Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall- Headlamp Low Beams Inoperative
- Recall 12V136000: Headlamp Low Beams Inoperative
- Recall - Driver's Air Bag Over-Pressurization
- Recall - Water Pump Replacement
- Recall 04V176000: Potential A/T Gear Failure
- Recall - Timing Belt Tensioner/Water Pump Replacement
- Campaign - SRS Control Unit Replacement
- Recall 10V041000: Air Bag Inflator Replacement
- Recall 12V573000: A/T Shift Interlock Lever Replacement
- Recall - Ignition Key Removable With A/T Not In Park
- Customer Interest
- Brakes - Rear Brake Clunk Sound
- Body/Suspension - Creaking/Ticking Noises
- Suspension - Clicking Noise From Right Rear
- Body - Tailgate Pops/Scrapes Upon Opening
- Body - Door(s), Clicking/Creaking Noises on Bumpy Roads
- Emissions/Engine Controls - MIL ON/DTC P1457 (EVAP)
- Engine Controls - Idle Fluctuation/MIL ON/DTC P1129
- Navigation System - Reboots/Incorrect Displays
- Interior - Seat Belts Slow to Retract
- LIghts - Tailight Reflector is Loose or Distorted
- Emissions - Hesitation/Surge Between 30 and 60 Mph
- Body - Accessory Hood Air Deflector Cracks
- Interior - Side-to-Side Looseness in Driver's Power Seat
- Restraints - Child Seat Anchor Locating Button Missing
- Electrical - Horn Honks By Itself On Bumps
- Engine - Idle Vibration/Harsh Shifting
- Suspension - Front End Rattles On Bumps
- A/C - Rear Blower Motor is Inoperative
- Body - Tailgate Spoiler Foam Strip Hangs Down
- Fuel System - Accelerator Pedal Popping/Sticking/Binding
- Engine - Oil Leaks From Front/Middle/Rear of Engine
- Drivetrain - Noise/Judder From Vehicle Rear When Turning
- Steering/Suspension - Vehicle Pulls Left/Right
- Navigation System - 2.11C Patch for Various Issues
- Factory Modifications
- Safety
- Superceded Bulletins
- 12-063 - 02/02/13
- THIS BULLETIN IS REPLACED BY 12-023 DATED 03/30/12
- 90-011 - 05/02/09
- 99-082 - 03/04/09
- 89-022 - 06/18/04
- Campaign - Extension of The Vehicle Warranty
- 99-082 - 02/02/06
- 99-018 - 04/20/06
- Campaign - Vehicle Warranty Extension
- 02-025 - 11/12/2002
- 98-019 - 05/13/05
- 06-001 - 01/16/06
- 03-081 - 11/04/03
- 03-064 - 11/04/03
- 01-077 - 01/12/05
- 00-009 - 03/04/03
- 99-070 - 05/28/02
- 98-011 - 02/05/02
- 04-029 - 2004/06/11
- Lighting - Lo Beam Intermittently Does Not Come On
- Recall - Headlamp Low Beams Inoperative
- Campaign - Warranty Extension For Odometer Inaccuracy
- Body - Recommended Repair Materials
- Body - Recommended Sealers And Adhesives
- Body - Recommended Sealers/Repair materials
- Body - Tailgate Spoiler Foam Strip Hanging Down
- Navigation System - System Information
- Navigation System - Inspection/DVD Information
- Navigation System - Warr. Exchange/Non-Warr. Repair
- Navigation System - DVD Information And Inspection
- Navigation System - DVD Information and Inspection
- Navigation System - Warranty Exchange/Repair
- Navigation System - DVD Service Information
- Navigation System - Exchange/Repair Guidelines
- Navigation System - DVD Information
- Navigation System Exchange/Repair Guidelines
- Navigation System DVD Information
- Navigation System - Information/Operation/Service
- Navigation System - DVD Information/Identification
- Navigation System - Controls/Operation/Initialization
- Navigation System - Personal Addresses Can't Be Viewed
- Instruments - Navigation Screen Reverses Color
- Audio/Navigation/RES - Warr. Exchange/Non-Warr. Repair
- Audio/Navigation/RES Unit - Warranty Exchange/Repair
- Audio/Entertainment/Navigation - Service/Warranty Info.
