Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Lighting - Headlamp Unit Fogged/Droplets Forming
- A/T - ECO Start/Stop Inoperative, DTC P0944 Stored In TCM
- Lighting - Headlamps/Front Fog Lamps Leaking Or Fogged
- A/C - HVAC - Foam Cleaner Information and Work Procedure
- Suspension - Strut/Shock Absorber Replacement Guidelines
- COMAND(R) System - Instrument Display Not Centered
- Fuel System - Hard Start After Fuel Filter Replacement
- Body - Scraping Noise From Transmission Tunnel Area
- Instruments - Fuel Gauge Inaccuracy
- Body - Windshield/Rear Glass Body Seam Corrosion
- Cruise Control Inoperative
- Body - Trunk Lid Won't Stay Open
- Body - Side Window(s) Open After One-Touch Closing
- Brakes - Pedal is Hard to Apply
- Audio System - Various CD Player Malfunctions
- Lighting - Fog Lamp Bulb(s) Inoperative
- Instruments - Cannot Enter Total Mileage Into Cluster
- Gasoline Engine - Oil Sludging
- Engine - Supercharger Clutch Rattling/Squealing Noise
- Wipers/Washers - Wipers Chattering/Noisy
- Electrical - 'ESP Visit Workshop' Message Displayed
- Entertainment System - CD's or DVD's Won't Eject
- Interior - Seat Noise Complaints
- ABS/TCS - ESP Lamp ON/Code C1142 Set
- ABS/TCS - ABS/ESP Lamps ON/Codes C1140/C1540
- Keyless Entry - LED on Transmitter Key Not Functioning
- ABS - Engine No Start/Limp Home/Multiple Codes Set
- ABS/TCS - ESP Visit Workshop Message Displayed
- A/T - Fluid Leaks at The Electrical Connector
- Garage Door Opener - Range Too Short/Can't Program
- Interior - Seats are Dirty/Stained
- Lighting - L/R Turn Signal/Headlamp Constantly ON
- Body - Door Frame Corrosion
- Body - Trunk Lid Corrosion Near Lock Cylinder
- Parking Assist System - Erroneous Activation
- Keyless Entry - Various Malfunctions
- Accessories - Can't Program Garage Door Opener
- A/C - No Or Low A/C Cooling Performance
- ABS/TCS - ESP Lamp ON/Codes C1401 Or C1405
- Brakes - ABS Pump Runs Continuously/Code C1401 Set
- Audio System - AM/FM Interference With Rear Defogger ON
- Body - Windshield/Rear Window Body Seam Corrosion
- Engine - Oil Level Message General Information
- ABS/TCS - ESP/BAS Warning and Service Light ON/DTC's Set
- A/T - Harsh Engagement From Park To Drive
- Drivetrain - Noises at Full Lock From Front Axle Area
- Computers/Controls - Malfunctions Of Various Power/Control Unit
- Superceded Bulletins
- S-00_40-89A - 08/10/10
- S-00_40-89 - 08/09/10
- P-46_25-71 - 01/19/10
- S-54_21-244 - 7/8/11
- S-07_61-89 - 7/08/11
- S-01_45-26 - 05/15/09
- S-82_70-475 - 11/14/05
- S-68_05-47 - 04/11/06
- S-46_30-40A - 11/27/07
- S-46_30-40 - 04/26/06
- S-18_00-17E - 06/01/06
- S-18_00-17D - 04/13/06
- S-18_00-17C - 12/09/04
- S-18_00-17B - 07/21/04
- S-18_00-17A - 07/31/02
- S-18_00-17 - 05/09/02
- S-32_25-19 - 12/30/04
- S-32_25-19A - 03/15/06
- S-32_25-19B - 05/05/06
- S-32_25-19C - 07/18/07
- S-32_25-19D - 10/18/07
- S-46_25-37 - 02/01/08
- S-18_00-36 - 01/01/06
- P-27_00-47E - 01/19/07
- P-27_00-47D - 05/01/06
- P-42_45-61 - 05/13/05
- P-27_00-47B - 04/05/05
- S-98_00-13J - 08/01/05
- S-60_00-008 - 12/01/00
- S-58_30-103 - 12/01/00
- S-05_091 - 05/01/01
- S-05_010 - 05/01/01
- P-82_62-169A - 09/25/01
- P-47_10-16 - 10/01/01
- P-40_10-33 - 10/01/01
- P-18_00-17 - 05/09/02
- P-27_00-47 - 10/01/04
- Wipers/Washers - Maintaining Wiping Quality
- Electrical - Horns Do Not Operate Correctly
- Lighting - Headlamp Lens Fogged Or Droplets Forming
