- Compact Disc Players - CD Changer Loading Procedures
- SIR - Operating Vehicle with Warning Light On
- A/C - Moan Noise With Compressor Engaged
- Diesel Engines - Hard Start, Erratic Operation, Smoke
- Diesel Engine - Downhill/Deceleration Surge
- Instrument Panel - Upper Surface Reflection
- Tailgate - Slow Power Window Operation
- Carpet - Loose on Side Wall Trim Pads
- Paint - Chips On Exterior Leading Edges
- Door Handle (Interior) - Misaligned
- A/T - Erratic or No Upshift (New Governor Driven Gear)
- A/T - 4L60 Stuck In First Gear
- Tool - Lifter Noise Diagnosis & Repair
- A/T - No Engine Braking In Drive 2 (D2) Selection
- Drive Axle - Premature Wear
- P/S - Reduced Assist When Cold
- Third Seat Back - Sagging
- Engine, A/T - Shift/Driveability Concerns/MIL ON
- A/T - No Movement in Drive or 3rd Gear
- Body - Marks/Stains on Windshield When Wet
- Body - Stain/Film On Windshield Glass Perimeter
- Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
- Electrical - Intermittent MIL/DTC P2138/Reduced Power
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- 10-00-89-010A - 10/19/12
- 12-06-01-008 - 09/01/12
- 04-06-01-029F - 09/01/12
- 03-06-04-017E - 09/17/12
- 00-03-10-006G - 07/17/12
- 03-03-10-007F - 07/12/12
- 01-08-51-003A - 11/01/2010
- 01-08-51-003 - 01/01/2010
- 08-07-30-035A - 01/01/2010
- 05-06-04-022F - 10/01/10
- 06-08-64-001 - 12/01/06
- 06-08-64-001A - 10/01/09
- 05-03-08-002 - 12/01/05
- 05-03-08-002A - 10/19/08
- 05-03-08-002B - 10/01/09
- 06-00-89-051B - 12/01/08
- 04-08-50-006 - 06/01/04
- 04-08-50-006A - 12/01/07
- 00-06-01-012A - 02/08/05
- 933E106 - 07/01/93
- 93966C - 10/01/93
- 938A95 - 07/01/93
- 93-4A-101 - 04/01/95
- 933E67 - 06/01/93
- 933E100 - 07/01/93
- 931B11 - 09/01/92
- 93-6-107 - 07/01/97
- 926B71 - 04/01/92
- 921B126 - 08/01/92
- 913117 - 03/01/94
- 89T266A - 03/01/89
- 891785 - 06/01/89
- 88T1497A - 08/01/88
- 883915 - 02/01/88
- 86C19D - 06/01/92
- 86B935A - 06/01/86
- 631208 - 04/01/97
- 40-05-01C - 10/01/99
- 367106 - 09/01/95
- 310503B - 01/12/96
- 23-62-03 - 07/01/97
- 12-92-43 - 07/01/97
- Warranty - Expediting parts
- Warranty - Parts Returning Program
- Warranty - Expediting Parts
- Parts - Expediting Information
- Wipers/Washers - Windshield Wiper Maintenance/Cleaning
- Wipers - Performance/Cleaning Instructions/Maintenance
- Windshield Wipers - Performance/Cleaning and Maintenance
- Glass/Body - Windshield Wiper Performance
- Body - Distortion On Outer Glass Surfaces
- Lighting - Headlamp Polycarbonate Lens Damage Prevention
- Lighting - Lamp Polycarbonate Lens Damage Prevention
- Odometer/Speedometer - Repair Facilities
- Body - Paint-Less Dent Repair Recommendations
- Body - Application of Anti-Corrosion Materials
- Body - Metal Body Panel Corrosion Protection
- Body - Hem Flange Sealer For Corrosion Protection
- Body - Metal Body Panel Corrosion Protection
- Body - Metal Panel Corrosion Protection
- Body - Hem Flange Repair
- Body - Paint-less Dent Repair Process
- Weatherstrips - Use of Silicone Grease for Maintenance
- Interior - Seat Cover Wrinkle/Crease/Burn Info
- Interior - Seat Cover Wrinkle/Crease/Crack/Burn Info.
