Alignment - Wear On the Inside Edge of Front Tires
Bulletin No.90-030
Issue Date
OCT 31, 1994
Model
1989-91
CIVIC
Applicable To
ALL
File Under
SUSPENSION
Front Tire Wear
(Supersedes 9O-03O, dated March 8, 1991)
SYMPTOM
An unusual amount of wear on the inside edges of the front tires.
PROBABLE CAUSE
The front toe is out of adjustment.
CORRECTIVE ACTION
Replace the tires, if necessary, and set the toe. If the tires do not need replacing, rotate them in the pattern shown. This rotation pattern supersedes the information in the Owner's Manual.
1. Inspect the tires, and replace them if necessary. If the tires are replaced, proceed to step 3. If the tires are serviceable, continue with step 2.
2. Rotate the tires using the pattern.
3. Adjust the tire pressure to the specifications listed. (The tire pressure can also be found on the tire information label inside the glove box.)
4. Using the procedure in section 18 of the appropriate service manual, set the front toe to 3 mm toe-in.
5. Check the rear toe, and adjust it if necessary to 2 mm +2 / -1 toe-in.
WARRANTY CLAIM INFORMATION
In warranty:
The normal warranty applies.
Out of warranty:
Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Service Manager or your Zone Office. You must request consideration, and get a decision, before starting work.
Failed part: P/N 53540-SR3-013
H/C 3002342
Defect code: 005
Contention code: B99
Tire Replacement Information - 13 inch
If tire replacement is necessary, the replacement tire you must use is the Bridgestone Turanza S in size P175/70R13825 (even if the original tires are P165/70R13). These tires are available from any Firestone Tire and Service Center (FTSC). To locate the nearest FTSC, call (800) 367-3872.
You can either send the vehicle to the FTSC for mounting and balancing, or purchase the tires from the FTSC and install them in your shop.
Installation by Tire Dealer - List the installation expense and the prorated tire expense on the warranty claim in the sublet field. Use sublet code T2 (sublet tire purchase/installation).
Installation in Your Shop - List the prorated tire expense on the warranty claim in the first sublet field. Use sublet code T3 (sublet tire purchase). You are also eligible for a $10 per tire reimbursement for handling. List this dollar amount on the warranty claim in the second sublet field. Use sublet code T4 (sublet tire purchase handling reimbursement). Charge your flat rate time for mounting and balancing according to the, chart.
Tire Replacement Information - 14 inch
You are not required to use Bridgestones if 14 inch replacement tires are needed. To submit a warranty claim, follow the procedures given under Tire Replacement Information - 13 inch.
Tire Proration Table
AHM will pay, on a pro rata basis, for tires that need replacement due to premature or irregular wear. The full cost of mounting and balancing is reimbursed up to 36,000 miles.