- Audio/Navigation/RES - Warr. Exchange/Non-Warr Repair
- Audio/Entertainment/Navigation - Service/Exchange
- 12-070 - 03/21/13
- Antitheft System - Immobilizer System (Type 2)
- Antitheft System - Type 2 System Operation/Programming
- Keyless Entry - Transmitter ID/Programming
- Keyless Entry - Remote Transmitter Information
- Audio/Navigation/RES/iMID(R) - Warr Exchange/Non Warr Repair
- Restraints - Occupant Detection Initialization
- Campaign - OPDS Unit/Sensor Warranty Extension
- SRS - Indicator Lamp ON/Multiple DTC's Set
- Campaign - OPDS Unit Warranty Extension
- Campaign - OPDS Sensor/Unit Warranty Extension
- Recall - SRS Module Reprogramming
- Recall - SRS Module Reprogramming
- Recall - Driver's Air Bag Over-Pressurization
- 08-093 - 12/08/11
- Recall - Driver's Air Bag Replacement
- 07-030 - 06/15/07
- A/C - Rear Blower Motor Won't Operate
- A/C - Rear Blower Motor Inoperative
- Suspension - Front Stabilizer Link Clunking Noise
- Electrical - GR8 Battery Diagnostic Station Update Info.
- Electrical - GR8 Battery Diagnostic Station Update
- Electrical - Battery Testing And Replacement
- Electrical - GR8(R) Battery Diagnostic Station Update
- Electrical - ED-18 Battery Analyzer Update Information
- Electrical - Battery Testing and Replacement
- Electrical - Battery Test Procedure/Equipment
- Battery - Testing Procedures
- Battery - Testing Procedure
- Disc Brake System - Brake Disc Refinishing Guidelines
- Brakes - Brake Disc Refinishing Guideline
- 07-028 - 10/30/07
- Drivetrain - Ping/Squeal/Rattle On Light Acceleration
- Recall - A/T, 2nd Gear Inspection
- Recall - A/T Second Gear Inspection
- Recall - A/T 2nd Gear Inspection, Update
- Fuel System - Accelerator Pedal Hard to Press
- Emissions - Engine Hesitates Under Light Acceleration
- Computers/Controls - Updating Control Units/Modules
- Computers/Controls - Module/Control Unit Updating
- Campaign - EGR Warranty Extension
- Engine Controls - Updating ECM/PCM Software
- Computers/Controls - HIM Module Updating
- Engine Controls/Emissions - OBD II DTC's and Monitors
- Computers/Controls - Updating Modules/Control Units
- Computers/Controls - Updating Control Units And Modules
- Computers/Controls - Control Unit/Module Reprogramming
- Computers/Controls - Updating Modules/Control Units
- Engine Controls - Control Module Programming Procedure
- Drivetrain - Rattle/Ping/Squeal on Light Acceleration
- Vehicle - Recommended Materials
- Campaign - Timing Belt Tensioner Replacement
- Recall - Water Pump/Timing Belt Tensioner Replacement
- Recall - Water Pump/Timing Belt Tensioner
- Engine - V6 Engine Oil Leaks
- Engine - Cylinder Block Oil Leaks
- Vehicle - Recommended Service Materials
- Drivetrain - Noise/Judder From Rear When Turning
- Drivetrain - Rear End Noise/Judder When Turning
- Drivetrain - Rear Differential Noise/Judder on Turns
- Steering/Suspension - Vehicle Pulls Right/Left
- Steering/Suspension - Vehicle Pulls/Drifts To One Side
- Steering/Suspension - Vehicle Pull/Drift To One Side
- Steering - Vehicle Pulls/Drifts to the Left/Right
- All Technical Service Bulletins
- A/T - New ATF DW-1 Available
- Campaign - OPDS Unit Warranty Extension
- Restraints - OPDS Unit Initialization Procedure
- Vehicle - Recommended Service Materials/Sealers/Lubricants
- Recall- Headlamp Low Beams Inoperative
- Recall 12V136000: Headlamp Low Beams Inoperative
- Recall - Driver's Air Bag Over-Pressurization
- Navigation System - System Information
- Keyless Entry - Keyless Remote Transmitter Information
- Electrical - ED-18 Battery Analyzer Update Info.