- Locks - Key Code Security Rules And Information
- Locks - Key Code Securtiy Rules And Information
- Locks - Binding/Sticking Door Lock Cylinders
- Body - Exterior Emblem Discoloration/Blistering/Peeling
- Body - Side Window Chipping Information
- Body - Vehicle Glass Distortion Information
- Body - Use of Silicone for Weatherstrip Maintenance
- Body - TPO Fascia Cleaning Prior to Painting
- Audio System - Noise When Using Portable Playback Unit
- Audio System -Noise When Using Portable Playback Unit
- Policy - Procedure to Handle Customer Radio Concerns
- Audio - Radio Frequency Interference (RFI) Diagnosis
- Cellular Phones - Operating Characteristics
- Restraints - Availability of Seat Belt Extenders
- Restraints - Seat Belt Warning Lamp On/Buckling Issues
- Restraints - Seat Belt Warning Lamp On/Buckling Issues
- Restraints - Seat Belt Operating Characteristic
- Seat Belts - Seat Belt Extender Availability
- Restraints - Driver/Passenger Seat Head Rest Information
- Restraints - Driver/Passenger Seat Head Rest Information
- Restraints - Passenger Presence System Information
- Airbags - Disconnect Procedures
- A/C - Broken Rear Window Defogger Grid Detection
- Interior - Elimination Of Unwanted Odors
- Interior - Elimination Of Unwanted Odors
- Interior, A/C - Vehicle Odor Elimination
- Tools - A/C Leak Detector Kit Maintenance
- A/C - Refrigerant Loss
- Interior - Eliminating Unwanted Odors
- Suspension - Shock Absorber/Strut Fluid Leak Information
- Suspension - Shock Absorber/Strut Leakage Information
- Electrical - Information For Electrical Ground Repair
- Electrical - Information For Electrical Ground Repair
- Electrical - Information For Electrical Ground Repair
- Electrical - Information For Electrical Ground Repair
- Audio System - Portable Audio Equipment Noise
- Locks - KeyCode Security Rules and Information
- Locks - Key Code Security Rules and Information
- Locks - Key Code Security Rules and Information (CANADA)
- Drivetrain - Clunk Noise Shifting From PARK Into Gear
- A/T - DEXRON(R)-VI Fluid Information
- Drivetrain - Clunk Noise Shifting From PARK Into Gear
- Drivetrain - Driveline Clunk Information
- 4WD/AWD Systems - Driveline Operating Characteristics
- AWD/4WD System - Driveline Operating Characteristics
- Driveline - Clunk Noise When Shifting
- Manual Transmission - M/T Operating Characteristics
- M/T - Operating Characteristics
- M/T - Operating Characteristics of Manual Transmissions
- M/T - Normal Operating Characteristics
- Driveline - Clunk
- Drive Line - Clunk During Shifting Gear Positions
- Drivetrain - Axle Lubricant Recommended
- A/T - Clunk When Shifting From PARK/DRIVE/REVERSE
- Automatic Transmission - Service Procedure Change
- A/T - Service Procedure
- A/T - Service Procedure Change
- A/T - 700-R4 (4160), Transmission Binding In Reverse
- A/T - Fluid Oil Cooler Flush
- A/T - Fluid Oil Cooler Flush
- Automatic Transmission - Fluid Cooler Flushing
- A/T - Oil Cooler Flushing and Flow Check Procedures
- A/T - Oil Cooler Flushing/Flow Check
- A/T - 2-3 Upshift or 3-2 Downshift Clunk Noise
- A/T - Slipping, Loss of Drive Range Condition
- Fuel System - GM Fuel System Treatment PLUS(R) Info.
- Fuel System - TOP TIER Detergent Gasoline Usage
- Fuel System - TOP TIER Detergent Gasoline
- Engine Controls - Aftermarket Accessory Usage
- Engine Controls - Aftermarket Accessory Usage
- Engine Controls - Aftermarket Accessory Usage
- Cooling System - Approved Coolant Recycling Processes
- A/C - Servicing of Aluminum Heater Cores/Radiators
- A/C - Aluminum Heater Core and/or Radiator Replacements
- Vehicle - Engine Crankcase and Subsystems Flushing Info.
- Vehicle - Engine Crankcase and Subsystems Flushing Info.
- Vehicle - Engine/Subsystem Flushing Recommendations
- Engine - Use of 'Surface Conditioning Disks'
- Engine - Crankcase Flushing Information
- Engine - Sealant Usage/procedures
- Engine - Surface Conditioning Disc Usage Prohibition
- Engine - Sealant Usage Recommendations
- Gasket Surfaces - Use of Surface Conditioning Discs
- Engine - Intake Manifold Inspection/Replacement
- Intake Manifold - Inspect/Replace After Engine Damage
- Engine/Fuel - Additive Information
- Manual Transmission - Operating Characteristics
- Chrome Wheels - Chemical Staining Precautions
- Aluminum Wheel - Refinishing Recommendations
- Chrome Wheels - Chemical Staining
- Aluminum Wheels - Low Tire Pressure Condition
- Wheels/Tires - Slow Leaks From Aluminum Wheels
- Wheels - Aluminum Wheel Refinishing Recommendations
- Tires - Puncture Repair Procedure
- Tires/Wheels - Low Tire Pressure With Aluminum Wheels
- Tires/Wheels - Nitrogen Gas Usage for Filling Tires
- Wheels Chrome Wheel Chemical Staining/Pitting/Corrosion
- Wheels - Changing Procedures/Precautions
- Wheels - Pitting/Brake Dust On Chrome Wheels
- Tires - Original Equipment Tire Characteristics
- Tires - Inflation Pressure Information
- Tires - Tread Puncture Repair Procedures
- Tires - Radial Force Variation (RFV) Information
- Wheel Alignment - Recommendations/Requirements
- Tires - Proper Tire Pressure Information
- Tires - Proper Inflation Pressure Information
- Wheels/Tires - 'Upsized' Wheel And Tire Information
- Tires - Proper Inflation Pressure Info.
- Engine - Noise Damage Caused By The Oil Filter
- Engine - Internal Noise/Damage After Oil Filter Change
- Tires - Information on Proper Tire Pressure
- Wheel/Tire - Upsized Wheel/Tire Performance Info.
