Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall 95V067000: Loss of ABS Power Assist
- Recall 94V126000: Oil Cooler Hose Damage
- Recall - Fitting Of Protective Oil Cooler Cover
- Recall - Air Bag Control Module Moisture Damage
- Recall 99V109000: Air Bag Control Module Replacement
- Recall - Fuel Filler Hoses
- Recall 94V029000: Fuel Filler, Tank Hoses Cracked
- Recall - ABS Pressure Switch Inspection
- Customer Interest
- A/C - Noise From Rear Unit
- A/C System - Bad Odor
- Electronic Display Unit - `Error Message'
- Instruments - (EDU) Low Fuel Consumption Reading
- Fan Control/Resistor - Failure
- Front Tires - Noise/Rubbing On Full-Lock Turns
- Timing Chain - Rattles/Chatters
- Exhaust - Sulfur Smell
- Air Mixing Damper - Lever Breakage
- Rear Stabilizer Bar Link - Noises
- Front Windows - Binding or Slow During Operation
- Rear Seat Cushion - Difficult To Latch
- Power Seats - Play/Noise
- Door Seals - Re-attaching
- Doors/Roof Seals - Squeaking Noises
- Sunroof - Mechanism Rattles or Malfunctions
- Sunroof - Popping/Gurgle Noise at 35 MPH or Higher
- A/T Kick-Down Cable - May Break
- Clutch Master Cylinder - Multiple Clutch Problems
- Fuel Damper - Noise In the Interior at Idle
- Fuel System - Engine Driveability Problems
- Exhaust - Sulfur/Rotten Egg Smell
- Pedal Potentiometer - Risk of Corrosion at Connector
- MIL (Check Engine Lamp) ON - Driveability (Bad Ground)
- Radio - Poor AM/FM Reception
- Power Window Motor - Fuses Blow
- Rear Window Defogger - Poor Performance
- Cooling Fan - Continuous Running/Dead Battery
- Front Body Structure - Unusual Noises
- Front Grille - Whistling Noise
- Interior - Water Leakage Into Luggage Compartment
- Amplifier - Lack of Bass Response In Rear Speakers
- Trunk Lid Hinge Springs - Noisy
- Windshield - Whistling Noise
- Upper Center Windshield - Whistling Noise
- A/T - ZF 4HP18 Upshift Squak or Moan Noise
- A/T - Noise On 2nd to 3rd Gear Shift
- Engine Mount Bushing - Noise/Vibration
- Climate Control Unit - High Frequency Noise
- Trunk Lid - Wiring Harness Chafing
- Clutch System - Hydraulic Contamination
- Fuel System - Pressure Pulsating Noise
- Fuel System - Tapping/Knocking Noise
- Engine - Poor Starting/Driveability Concerns
- Center Air Vent - Closes By Itself
- Body - Stain/Film On Inside Perimeter Of Windshield
- Factory Modifications
- Labor/Parts Updates
- Recommended Repairs
- Tools, Equipment
- Superceded Bulletins
- 05-06-04-022C - 12/01/06
- 05-06-04-022A - 01/01/06
- 05-06-04-022 - 12/30/05
- 890-18073 - 09/01/99
- 11920275 - 11/01/92
- 09929252 - 09/01/92
- 08900017 - 08/01/90
- 01940429 - 01/01/94
- Roof Seal - Squeaking Noise
- Paint - Color Codes/Cross References
- Grille - Whistling Noise
- Extended Length Seat Belt - Availability
- A/C - R134a Compressors for Converted Systems
- Air Mixing Damper - Installation
- ABS and TC/ABS - Diode Diagnosis & Repair
- Fuel System - Top Tier Gasoline Usage (Canada)
- Fuel System - TOP-TIER Gasoline Usage (Canada)
- Accelerator Pedal - Raising Kit
- Radiator Fan Time-Delay Relay - May Not Shut Off
- Power Windows - Revised Motor Fuse Rating
- Spark Plug - Reference
- All Technical Service Bulletins
- TSB 0178291 Dated 01/01/78 is No Longer Available
- Expander Rivet Extraction Tool
- Tool - Revised Tip for Connector Pin & Socket Removal
- Owner's Manual - Correction
- VIN Number - Location
- SAE J130 Terminology - US Emissions Components