- BULLETIN CANCELLATION NOTIFICATION
- Tools - Required Special Tools And Equipment
- ABS DTC 51 Or 53 - Diagnostic Tip
- ABS - Grunts When Doing A Self-Check
- Fuel Gauge Sending Unit - Service Manual Revision
- Odometer - Does It Rack Up Miles When Towed
- A/C - System Performance Testing
- A/C - Poor Cooling During Hard Acceleration
- A/C - Heater Blows Cold Air, A/C Blows Warm Air
- Power Steering Pump Noisy
- Engine - Ticking Noise After Cyl Head Gasket Replacement
- Engine Oil Recommendations
- Engine Cranks But Doesn't Start, Immobile Light Blinks
- A/T Or Engine Noise At 4,200 RPM
- Buzzing Or Clicking On Hard Acceleration
- Gas Tank - Fuel Pump/Sending Unit Installation Tip
- Brakes - Rear Brake Clunk Sound
- Blower (Heater) Motor Gets Hot and Blows A Fuse
- Body/Suspension - Creaking/Ticking Noises
- Wheel Bearing Noise After A/T Replacement
- Recall - Water Pump Replacement
- Suspension - Clicking Noise From Right Rear
- Body - Tailgate Pops/Scrapes Upon Opening
- Body - Door(s), Clicking/Creaking Noises on Bumpy Roads
- Driveline - Hissing Between 30 and 50 MPH
- A/T - Leak From Cooler Line Banjo Bolt
- A/T - Avoiding Fluid Contamination
- A/T - Fixing Banjo Bolt Leaks
- A/T - Oil Jet Hoses Now Available
- A/T - Do Not Remove Torque Converter From Mainshaft
- Emissions/Engine Controls - MIL ON/DTC P1457 (EVAP)
- Engine Controls - Idle Fluctuation/MIL ON/DTC P1129
- Drivetrain - Revised CV Joint Boot Band/Installation
- Oil Pressure - Low Indicator Blinks On Start-up
- Thump When Accelerating Or Braking
- Catalytic Converter - Rotten Egg Smell
- Exhaust System - Catalytic Converter Noise
- Navigation System - Reboots/Incorrect Displays
- Audio System - Hands Free System Mute Logic
- Interior - Seat Belts Slow to Retract
- Restraint System - Seat Belt Tongue Stopper Position
- Driver's Air Bag - Replace Torx Bolts Properly
- Suspension - Drifting and Pulling At Highway Speeds
- Door - Clicking Noise Going Over Rough Roads
- Interior and Exterior Trim - Tool To Make Removal A Snap
- Center Console Lid Doesn't Latch Or Stay Latched
- Air Fresheners - Bad News For Paint Or Plastic
- Water Leak From Door. Check Rain Protector
- Roof Rack - Wind Noise
- Wind Noise - Simple Way To Replicate
- Accessory Security System - Troubleshooting
- Audio Unit - Electronically Retrieving Serial Numbers
- Audio Unit - Models Which Are Electronically Retrieval
- Alarm/Security System - Troubleshooting
- Keyless Remote Unlocks Gut Doesn't Lock Doors
- Navigation System - Serial Number Location
- Security System Doesn't Arm
- HomeLink (R) - Skimpy Range
- No Reman Program For I-VES (R)
- SRS - DTC 15-1, No.7 Fuse Blows, Rear Wiper Inop
- Fuel Filler Cap Adapter Available For Testing Emissions
- Clearing DTCs and Setting ECM/PCM With The HDS
- DTC P1457 - Check For a Twisted EVAP Purge Hose
- Engine Conrtols - Got DTC P0128? Replace PCM
- Engine Controls - DTC P0171 Set
- Engine Controls - DTC P0172
- Engine Controls - Clearing DTC's
- Clock Gains or Loses Time
- Windshield Washer Nozzle Troubleshooting
- Wind Noise At The Hood Air Deflector Seal
- Windshield Wipers - Blade Care and Replacement
- LIghts - Tailight Reflector is Loose or Distorted
- Engine - Oil Recommendation GF-4 Standard