- Tires/Wheels - Vibration/Balance/Shake/Flat Spotting
- Tires/Wheels - Tire Inflation Pressure Information
- Tires - (RFV) Radial Force Variation Information
- Tires - Tire Puncture Repair Procedures
- Tires - Nitrogen Gas Usage
- Wheels/Tires - Changing Tire and Wheel Assemblies
- Wheels/Tires -Low Tire Pressure
- Engine - Accessory Drive Belt Noise Diagnostics/Tool
- Wheels/Tires - Accessory Wheel/Tire Mounting/Balancing
- Wheels/Tires - Chrome or Chrome Plated Steel Valve Caps
- Alignment - Specifications/Requirements/Recommendations
- Tires - Radial Force Variation (RFV) Info.
- Tire - Use Of Nitrogen Gas In Tires
- Tires - Correct Inflation Pressure Information
- Wheels/Tires - Original Equipment Characteristics
- Wheels/Tires - Tire Puncture Repair Procedures
- Wheels/Tires - Low Tire Pressure
- Wheels/Tires - OE Tire/Wheel Characteristics
- Wheels/Tires - Low Tire Pressure/Aluminum Wheels Leak
- Wheel - Refinishing Aluminum Wheels
- Tires - Tire Radial Force Variation (RFV)
- Wheels - Chrome Wheel Staining/Pitting/Corrosion
- Wheels/Tires - Use of Nitrogen Gas in Tires
- Wheels/Tires - Tire Radial Force Variation (RFV)
- Wheels - Chrome Wheel Staining/Pitting/Corrosion
- Tires/Wheels - Information on Tire Radial Force Variation (RFV)
- Engine Coolant - Approved Recycling Systems
- A/T - Fluid Cooler Flushing
- Cooling System - Coolant Recycling Equipment Update
- Coolant - Current Information on Propylene Glycol Blend
- Coolant - Use of Propylene Glycol Based Blend
- Engine Coolant - Information
- Cooling System - DEX-COOL(R) Coolant Usage Information
- Cooling System - DEX-COOL(R) Coolant Information
- A/T - DEXRON III(R) (H-Revision) Specification Upgrade
- A/T - DEXRON(R) VI Fluid Availability
- Engine - Unnecessary Flushing Services
- A/T - DEXRON-VI(R) Fluid Availability
- Engine - GM Dexos 1(R) and Dexos 2(R) Oil Specifications
- All Technical Service Bulletins
- Interior - Eliminating Unwanted Odors in Vehicles
- Locks - Key Code Security Rules, Key Code Look Up
- Vehicle - Engine And Sub Systems Flushing Info. (CANADA)
- Vehicle - Engine And Sub-Systems Flushing Recommendations
- Wheels/Tires - Use Of Nitrogen Gas In Tires
- Tires - Information On Proper Tire Pressure
- Engine - THIS BULLETIN HAS BEEN CANCELED
- Tires/Wheels - OE Tire Shake/Vibration Information
- Suspension - Shock Absorber/Strut Fluid Leak Information
- M/T - Operating Characteristics Information
- Brakes - Resurfacing Park Brake Portion of Rear Brake Rotor
- Body - Hem Flange Sealer For Corrosion Protection
- Engine - Intake Manifold Inspection/Replacement
- Body - Metal Body Panel Corrosion Protection
- Fuel System - GM Fuel System Treatment PLUS(R) Info.
- Body - Broken Rear Window Defogger Grid Detection
- Fuel System - Fuel Injector Maintenance Cleaning
- Audio - Inadvertent Steering Wheel Button Activation
- Audio System - Noise When Using Portable Playback Unit
- Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
- A/T - Fluid Oil Cooler Flow Test
- Power Steering - Fluid Leaks Due to Extreme Low Temps
- Lighting - Lamp Polycarbonate Lens Damage Prevention
- Restraints - Seat Belt Latching Issues/Warning Lights
- Body - Side Window Chipping Information
- Restraints - Driver/Passenger Seat Head Rest Information
- Engine - Use of 'Surface Conditioning Disks'
- Body - Application of Anti-Corrosion Materials
- A/T - 2-3 Upshift or 3-2 Downshift Clunk Noise
- A/C - Musty Odors Emitted From (HVAC) System
- A/T - Slight Vehicle Movement In Park At Start Up
- A/T - DEXRON(R)-VI Fluid Information
- Wheels/Tires - Refinishing Aluminum Wheels
- Lighting - Exterior Lamp Condensation and Replacement
- Electrical - MIL ON/DTC's Set By Various Control Modules
- Steering/Suspension - Wheel Alignment Specifications
- Warranty - Claims Submission
- Warranty - Goodwrench Service Lifetime Service Guarantee
- Warranty - GM Dealer Parts Procurement
- Warranty - Notice of Delayed Start Process
- Warranty - Parts Warranty Special Claims B and C
- Warranty - Request for Wholesale Authorization
- VIN Plate - Replacement Policy and Procedure
- Warranty - GM Dealer Empowerment Program
- Labor - Revised Operation Z1241/Personal Property Damage
- Warranty - Repair/Replace Policies & Procedures
- Parts Expediting - Reimbursement Policy