- Recall 95V067000: Loss of ABS Power Assist
- A/C - Noise From Rear Unit
- A/C - R12 to R134a Refrigerant Retrofit
- A/C System - R12 to R134a Conversion/Retrofit
- A/C System - Bad Odor
- Steering/Suspension - Service Manual Revisions
- M/T - New Preload Adjustment Method
- M/T - Adjustment of Output Shaft Bearing Tension
- Tool - For Relieving Strain on Engine
- Engine, Tires - Revisions to Service Manual
- Recall 94V126000: Oil Cooler Hose Damage
- Throttle Potentiometer - Fault Code Testing Procedure
- Rear Brake Pad - New Design
- Brake Pad - Revised Recommendations
- Brake Pads - Approved Designs/Applications
- Brakes - Brake Pad Information
- EDU Temperature Warning Function - Programming
- Electronic Display Unit - `Error Message'
- Instruments - (EDU) Low Fuel Consumption Reading
- Spark Plug - Application Reference
- A/C System - R134 Conversion Compressors
- Fan Control/Resistor - Failure
- Spring Struts/Shock Absorbers - Microfiche Correction
- Front Tires - Noise/Rubbing On Full-Lock Turns
- Crankshaft Pulley Bolt - Socket
- Timing Chain - Rattles/Chatters
- Engine Block - Pitting Correction
- Engine Block - Deck Surface Pitting
- Exhaust - Sulfur Smell
- Air Mixing Damper - Lever Breakage
- Recall - Fitting Of Protective Oil Cooler Cover
- Rims/Tires - Vibration Diagnosis
- Radial Tire - Repair
- Rear Stabilizer Bar Link - Noises
- Front Windows - Binding or Slow During Operation
- Rear Seat Cushion - Difficult To Latch
- Power Seats - Play/Noise
- Door Seals - Re-attaching
- Doors/Roof Seals - Squeaking Noises
- Sunroof - Mechanism Rattles or Malfunctions
- Sunroof - Popping/Gurgle Noise at 35 MPH or Higher
- Special Tools - Transmission and Headliner Repair
- Outboard Drive Shaft CV Joint - Normal Noise
- A/T - ATF Filtering Kit
- Speedometer - Gear Application
- A/T Kick-Down Cable - May Break
- Clutch Master Cylinder - Multiple Clutch Problems
- Accelerator Pedal - Raising Kit.
- Fiche Correction - Cable Terminal for Trionic ECM
- Speedometer Sensor - Microfiche Correction
- CV Joint - New Boot Clamps
- Tool - For Installing CV Joint Boot Clamps
- ABS/TCS/ASR/ETS - Exchange Components
- Special Tool - Battery Tester 311
- Alternator - Exchange Component Part Numbers
- Ignition Discharge Module - Special Tool
- Pre-Replacement Check of Ignition Discharge Module
- Fuel Damper - Noise In the Interior at Idle
- Fuel System - Engine Driveability Problems
- Exhaust - Sulfur/Rotten Egg Smell
- Pedal Potentiometer - Risk of Corrosion at Connector
- MIL (Check Engine Lamp) ON - Driveability (Bad Ground)
- Radio - Poor AM/FM Reception
- Power Windows - Revised Motor Fuse
- Power Window Motor - Fuses Blow
- Radio - Interference When Tuned to Weak Stations
- Rear Window Defogger - Poor Performance
- Alarm - Electronic Control Supercedes Older Models
- Phone System - (Griffen) Troubleshooting
- Mobile Telephones - Factory Connectors
- Mobile Telephones - Dash Connector
- Seat Belt Button - Replacing
- Extended Length Safety Belt - Availability
- Front Airbag Front Sensor - Captive Nut Replacement
- Recall - Air Bag Control Module Moisture Damage
- Recall 99V109000: Air Bag Control Module Replacement
- Engine Oil Filters/Drain Plug Gaskets - Part Numbers
- Brake Rotor - Measuring Fixture
- Main Bearing Caps - Torque Revision
- EZK Ignition System - Tester Modification
- Starter - Exchange Component Part numbers