- ABS/TCS - ESP/BAS Visit Workshop Message/Codes Set
- Paint/Body - MBUSA Approved Refinishing Products Update
- Paint/Body - MBUSA Approved Refinishing Products
- Paint/Body - Approved Refinishing Products
- Body/Paint - MBUSA(R) Approved Refinishing Products
- Body/Paint - Approved Refinishing Materials
- Body/Paint - MBUSA Approved Refinishing Materials
- Body/Paint - Approved Refinishing Products
- Body - MBUSA Approved Refinishing Products
- Lighting - Moisture in Mirror Turn Signal Lamps
- Chassis/Frame - Dedicated Frame Straightener
- Suspension - Shock Absorber/Strut Replacement Criteria
- Suspension - Shock Absorber/Strut Replacement Guidelines
- Suspension - Strut/Shock Replacement Guidelines
- Suspension - Shock/Strut Replacement Guidelins
- Suspension -Strut/Shock Absorber Replacement Guidelines
- Suspension Strut/Shock Absorber Replacement Guidelines
- Steering - Flow Noises/Fluid Foams in Reservoir
- Electrical Part Incompatibility Malfunctions
- Restraints -Repair And Diag. Of Airbag Wiring Harnesses
- Antitheft System - 'Replace Key Battery' Message Displayed
- Charging System - Voltage Regulator Inspection/Testing
- Charging System - Voltage Regulator Testing/Inspection
- LI42-45_P-048852 - 02/03/10
- A/T - Fluid Leaks at Electrical Connector
- A/T - 722.6 Oil Leaks From Electrical Connection
- Engine Controls - Engine Control Module (N3/10) Flashing
- Computers/Controls - Malfunctions Of Various Power/Control Uni
- Engine - Oil Sludging Causes/Remedies
- Engine - Approved Engine Oils
- Instruments - Low Oil Level Messages Displayed
- A/C - Not Cooling/Compressor Noise
- Engine - Oil Level Display and Measurement
- Engine - Approved Oils Information
- Steering - Approved Hydraulic Fluids
- A/T - Fluid Specification Changes
- All Technical Service Bulletins
- Keyless System/Instruments - 'Replace Key Battery' Displayed
- Body/Frame - Dedicated Frame Straightener
- Body - License Plate Bracket Installation Precautions
- Lighting - Headlamp Unit Fogged/Droplets Forming
- A/C - A/C Sealant
- Battery - Battery Charging Information
- A/T - ECO Start/Stop Inoperative, DTC P0944 Stored In TCM
- Steering - Warranty Policy Regarding Steering Wheels
- Restraints - Seat Belt Buckle Warranty Replacement Information
- Lighting - Headlamps/Front Fog Lamps Leaking Or Fogged
- A/C - HVAC - Foam Cleaner Information and Work Procedure
- Parking Assist - Malfunction and Fault Scenarios
- Parking Assist - Parktronic Sensor Return Policy
- Restraints - Repair And Diag. Of Airbag Wiring Harnesses
- Audio/COMAND(R) - Repair Of Wiring Harnesses
- Suspension - Strut/Shock Absorber Replacement Guidelines
- A/T - Operating Fluid Specification Changes
- Brakes/Traction Control - Handling Multipole Rings
- Fuel System - Use Of E10 Fuel
- Brakes - Brake Lining Instructions
- Suspension - Assembly Of Suspension Struts And Shocks
- Transmission Controls - Control Module Flashing Info.
- Steering - Approved Hydraulic Fluids
- Engine Control - Engine Control Module (N3/10) Flashing
- Computers/Controls - Module Programming Precautions
- Charging System - Voltage Regulator, Inspection/Testing
- Paint/Body - MBUSA Approved Refinishing Products Update
- Wheels - Checking Components For Bolted Wheel Connection
- Electrical - Electrostatic Discharge Damage Prevention
- Lighting - Uprated H7 Bulbs
- Electrical - Aftermarket Tampering Malfunctions
- Chemicals/Lubrication - Multi-Grade Metal Grease Info.