- Warranty - Enhanced Sublet Repair Policy
- Warranty - Required Claim Submission Procedures
- Warranty - Repair and Claims Procedures
- Overview
- Certified Dealer Service Management empower./repair approval
- Customer Satisfaction
- Dealer Repair Options
- Coverage Guidelines/GM Certified Used Vehicle Coverage
- Warranty Coverage - Cause of Failure
- GM Certified Used Vehicle Warranty Verification
- Warranty Administration
- Courtesy Transportation
- Campaigns
- Dealer Reimbursement Guidelines (Warranty Claims Submission)
- Customer Reimbursements
- Warranty Repairs on Used Vehicles In Inventory
- Reconditioning
- Inspection and Warranty Repairs
- Buy-Back Vehicles
- Diesel Engine Repairs/Deductible
- Corrosion Protection and Emissions Warranties
- U.S. Touring Owner Service
- Warranty - Claim Processing
- Warranty - Corporate Parts Return Program Instructions
- Vehicle - Use of a Diagnostic Worksheet
- Vehicle - AC Delco Locator Service, Electronics Exchange
- Electrical - Wiring Repair Temp Range Precaution
- Campaign - Product Bulletin Numbering System
- VIN - Passenger Car & Truck Identification
- Overview
- Vehicle Identification
- 1984-85 Service Parts Identification Label Locations
- Passenger Car Engine Production Code Explanation
- Truck Engine Production Code Explanation
- Transaxle Assembly Identification Information
- Passenger Car Transmission Production Code Explanation
- Manual Transmissions
- Automatic Transmissions
- Passenger Car Transmission Identification Number For "Service" Usage
- 1985 Passenger Car Transmission Program Summary
- Truck Transmission Production Code Explanation
- Muncie Manual Transmission Production Code Explanation
- 3 Speed (Saginaw Type)
- Muncie Truck 4 Speed
- New Process 205, 207, and 208 4-Wheel Drive Transfer Case
- Warner Gear Four and Five-Speed Manual Transmissions
- Truck Four-Speed Isuzu Transmission (77.5mm)
- 350C and 700-R4 Turbo Hydra-Matic Transmissions
- 400-475 Model Turbo Hydra-Matic Transmission
- Truck Transmission Identification Number For "Service" Usage
- 1985 Truck Transmission Program Summary
- Axles
- Vehicle - Current Model Line Designators
- Parts - Expediting Procedures
- Glass - Adhesive Caulking Kit Revisions
- Electrical - Detecting Intermittents Procedure
- Warranty - Corporate Parts Return Program
- Aftermarket Accessories - Installation Guidelines
- Electrical - Diodes Replacement Information
- RTV Sealants - Use on Engines With Oxygen Sensors
- I/M 240 Repairs - Obtaining Technical Assistance
- Instrument Cluster - Replacement Information
- Instrument Panel - Lights Inoperative With Switch ON
- Electrical - Instrument Panel And General Wiring Repair
- A/C - Leak Test Diagnosis Tools
- A/C - CFC Reduction and Refrigerant Recovery
- A/C Refrigerant - Contamination
- A/C - Use of Alternate Refrigerants in CFC 12 Units
- Tools - A/C Leak Detector Maintenance Kit Availability
- A/C - Systems With R12 Or R134a Service Issue
- A/C - Tool And Equipment Maintenance
- A/C - PureGuard 2 Operating Alert
- A/T, Rear - Poor Performance
- A/T & M/T - AC Delco Remanufactured Transmissions
- ACDelco(R) Remanufactured Transmissions - Program Update
- Engine - Recommended RTV Sealants
- Engine - Oil Leaks Diagnosis & Repair
- Engines - ACDelco Remanufactured
- Engine - Surface Conditioning Discs Precautions
- Engine - AC Delco Remanufactured Engines
- Diesel Engine - Noise Compliance
- Cooling System - Leaks
- Steering - System Bleed Procedures
- Fuel Filter Base - Restriction Switch Elimination
- Fuel Filter - Leak Concerns, Hard Start
- Fuel - Hard Starting Cold
- Brake Pads - Front Brake Squeal
- Brakes - Pull/Lead When Braking
- A/C - Compressor Assembly Availability
- A/C - System Diagnostic Procedure
- A/C - Shaft Nut Removal from the HR6HE Compressor
- A/C Compressor Seal Washer - Reference Chart
- Interior - Wind Whistling Noise From Vent Window
- Suspension - Shock Absorber/Strut Replacement Guidlines
- Engine - Cylinder Damage Due to Glow Plug Breaking
- Cooling - Radiator Repair/Replacement Guidelines
- Diesel Engine Rear Main Seal - Leaking
- Brakes - Manual Clarified, Caliper To Knuckle Clearance
- Wheels (Aluminum) - Coated Balance Weight Usage
- Recall - Firestone Steel Wheels Cracking Addendum
