Recall - Fuel Line Leakage
Bulletin No.: 005/96Issued: 03/12/96
Revised:
Category
F
Applicable Model/s
1993-94 RX-7
Subject
SERVICE POINTS FOR FUEL LEAKAGE RECALL VEHICLE
APPLICABLE MODELS
1993 - 1994 RX-7 vehicles with a VIN of JM1FD33**P0303550 and lower.
DESCRIPTION
Under the repair for vehicles subject to recall campaign No. 60504, the fuel pipe is adhered at three (3) points ("A", "B" and "C") as shown. The following procedures may be used when removing the fuel hose and the fuel pipe from these points.
SERVICE POINTS
1. Once the fuel hose is removed from any of the three (3) points, do not reuse the hose.
2. Install a new hose supplied in the campaign kit.
3. Install new clips.
NOTE:
It is not necessary to apply adhesive to the new hoses for the following reasons:
^ The adhesive (supplied with the campaign repair kit) is a curing solution used to accelerate drying time.
^ The adhesive is primarily used as a lubricant to facilitate installation.
^ New hoses have adhesive applied and do not require additional adhesive.
^ Availability and maintenance of the adhesive at the dealer level.
When removing an engine from any of the above mentioned vehicles, disconnect the main fuel line from the other side of the adhered spot (Refer to area "C").