Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Customer Interest
- A/C - Odor From the Ventilators
- A/C - Poor Heater Output
- Engine - Idle Vibration In D Range
- Hydraulic Lash Adjusters - Noisy
- Front Brakes - Squealing Noises
- Front Brakes - Squealing, Pulsation
- A/C - Small Amount of Air Comes from Center Vents
- Front Strut - Noise While Turning
- Front End - Snapping Noise
- Steering Gear - Fluid Loss
- Timing Belt - Rubbing Noise from Front of Engine
- Timing Belt - Squeal or Whine Noise
- Engine - Noise On Initial Start Up
- HLA - Noise After Long Storage
- Rear Door Weather-Strip Breakage
- Door Weatherstrip - Wind Noise Around Doors
- Clutch - Squealing Upon Release
- A/T - Throttle Cable Won't Move After Rebuild Install
- Brakes, Rear - Noise/Squeal
- Brake, Rear - Noise
- Brakes, Rear - Squealing Noise
- Front Caliper - Noises Upon Light Braking
- Front Brake Caliper - Popping Noise When Braking
- Seat Belt - Will Not Retract/Hard to Pull Out
- Heater Core - Water Leaking Through Firewall
- Steering Wheel - Slightly Off Center.
- Steering Wheel - Is Slightly Off Center
- Power Door Lock - Difficult to Operate
- Power Door Locks - Stiff Operation
- Speakers, Door - Poor Sound Quality from Water Damage
- Speakers, Rear - No Sound or Intermittent Sound
- Trunk Lid - Does Not Remain Fully Open
- Door Mirror - Driver's Side Vibration
- Bumper Face - Deforming
- Wheel Cover - Damage Due to Improper Installation
- Engine - Vibration at Idle
- Engine - Idle Vibration or Rough Idle In DRIVE Range
- Fuel Filler Door - Will Not Open When Activated
- Cowl Grill Protector - Unfastened
- Retractor Switch - Seat Belt Lamp/Buzzer ON
- Seat Belts - Warning Lamp/Buzzer ON
- Front Door Assist Grip - Breakage
- Outer Door Handle - Loose/Rattles
- Rear Speakers - Intermittent or No Sound
- Engine - Top End Noise
- M/T - Hard or Grinding Noise When Shifting to Reverse
- M/T - Hard Shifting To Reverse Gear
- Chemicals,Additives
- Labor/Parts Updates
- Manual Updates
- Seals, Gaskets
- Superceded Bulletins
- S00390 - 03/27/90
- P00394 - 02/11/93
- P00393 - 05/26/93
- P00193 - 05/19/93
- N00196 - 04/15/98
- K00598 - 04/22/98
- H00295 - 04/05/95
- H00295 - 05/17/97
- G00397 - 06/19/97
- B00994 - 01/19/95
- B00893 - 11/05/93
- B00695 - 04/27/95
- B00695 - 06/02/95
- S0802297 - 12/28/97
- ST00294 - 10/25/94
- U00194 - 02/28/94
- 15070-88 - 06/19/97
- Body - Wind Noise Around Doors
- Bumper - Pre-Painting Procedures
- Speakers, Rear - No/Intermittent Sound
- Air Bag System - Effect of Aftermarket Accessories
- A/C System - Tracer Dye Leak Detection
- Battery - Test Procedures
- Brakes - Vibration, Pulsation
- Brakes - Judder When Applying
- Brakes - Pedal Pulsation/Squealing Front Brakes
- Front Brakes - Squealing Noise
- Brake Caliper, Front - Knocking Noise When Braking
- Clutch - Squealing When Released
- Clutch - Squeal Noise
- A/T - Throttle Cable Jammed After Installing Rebuild
- A/T Cooler/Line - Flushing Procedure
- Throttle Position Sensor - New Inspection & Adjustment
- EGI Control Units - Replacements Now Remanufactured
- Engine - Partial Engines Available
- Hydraulic Lash Adjuster - Noise
- Steering Wheel - Off Centered
- Steering Wheel - Slightly Off Center
- Reconditioned Anti-Freeze - Recommendations
- Engine - Noise On Intial Start Up, Decreases When Warm
- All Technical Service Bulletins
- Interior - Console Damage Prevention During Removal
- Fuel System - Fuel Ethanol Content Testing
- Mirrors - Door Mirror Glass Is Loose
- Wheels/Tires - Tire Pessure/Rotation Information
- Mirrors - Interior Mirror Removal
- Electrical - Lightning Strike Information
- Wheels - Aluminum Wheel Cleaning Precautions
- Special Tools - Storage Cabinet System
- Required Tools - Inventory List
- Tools - Shipment Of NGS Program Card Version 2.0
- Emission Inspection Test - Proper Preparation
- Emissions - Proof of Recall Correction Certificate
- Engine, Transaxle & Electrical - Manual Corrections
- Overview
- Revisions For 2WD
- Page B1-56
- Page B2-56
- Page F-76
- Page J1-31
- Page K-96
- Page K-106
- Page K-158
- Page K-168
- Page K-169
- Page K-172
- Page K-178
- Page K-179
- Page K-180
- Page K-181
- Page K-182
- Page K-185
- Page K-197
- K-198
- Page K-202
- Page K-205
- Page K-217
- Page K-218
- Page K-222
- Page K-228
- Page K-230
- Page K-232
- Page K-233
- Page K-234
- Page K-235
- Page K-236
- Page K-246
- Page K-247
- Page K-248
- Page K-249
- Page K-250
- Page K-251
- Page K-252
- Page K-253
- Revisions For 4WD
- Engine, Cruise Control - Manual Corrections
- A/T - Proper Control Unit Connection
- Vehicle - Beginning VINS
- A/C - 0 Ring Replacement
- A/C - O Ring Installation Procedure
- A/C - Odor From the Ventilators