- Recall - Firestone Steel Wheels May Crack
- Wheels - Sealing Leaking Cast Aluminum
- Wheels - Finish Damage During Off Car Balancing
- Warranty - OE Chrome Plated Aluminum Wheel ID
- Wheels - Locking Wheel Nuts Impact On Tire Balance
- Tires (Front) - Irregular Wear Information
- Tires - Irregular/Premature Wear
- Wheels (Steel) - Damage Due to Improper Mounting
- Tires - Speed Rated Information
- Frame - Cracking Under Severe Useage
- Frame - Wheel Offset Explanation
- Door Locks - Binding or Sticking/Key Hard to Insert
- Lock Cylinders - Inoperative/Proper Lubricant Usage
- Tailgate Window - Closes Slowly/Sticking
- Seat (Rear) - Rattle/Chucking Noise
- Seat (Rear) - Squeaks and Rattles
- Doors - Wind Noise/Cold Air Intrusion
- Rear Inner Headliner Roof Molding - Sagging
- Drivetrain - Evaluating Driveline Vibration
- A/T Oil Pan Gasket - Eliminates Fluid Leaks
- A/T - Updated Side Cover Or Bottom Pan Removal
- Differential Pinion Shaft Lock Screw - Service
- Differential Pinion Shaft Locking Screw - Revised
- Differential - Chatter on Acceleration, 8.5 Inch Locking
- Differential - Governor Removal Tool Revision
- A/T - Updated Filter and Seal
- A/T - New Pump to Case Bolt and O-Ring Improves Sealing
- Oil Pump Body Seal - Fluid Leaks
- A/T - Fluid Out Vent Diagnostic Tips
- A/T - Updated Oil Pump Assemblies
- Pump to Case Bolt and O-Ring Assembly - Revised
- A/T - Fluid Leak Near Front Pump (Bushing Walkout)
- A/T - THM 700-R4 Pump Whine or Moan
- A/T - 700 R4 Pump Whine or Moan
- A/T - Replacement of the Pump Body Oil Seal Assembly
- A/T - Leaks From the Oil Pump Body
- A/T - New Pump Assembly Service Parts Information
- Engine - Stops Running When Shifting to Reverse or Drive
- A/T - 4L60 Slipping or No 3rd/4th Gear
- A/T - 700R4 Updated Oil Pump
- A/T - 700R4 New Front Pump Assembly
- A/T - 700R4 Front Pump Air Check
- A/T - THM 400 Front Pump Interchangeability
- A/T - 2004R/700R4 Oil Pump & Slide Service
- A/T - 700R4 Pump Assembly Casting Number Information
- A/T - Cooler Replacement/Flushing
- A/T - Binding or Inoperative In Reverse
- Flywheel Bolts - Revised Torque Specification
- A/T - TV Cable Identification (700-R4 Light Duty)
- Slip Yoke/U-Joint - Replacement and Servicing
- Fuel Injectors - Remanufactured for TBI Systems
- Tools - Introduction Of The Fuel Injector Tester
- Fuel - Return Line Cap & Clamp Updated Replacement Parts
- Engine Controls - ECM May Contain Wrong PROM
- Front Wheel Driveshaft Boot - Damage Prevention
- Brake Master Cylinder Cover - Leakage
- Brakes - Front Calipers
- Brakes - New Front Brake Calipers Available
- Brakes - Replacement Booster Push Rod Height Gage
- Tools - Revised Brake Booster Push Rod Height Gage
- Parasitic Drain Ammeter - Connection Procedure Revised
- Battery - Diagnosis and Charging
- Battery - Dead Due to Excessive Current Draw
- Warranty - New Vehicle/Replacement Battery
- Battery - Insulator Replacement & Caution
- Backup Lamps/Tailgate Window Release - Inoperative
- Recall - Fuel Tank Shield Installation
- Recall - Insufficient Fuel Tank Shield Spill Proctection
- Cruise Control - Engine Surge More Noticeable Low Speeds
- Audio - Radio Frequency Interference (RFI) Diagnosis/ID
- Radio - Alternator Noise Whine Left Channel
- Audio - Poor AM or FM Radio Reception
- Accessories - Radio Telephone/Mobile Radio Precautions
- Seat Belts - Extender Availability
- Seat Belt - Operations/Features and Location
- Lap/Shoulder Belts - Dealer Installed Rear Kits
- IP Dimmer Control - Proper Setting
- Brakes - Pulsations and Rotor Surface Refinish
- Brakes - Rotor & Hub Flange Cleaning Tool Revision
- Brakes - Pull While Braking
- A/C - Refrigerant Loss Prevention
- Engine - Block Heater Leaks
- Odometer/Speedometer - ACDelco Service Center Locations
- Recall - Push-Pull Headlight Switch Replacement
- Recall - Headlight Switch R&R, Potential Headlight Loss
- Recall 86V056000: Headlight Switch Defect
- Brakes - Light Brake Drag While Driving
- Cooling - New Style Hose Clamp
- Cooling - New Style Hose Clamp
- A/C - Refrigerant Hose & Clamp Repairs
- Anti-Lock Brake - Aftermarket Products Usage Precaution
- Stabilizer Bar (Front) - Noise/Rattle
- Suspension - Modification To Rear & Affects On Braking
- Suspension - Vehicle Trim Height Low on One Side