- Recall 04V176000: Potential A/T Gear Failure
- DTC P0710 Set - Possible ATF Temp Sensor Faulty
- A/T Whine - Test Drive Tip
- A/T - Don't Test Drive With The MIL Or D Indicator On
- A/T - Removing Stubborn ATF Filler Bolt
- A/T - Replenishing ATF On Vehicles With A/T Oil Jet Kits
- Emissions - Hesitation/Surge Between 30 and 60 Mph
- Body - Accessory Hood Air Deflector Cracks
- Dashboard Switch Not Lit,? Replace Bulb, Not Switch
- SRS - Indicator ON with No SRS DTC Set
- Air Deflector - Wind Noise
- Audio System - Never Play CD's With Adhesive Labels
- Navigation System - Multiple Symptoms
- Navigation System - Setup and Operation
- Navigation System - Changing or Removing PIN
- Replacing Navigation Sys DVDs Can Cause DVD Disc Error
- Navigation System - Replacing Lost or Damaged DVD's
- Ignition/Locks - Cutting Sidewinder-Type Keys
- Interior - Side-to-Side Looseness in Driver's Power Seat
- Restraints - Child Seat Anchor Locating Button Missing
- Body - Plastic Body Clip Removal Tips
- Recall - Timing Belt Tensioner/Water Pump Replacement
- Campaign - Timing Belt Auto-Tensioner Replacement
- Tires - Tubless Tire Repair Information
- Electrical - Horn Honks By Itself On Bumps
- Engine - Idle Vibration/Harsh Shifting
- Paint - Industrial Fallout Paint Damage
- Suspension - Front End Rattles On Bumps
- Body - Unibody Repair Guidelines
- Music Link(R) - System Information/Diagnostics
- A/C - Rear Blower Motor is Inoperative
- A/C - Refrigerant Leak Detection
- Body - Tailgate Spoiler Foam Strip Hangs Down
- Fuel System - Accelerator Pedal Popping/Sticking/Binding
- Engine - Oil Leaks From Front/Middle/Rear of Engine
- Campaign - EGR System Contamination/Clogging
- Campaign - Vehicle Warranty Mileage Extension
- Drivetrain - Noise/Judder From Vehicle Rear When Turning
- Steering/Suspension - Vehicle Pulls Left/Right
- Campaign - SRS Control Unit Replacement
- Electrical - Battery Testing and Replacement Information
- Engine - Connecting Rod Damage Information
- A/C - Heater Blows Cold Air/A/C Blows Hot Air
- A/T - ATF Cooler Cleaner Information
- Emissions - OBD II DTC's And Associated Monitors
- A/T - Vehicle Speed Sensor Installation Precautions
- Electrical - Battery Replacement Precautions
- Recall 10V041000: Air Bag Inflator Replacement
- Starting System - Unable To Key In Ignition Switch
- Accessories - HomeLink(R0 Troubleshooting Considerations
- Computers/Controls - Initialization Procedure Info.
- Engine Controls - Test Drive Precautions
- Audio System - CD/DVD Precautions
- Interior - Fabric Upholstery Wrinkle Information
- Body - Chrome/Stainless Trim Staining Information
- Brakes - Brake Disc Refinishing Information
- Navigation System - 2.11C Patch for Various Issues
- Navigation System - DVD and HDD System Information
- A/T - Cooler Flushing Equipment Information
- Recall 12V573000: A/T Shift Interlock Lever Replacement
- Electrical - GR8 Battery Diagnostic Station Update Information
- Antitheft - Immobilizer System (Type 2) Information
- Computers/Controls - Updating Control Units/Modules
- Audio,Navigation, RES - Warr. Exchange/Non-Warr. Repair
- Recall - Ignition Key Removable With A/T Not In Park
- Cell Phone - Programmable HFL (HFT) Unit Update Info.