- Special Tools - Inventory List
- Special Tools - Storage, Mounting, and Management
- Vehicle - Roadside Assistance Program
- COMAND(R) System - Instrument Display Not Centered
- Engine - Oil Sludging Damage/Class Action Settlement
- Fuel System - Hard Start After Fuel Filter Replacement
- Fuel System - Replacement Fuel Pump Adapter Harness
- Rattling Noises at Idle in Neutral, A/C ON
- MIL ON DTC P1341 is Set
- Engine - Cylinder Wall Damage Assesment
- Electric Suction Fan Runs All The Time, Ignition OFF
- Check List With Engine Running Complaints
- Unsatisfactory Directional/Straightline Stability
- Steering/Suspension - Ball Joint Inspection
- Tires/Snow Chains - Factory Approved Specifications
- Tires - High Performance Tire Storage
- Tires - Maintenance & Inspection
- Tires - Approved Winter/Summer Tires
- Tires - Michelin Pilot Sport A/S(R) Tires Not Approved
- Electrostatic Charge on Seats
- Body - Scraping Noise From Transmission Tunnel Area
- Whistling/Howling From Propshaft When Cold
- DTCs 57/60/63 Control Module Memory Malfunction
- Engine Cannot Be Started
- ASR MIL Comes On After Engine Start, Code C1022
- Engine, Shakes, Misses, and Dies at Idle
- COMAND(R) System - Incorrect ETA Calculation Displayed
- Grease Leaks Out of Front Wheel Hub
- ABS, MIL ON No ABS System Malfunctions
- Battery Safety Notes
- MIL ON Various DTC's Set
- Failure of Power Window Drive
- Audio System - RF Interference Explanation
- Cellular - StarTAC Portable Telephone Programming
- Radio - Cellular Phone and CD Changer Installation
- Telephone Call is Interrupted When Engine Started
- Volume of ``Hands-Free'' System Too Low
- Radio - Fiber Optic Configuration and Cautions
- Cell Phone - Calls Cut Off/Dropped
- Air Bag System - Side Impact Sensor Replacement
- Incorrect Fuel Indication
- Instruments - Fuel Gauge Inaccuracy
- Headlamps/Turn Signals Mist Up or Leaking
- Selector Lever Blocks
- ESP is Activated Even On Slight Curves at Moderate Speed
- ESP System Electrical Components Location
- Maintenance - Factory Approved Service Products
- Special Tool - Resistance Spot Welder
- Special Tool - Resistance Welder
- Special Tool - Spot Welder
- Special Tool - M20 Resistance Welder
- Body/Frame - Dedicated Straightening Equipment
- Body - Windshield/Rear Glass Body Seam Corrosion
- Emission/VIN Label - Availability
- Exhaust System - Rattling/Hissing/Humming Noises
- Computer Software - Y2K Impacts
- Computer Control Systems - Diagnostic Analyzers
- Cruise Control Inoperative
- Body - Trunk Lid Won't Stay Open
- Corrosion at Trunk Lid in Area of Lock Cylinder
- Recall - Infant Restraint/Booster Seat Exchange
- Body - Side Window(s) Open After One-Touch Closing
- Synthetic Oil Recommendations - For FFS Vehicles
- Engine Oil - Approved Evacuation Equipment
- Tools - Universal Valve Spring Tool
- Special Tool - Universal Valve Spring Tool
- Brakes - Pedal is Hard to Apply
- Audio System - Various CD Player Malfunctions
- Main Beam/Low Beam Not Operating
- Lighting - Fog Lamp Bulb(s) Inoperative
- Electric Suction Fan Runs Constantly, Ignition OFF
- Instruments - Cannot Enter Total Mileage Into Cluster
- Gasoline Engine - Oil Sludging
- Engine - Oil Sludging/Consumption Diagnosis & Repair
- Repairing Wiring Harness Using Soldered Terminal
- Electrical - Component Locator, Star Finder
- Interior - Squeaking/Creaking Noise Kit
- Interference to Radio After Installing Window Screens
- Radio Cannot Be Operated
- Radio Inoperative
- Operational Problem Radio/Cassette Player
- Paint Damage to Trunk Lid in Area of Grip
- Operational Problem in Upper Control Panel