- Body - Vinyl Trim and Vinyl Top Repair Information
- Body - Sealer Tape For Collision Repairs
- Emissions - Information On State Emissions Testing
- Enhanced IM240 Program - Implementation Plan
- Emission - Enhanced Inspection Maintenance Programs
- I/M 240 Program - Equipment Purchase
- Enhanced Emission I/M - Program Update
- Enhanced Emission Inspection Maintenance - Equipment
- EVAP System - Service of Connectors
- Fuel System - Integrator/Block Learn Operation
- Electrical - Care of Metri-pack 150 Terminals
- Oxygen Sensor Test - Revised Tech 1 Mass Storage CD
- Electric Door Lock Switch - Separation
- Campaign - Windshield Washer Pump Failure
- Campaign - Windshield Washer Pump Failures
- Kick Panel Fresh Air Vent - Water Leak
- Door Handle - Air Leaks
- Door Trim Panel - Warp
- Tailgate Window - Chipping
- Hood - Sheet Metal Movement
- Windshield - Two-Part Urethane Adhesive For Installation
- Wiper Blades - Chattering on Windshield
- Tailgate Window Operation
- Side Door Glass Lower Seal - Wind Whistle
- Wiper Blades - Chattering and Poor Wipeability
- Windshield Washer System - Drips/Dribbles
- Body - Grille Mounting Tabs Crack or Break Off
- Grill Mounting Tabs - Cracking
- Engine Oil - Dye and Discoloration
- Water Pump Pulley - Cracked
- Cooling System - Antifreeze Recycling
- Coolant - Recycling Update
- Coolant - Information on Propylene Glycol Usage
- Warranty - Recycled Engine Coolant Policy
- Coolant - Usage/Specifications
- Engine Coolant - Recycling Information
- Console - Shake
- P/S - Rack & Pinion O-Ring Seal Fitting Leaks
- P/S - Submerged Style Pump "O" Ring Change
- A/T - Piston Seals Cut/Leaking
- A/T - Premature Wear of Direct Clutch
- A/T - Slipping/Loss of Drive Range
- Slipping Condition - Loss of Drive Range
- A/T - Forward Clutch Plate Assembly Modifications
- A/T - 700R4 New Lo & Reverse Clutch Assembly
- A/T - 700R4 New 3-4 Clutch Apply Package
- A/T - Elimation of Throttle Valve Sleeve
- Campaign - Transmission Replacement
- A/T - Understanding Identification Information
- A/T - Identification Information
- A/T - Buzzing Noise at Idle
- M/T - Gear Oil Smell In Vehicles
- A/T - 4L60 New Output Shafts and Shaft Seals
- A/T - New Lube Window and Band Apply/Anchor Brackets
- A/T Fluid Level Indicator - Revised (Sealed)
- A/T - Park/Neutral to Reverse Shift Feel
- A/T - Replacement Model Update
- A/T - Shudder in Reverse
- A/T - New Solenoid Testing Kit
- A/T - Core Return Product Feedback Form
- A/T - Control Valve Without Throttle Valve Sleeve Update
- A/T - 700R4 Updated Input Shaft/Pump/Converter
- A/T - 700R4 Solenoid Reference Chart
- A/T - 2004R/700R4 Pump Assembly
- A/T - 700R4 2nd Apply Piston & Housing Applications
- A/T - 700R4 Updated Pinion Carrier
- A/T - 700R4 Redesigned Valve Body
- A/T - 700R4 Service Update
- A/T - 700R4 Oil Pressure Switch Locations
- A/T - 700R4 Harsh 1-2 Shift
- A/T - 700R4 Shudder In Reverse
- A/T - THM 7700R4 Correction To Service Bulletin - 8614
- A/T - Overheating In Fourth Gear
- A/T - 700R4 1984 Production Changes
- A/T - 700R4 Checking Lubrication Passages
- A/T - 700R4 Down-Shift Clunk In Manual 3 Range
- A/T - 700R4 Auxiliary Accumulator Valve
- A/T - 700R4 Correction To Bulletin SIL8722
- A/T - 700R4 Fluid Leaks/Oil Pump Body Seal
- A/T - Converter Clutch Solenoid Fluid Source I.D.
- A/T - 700R4 & 2004R New Iron Pump Rings
- A/T - 700R4 New Control Valve Assembly
- A/T - 700-R4 & 400 Improved Governor Driven Gear
- A/T - 3L80/THM 400 Center Support Bolt
- A/T - ATRASIL8713 Service Bulletin Correction
- A/T - Torque Converter Identification
- A/T - Harsh Reverse Engagements
- A/T - Engine Vacuum Testing
- A/T - Bind-Up On The 1-2 or 3-2 Downshift
- A/T - 700R4 No 4th, Late 4th, Falls Out Of 4th
- A/T - Diagnosing Converter Lock-Up Problems
- Overview
- Test # 1 - Checking For 12 Volts at Terminal -A-
- Test # 2 - Checking For 12 Volts Across Fuse
- Test # 3 - Checking For 12 Volts Across Brake Switch
- Test # 4 - Adjusting/Replacing the Brake Switch
- Test # 5 - Checking Wires For Shorts and Opens
- Test # 6 - Checking For Ground at Terminal -D-
- Test # 7 - Grounding the -D- Wire
- Test # 8 - Checking Cooler Line Pressure or Surge
- Test # 9 - Checking the Solenoid
- Test # 10 - Checking Electrical Switches on Trans.