- A/C - Recommended Procedure for Charging & Handling R-12
- A/C - O Ring Replacement
- A/C - Poor Heater Output
- Engine - Idle Vibration In D Range
- Hydraulic Lash Adjusters - Noisy
- Coolant - Propylene Glycol Based Not Recommended
- Battery - Dies In A relatively Short Period Of Time
- Throttle Position Sensor - Revised Inspect & Adjustment
- Electronic Devices/Electrical - Diagnosis and Repair
- Front Brakes - Squealing Noises
- Front Brakes - Squealing, Pulsation
- A/C Compressor - Vane Noise Troubleshooting
- A/C Compressor - Noise Replacement Criteria
- A/C - Small Amount of Air Comes from Center Vents
- Front Strut - Noise While Turning
- Front End - Snapping Noise
- Steering Gear - Fluid Loss
- Timing Belt - Rubbing Noise from Front of Engine
- Timing Belt - Squeal or Whine Noise
- Engine - Noise On Initial Start Up
- HLA - Noise After Long Storage
- Engine - Partial Repair Components Available
- Engine Valve Seal - Identification
- Engine - Valve Seal Identification
- Receiver Dryer - Replacement Criteria
- Tire Chains - Installation Precautions
- Bumper - Painting Preparation
- Rear Door Weather-Strip Breakage
- Door Weatherstrip - Wind Noise Around Doors
- Clutch - Squealing Upon Release
- Throttle Cable Bracket - Modification, Adjust Procedure
- A/T - Throttle Cable Won't Move After Rebuild Install
- EGI Control Unit - Remanufactured Exchange Program
- MIL Lamp On, DTC 15 Oxygen Sensor Set
- Air Flow Meter - Service Precautions
- Brakes, Rear - Noise/Squeal
- Brake, Rear - Noise
- Brakes, Rear - Squealing Noise
- Front Caliper - Noises Upon Light Braking
- Front Brake Caliper - Popping Noise When Braking
- Rear Wheel Cylinder - Improved Design
- Battery - Dead After Key Mistakenly Left On ACC
- Battery - Ignition OFF Draw Current Diagnosis
- Battery - Diagnostic and Charging Procedures
- Throttle Adjustment Screw - Adjustment Precaution
- Seat Belt - Will Not Retract/Hard to Pull Out
- Brakes - Rotor and Drum Inspection Criteria
- Brakes - Use On Car Brake Lathe to Correct Judder
- Speedometer Cable - Service Parts
- Speedometer - Replacement Procedure
- Wiper Motor - Inoperative/Circuit Breaker Operation
- Heater Core - Water Leaking Through Firewall
- A/T, Brakes, Transaxle - Manual Revisions
- Steering Wheel - Slightly Off Center.
- Steering Wheel - Is Slightly Off Center
- NGS System - Reprogramming Service
- Year 2000 - Computer Systems Compliance
- Star Tester - New Version Program Cards
- Power Door Lock - Difficult to Operate
- Power Door Locks - Stiff Operation
- Speakers, Door - Poor Sound Quality from Water Damage
- Speakers, Rear - No Sound or Intermittent Sound
- Trunk Lid - Does Not Remain Fully Open
- Door Mirror - Driver's Side Vibration
- Bumper Face - Deforming
- Coolant - Reconditioned Antifreeze, Not Recommended
- Wheel Cover - Damage Due to Improper Installation
- A/T - Diagnostic Procedures
- A/T - Revised Line Pressure Adjustment
- A/T - Problems W/Aftermarket Accessories to Wired EC-AT
- A/T - Specified Manual Shift Lock Nut Torque
- A/T - Repair Policies
- A/T - ATX Line Pressure Adjustment
- A/T - G4A, 4EAT Sprag Rotation
- A/T - G4A, 4EAT Pressure Tap Locations
- A/T - G4A, 4EAT Valve Body Identification
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - G4A-HL Valve Body Orifice Locations
- A/T - G4AEL, G4AHL, F4EAT, F4AEL Shift Feel Complaints
- A/T - Failsafe Modes
- A/T - Low OR No Line Pressure Rise/Worn Throttle Cam
- A/T - Reverse Piston Return Spring Revised
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Overhaul Information
- Engine - Vibration at Idle
- Engine - Idle Vibration or Rough Idle In DRIVE Range
- Fan, Additional - Improper Operation
- Fuel Filler Door - Will Not Open When Activated
- Fuel Injector - Cleaner Kit for Improved Performance
- Cruise Control - Manual Corrections
- Cruise Control - Operation Revised
- Cruise Control - OE Replacement Recommended
- Alignment - Background Information & Specifications
- Cowl Grill Protector - Unfastened
- Retractor Switch - Seat Belt Lamp/Buzzer ON
- Seat Belts - Warning Lamp/Buzzer ON
- Front Door Assist Grip - Breakage
- Outer Door Handle - Loose/Rattles
- Rear Speakers - Intermittent or No Sound
- Engine - Top End Noise
- A/C Refrigerant - Recommendations
- A/C - R134a Training/Equipment Requirements
- M/T - Hard or Grinding Noise When Shifting to Reverse
- M/T - Hard Shifting To Reverse Gear
- A/C - O-Ring Replacement
- Fuel Volatility - Driveability Concerns
- Fuel - California Reformulated Gasoline
- Pre Alignment - Specifications
- Wheels - Wheel Lock Installation Precautions
- Wheels - Stain Prevention Information
- Body - Service Bumper Specification Change
- Fuel System - Ethanol Fuel Usage