- Power Windows, Locks, Wipers, Turn Signals Malfunction
- Emergency Trunk Release - Retrofit
- Color or Brightness Difference of Headlamps
- High/Low Beams Do Not Function
- Engine - Supercharger Clutch Rattling/Squealing Noise
- Side Window Opens After Closing
- Occasional Air Conditioner Failure
- Suspension - New Alignment Tools and Procedures
- Seat Belt - Extensions
- Air Bag System - SRS Lamp ON/Multiple DTC's Set
- Body - Laminated Glass Chip/Crack Repair Information
- Wipers/Washers - Wipers Chattering/Noisy
- Electrical - 'ESP Visit Workshop' Message Displayed
- Entertainment System - CD's or DVD's Won't Eject
- Interior - Seat Noise Complaints
- ABS/TCS - ESP Lamp ON/Code C1142 Set
- Body - Replacement Sheet Metal With Seam Sealer
- A/T - Throttle/Brake Pedal Application Precaution
- ABS/TCS - ABS/ESP Lamps ON/Codes C1140/C1540
- A/C - Fluorescent Dye Leak Testing
- Suspension - Shock/Strut Replacement Guidelines
- Keyless Entry - LED on Transmitter Key Not Functioning
- Wheels - Recommendation Against Chroming Alloy Wheels
- ABS - Engine No Start/Limp Home/Multiple Codes Set
- Paint - Adhesive Residue Removal
- ABS/TCS - ESP Visit Workshop Message Displayed
- A/T - Fluid Leaks at The Electrical Connector
- Steering - Flow Noises/Fluid Foaming After Repairs
- Exhaust System - Exhaust Pipe Chrome Tip Care
- Interior - Interior Damage From Scent Dispensers
- Wheels/Tires - Nitrogen Usage Recommendations
- Garage Door Opener - Range Too Short/Can't Program
- Interior - Seats are Dirty/Stained
- Steering - Power Steering Diagnostic Tips
- Suspension - Shock/Strut Replace Guidelines
- Lighting - L/R Turn Signal/Headlamp Constantly ON
- Body - Door Frame Corrosion
- Body - Trunk Lid Corrosion Near Lock Cylinder
- Body/Lighting - Moisture in Mirror Turn Signals
- Parking Assist System - Erroneous Activation
- Power Steering - Fluid Filling/Bleeding Precautions
- Electrical - Horn Replacement Information
- Keyless Entry - Various Malfunctions
- Accessories - Can't Program Garage Door Opener
- Vehicle - Approved Service Products On WIS
- A/C - No Or Low A/C Cooling Performance
- Wheels - Approved Alloy Wheel Cleaning Product
- Wheels/Tires - Alloy Wheel Radial Crack Information
- ABS/TCS - ESP Lamp ON/Codes C1401 Or C1405
- Brakes - ABS Pump Runs Continuously/Code C1401 Set
- Audio System - AM/FM Interference With Rear Defogger ON
- Cell Phone - Calls Dropped Or Cut Off
- Body - Windshield/Rear Window Body Seam Corrosion
- Body - New Window Glazing Adhesive Repair Kit
- Drivetrain - Axle Mount Service Guidelines
- Brakes - Brake Pad Paste Usage
- Brakes - Caliper Bolt Replacement Information
- Engine - Charge Air Hose Sealing Ring Information
- Lighting - Xenon Headlamp Brightness Explanation
- Wipers/Washers - Wiping Quality Maintenance
- Brakes - Brake Component Corrosion Information
- Vehicle - Maintenance Systems Overview
- Engine - Oil Level Message General Information
- Body - Windshield/Window Glass Bonding System
- ABS/TCS - ESP/BAS Warning and Service Light ON/DTC's Set
- A/T - Harsh Engagement From Park To Drive
- Interior - Floor Mat Safety Information
- Restraints - Air Bag Durability And Reliability
- Audio System - Radio Interruption Information
- Brakes - Brake Rotors Treated With Zinc Dust Spray Paint
- Body - Cleaning Tin-Plated Surfaces
- Emissions - I/m Dynamometer Emissions Testing
- Steering/Suspension - Wheel Alignment Data
- Drivetrain - Noises at Full Lock From Front Axle Area
- Antitheft System - 'Replace Key Battery' Message Displayed
- Computers/Controls - Malfunctions Of Various Power/Control Unit