- Test # 11 - Checking Lockup Apply Valve
- Test # 12 - Checking Signal Oil Circuit
- Test # 13 - Checking the Computer
- A/T - Valve Body Assembly 700-R4 Inspection
- A/T - How To Use A Pressure Gauge
- A/T - 700R4 Valve Body Interchange
- A/T - 700R4 Bind In Reverse After Rebuild
- A/T - 200/200C/200R4, 325/3254L, 700-R4 No 2nd Gear
- A/T - THM Late or No Upshifts
- A/T - 700R4 Shifts In Manual Low
- A/T - 700R4, 2004R No Line Pressure Rise
- A/T - 700R4 Forward Sprag Design
- A/T - 700R4 Rear Planet Failure/Lack of Lube
- A/T - 700R4 No 2nd, No 4th and No TCC
- A/T - Delayed Forward Engagement/Burnt 3-4 Clutches
- A/T - 700R4 Pump Cover Screen
- A/T - 700R4 Erratic/Late Shifts As Unit Gets Hot
- A/T - 700R4 No Upshift, Good Reverse and Drive
- A/T - Occasional No-Reverse, Or Shudder In Reverse
- A/T - 700R4 Sleeving Governor Bore
- A/T - No Drive/Reverse/Third Gear Or Fourth Gear
- A/T - No Converter Clutch Apply When Unit Is Hot
- A/T - Recurrent Sticking Valves/In Line Filters
- A/T - 700R4 Valve Chatter/Not Enough Oil Feed
- A/T - THM 400 Rear Band Adjustment Too Loose
- A/T - 200C/2004R, 700-R4 Lip Seal Packages Part Numbers
- A/T - Rapid Converter Pump Bushing Wear
- A/T - 2004R & 700R4 Pump Break Up
- A/T - Converter Clutch Shudder
- A/T - 700R4 TCC Lock-Up Kit Precautions
- A/T - 125, 200C/200 4R, 700 R4 Hidden Residue Build Up
- A/T - 200 4R & 700 R4 Pump Failure
- A/T - 700R4 Late Upshifts/High Main Line Pressure
- A/T - 700R4 Low Mainline Oil Pressure
- A/T - 700R4 Snap Ring Jumps Out of Place
- A/T - Sticking Throttle Valves
- A/T - 700R4 Passing Gear Spin-Up/Engine Revs Up
- A/T - 700R4 Manual Valve Sticks
- A/T - 700R4 Reverse Friction (Lined) Clutches
- A/T - Pressure Tap Locations
- A/T - Blows Fuses, Engine Runs Poorly, No TCC Lock-Up
- A/T - Partial Tie Up In Reverse
- A/T - 700R4 Case Switches Installed On Outside Of Case
- A/T - 700R4 Diagnosing Internal Pressure Leaks
- A/T - 700R4 Clunk On 2-3 Gear Shift
- A/T - 700R4 Updated Input Sprag Assembly
- A/T - 700R4 4-3 Downshift On Slight Acceleration
- A/T - Methods to Check for Restricted Exhaust
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - 2-3 Flare-up, or Repeated 3-4 Clutch Failure
- A/T - THM 400 Too Sensitive 3-2 Downshift
- A/T - No Passing Gear (forced detent) Upshifts Normal
- A/T - No Upshift/Governor Contamination
- A/T - 700R4 Solid Teflon Sealing Rings/Turbine Shaft
- A/T - THM 400 No Reverse
- A/T - THM Steel Clutch Piston Inspection
- A/T - Sprag Rotation
- A/T - THM 2004R 700R4 TCC Stalls Engine In Drive/Reverse
- A/T - Checking Pressure Switches For Leaks
- A/T - 700R4 TCC Lock-Up Delay Valve
- A/T - Math Formulas Part I
- A/T - 700R4 Wiring Diagrams Thru 1989
- A/T - Twenty Steps To Successful Repairs
- A/T - 4L60/THM 700R4 200R4 Fluid Filter Seal
- A/T - Math Part II
- A/T - 700R4/200-4R New Fluid Filter Seal
- A/T - 700R4 Lubrication Update
- A/T - Choosing the Right ATF
- A/T - ATRATB8725 Service Bulletin Correction
- M/T - Pops out of 3rd Gear on Accel or Decel
- M/T - 3RD Gear Hop-Out on Acceleration or Deceleration
- M/T - Neutral/Drive Gear Rattle
- M/T - New Leak Resistant Styrene Rubber Coated Gaskets
- M/T Shifter Assembly - Stuck in Gear
- Compact Disc Players - CD Changer Loading Procedures
- SIR - Operating Vehicle with Warning Light On
- A/T - 4 (Of 6) Case Extension Studs Replaced By 4 Bolts
- Power Steering/A.I.R. Pump Belt - Tension Too Tight
- A/T - New ATF Dexron IIe Information
- A/T - DEXRON III Fluid Introduction
- A/C - Moan Noise With Compressor Engaged
- A/T - Intermittent Downshift, Slip or Busy/Cycling TCC
- Recall - LH Lower Control Arm Cracking
- Diesel Engines - Hard Start, Erratic Operation, Smoke
- Fuel - Diesel Injection Pump Governor Weight Retainer
- Diesel Engine - Downhill/Deceleration Surge
- PROM/MEMCAL - Identification Marks
- Engine - Sprocket Key Shear On Crankshaft
- Fuel - New Dash-Mounted Fuel Tank Selector Switch
- Instrument Panel - Upper Surface Reflection
- Suspension - Chassis Lubrication Importance
- Engine - Used Lube Oil Analysis Guidelines & Warnings
- Electrical - New Nickel Tape Shields Harnesses
- Fuel - How Fuel Economy Is Determined
- Engine - No Cold Start When Glow Plug Wait Lamp is OFF
- Fuel - Low Sulfur Diesel, Lubricity Information
- Cruise Control - Misdiagnosed Delay
- Cruise Control - Diagnostic Routine Modified
- Tires/Wheels - Wheel Weight Usage Precautions
- Tailgate - Slow Power Window Operation
- Engine - Glow Plug System Diagnostics
- Glow Plug - System Description, Diagnosis & Repair
- Glow Plug - No Wait Lamp, Starting Difficulty
- Carpet - Loose on Side Wall Trim Pads
- Body - Urethane Adhesives for Glass Applications
- Key Code - Information
- Paint - Checking Clear Coat Thickness
- Paint - Exterior Finish Removal By Layers
- Paint - Chips On Exterior Leading Edges
- Paint - Etching/Staining Prevention
- Paint - HVLP Painting Information
- Warranty - Rail Dust Removal & Chemical Spotting Labor
- Brakes - Rear Brake Sensitivity
- Electrical Connector - Terminal Checking Procedure
- Recall - Roof Marker Lamps Not Installed
- Door Handle (Interior) - Misaligned
- A/T - Rear Bushing On-Vehicle Service Procedure
- A/T - New Control Valve Assembly Elimination of TCC Bore
- A/T - Proper Use of Spacer Plate Gaskets In Overhaul Kit
- A/T - New Control Valve Assembly Identification
- A/T - Evaluating Peened Spacer Plates
- A/T - 700R4 Valve Body Modification
- A/T - Erratic or No Upshift (New Governor Driven Gear)
- A/T - 4L60 Stuck In First Gear
- Drivetrain - Recommended Axle Lubricant
- Tool - Lifter Noise Diagnosis & Repair
- A/T - New Servo Apply Pin
- A/T - Servo Cover Retainer Ring Modified
- A/T - Consistent Shift Points and Smoothness
- A/T - Accumulator Pistons & Seals Enhance Shift Points
- A/T - No Engine Braking In Drive 2 (D2) Selection
- A/T - 1-2 Accumulator Piston/Outer Spring Replacement
- A/T - New Case, 2nd, 3rd, 4th Pressure Taps Removed
- Drive Axle - Premature Wear
- Recall 93V187000: Seat Recliner Defect
- Contaminated R12 Refrigerant - Testing & Handling
- A/C - Retrofitting R-12 Vehicles to R-134A
- Electrical - Speed Sensor Buffer Connector Labeled Wrong
- Height Sensing Brake Proportioning Valve - Adjustment
- Brakes - Height Sensing Proportioning Valve Adjustment
- Sunshade - Replacement Availability
- P/S - Reduced Assist When Cold
- Recall - Incorrect Rear Brake Assemblies
- Non-Factory Hydraulic Parking Brakes
- Alignment - The Importance of Four Wheel Alignment
- Third Seat Back - Sagging
- M/T - Updated Gaskets
- Body - Metal Panel Adhesive Bonding Information
- Cooling System - Coolant Recycling Information
- M/T - Hydraulic Clutch Bleeding Procedure Improvement
- Engine, A/T - Shift/Driveability Concerns/MIL ON
- Instruments - Reduced PRNDL Display Visibility
- Body - Polypropylene Energy Absorber Replacement
- Engine - Sealant Usage/Procedures
- Electrical - Aftermarket Fuse Warning
- Drivetrain - AWD/4WD System Driveline Characteristics
- Wheels - Chrome Wheel Brake Dust Accumulation/Pitting
- Restraints - Usage of Used/Salvaged/Imitation Components
- A/T - 4L60, Revised Sprag/Forward Clutch Hub
- A/T - No Movement in Drive or 3rd Gear
- Engine/Fuel System - Oil/Fuel Additive Information
- Cooling System, A/C - Aluminum Heater Cores/Radiators
- Wheels/Tires - Upsized Wheel/Tire Characteristics
- Audio System - Refurbishing Radio Faceplates/Knobs
- Body - Hem Flange Rust Repair Information
- Body - Marks/Stains on Windshield When Wet
- Wheels/Tires - Chrome/Steel Valve Stem Cap Precautions
- Engine - Noise/Damage Oil Filter Application Importance
- Engine - Drive Belt Misalignment Diagnostics
- Body - Maintaining Exterior Weatherstrip Appearance
- 06-08-111-004B - BULLETIN CANCELLATION NOTIFICATION
- Body - Stain/Film On Windshield Glass Perimeter
- Wheels/Tires - Accessory Wheel And Tire Information
- Wheels/Tires - Replacement Wheel Weight Information
- Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
- Tires/Wheels - Tire Puncture Repair Procedures
- Lighting - Headlamp Warranty Replacement Guideline
- Interior - Proper Use of Floor Mats
- Wheels - Changing Procedures/Precautions
- Body - Squeeze Type Resistance Spot Welding/Equipment
- Electrical - Intermittent MIL/DTC P2138/Reduced Power
- Restraints - Extender Availability For Seat Belt
- Interior - Seat Cover Wrinkle/Crease/Burn Info
- A/T - Water Or Coolant Contamination Information
- Body - Drilling High Strength Steel Using CryoCobalt(R)
- Body - Vehicle Glass Distortion Information
- Fuel System - TOP TIER Detergent Gasoline (Canada)
- Tires/Wheels - Information on Tire Radial Force Variation (RFV)
- Engine - GM Dexos 1(R) And 2(R) Oil Specifications
- Engine - GM dexos 1(R) and dexos 2(R) Oil Specifications/Info.
- Body - Pre-Painting/Cleaning Process For TPO Plastic Fascias
- Drivetrain - Information on Driveline Clunk Noise
- Wheels - Chromed Aluminum Wheel Staining/Pitting/Corrosion
- Body - Paint-less Dent Repair Process
- Wipers/Washers - Windshield Wiper Performance Information
- Electrical - Ground Repair Information
- Interior - Cleaning Instrument Panel, Interior Trim