- Cooling Fan - Continuous Running/Dead Battery
- A/C Hose - Replacement Guidelines
- Cylinder Head Gasket - Revised
- Service Manual - Corrections
- ABS System - Diagnostic Procedures
- ABS & TC/ABS System - Diode Locator and Fault Diagnosis
- New Special Tools
- Traction Control System - Installing an On/Off Switch
- TCS - Revised Calibration Procedures
- Campaign - Replace Certain TCS Components
- Steering Wheel - Adjustment
- Sport Steering Wheel - Part Availability
- Tools - Suspension
- Body & Frame - Bodywork Repairs Manual Correction
- Front Body Structure - Unusual Noises
- Front Grille - Whistling Noise
- Interior - Water Leakage Into Luggage Compartment
- SRS - Wiring Harness Installation
- Airbag - Correction to Service Manual
- Vehicle - Technical Tip Bulletin
- SRS System - 10 Year Inspection
- Restraints - Pyrotechnic Device Component Usage
- Technical Tips - PSI Bulletins
- Evaporative System - Leak/Pressure Testing
- ISAT Scan Tool Diagnostics Set - Changes
- Essential Special Tools - New Releases
- ISAT Program Board and Cable - Redesigned
- Tools - ISAT TECH 2
- ISAT Scan Tool - Repair Procedure
- Amplifier - Lack of Bass Response In Rear Speakers
- Trunk Lid Hinge Springs - Noisy
- Rear Hatch Gas Spring - Installation
- Windshield - Whistling Noise
- Upper Center Windshield - Whistling Noise
- Wiper Blades - Care/Maintennance
- A/T - Parts Exchange Information
- A/T - ZF 4HP18 Upshift Squak or Moan Noise
- A/T - Revised
- A/T - Noise On 2nd to 3rd Gear Shift
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - ZF4HP18 Bind In Low/2nd Gear Starts After Rebuild
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Recommended Gearbox Oil
- Gear Shift Lever - Revised Assembly
- M/T Gear Shift Lever - Replacement Procedure Update
- Manual Transmission - Shift Linkage Revision
- CD Autochanger - Data Cable Installation
- Engine Mount Bushing - Noise/Vibration
- Climate Control Unit - High Frequency Noise
- ACC Electronic Control Module - Installation
- Engine Oil Drain Plug - New Style Washer
- Fuse Box Distribution Terminal - Securing
- Tool - New Test Cables for Breakout Box
- Trunk Lid Wiring - Harness Update
- Wiring - Terminal Repair Kit Contents
- Trunk Lid - Wiring Harness Chafing
- Cruise Control - Operation Features
- Cruise Control - Troubleshooting With Breakout Box
- Clutch System - Hydraulic Contamination
- Luggage Compartment - Revised Safety Net
- Windows/Glass - New Installation Sealant
- Right Rear Rubber Floor Mat - Modification
- Radios - M91 in M92 Military Edition Parts Update
- Paint Codes - Applications and Cross Reference
- Paint Colors - Cross Reference & Information
- Recall - Fuel Filler Hoses
- Recall 94V029000: Fuel Filler, Tank Hoses Cracked
- Fuel System - Pressure Pulsating Noise
- Fuel System - Tapping/Knocking Noise
- Engine - Poor Starting/Driveability Concerns
- Recall - ABS Pressure Switch Inspection
- Dash Panel - Production Change
- Fuel Line Non-Return Valve - Dimension Change
- Center Air Vent - Closes By Itself
- Seat Height - Adjustment
- Manual Gearbox - New Oil
- Scheduled Maintenance - Labor Times
- Specialized Fluids, Lubricants and Supplies
- CD Changer - Manual Magazine Release
- CD Autochanger - Water Damage Protection
- Compact Disc Autochanger - Installation Components
- Child Tether Anchorage - Availability
- A/C - Compressor Oil Recommendations
- Fuel System - TOP TIER Detergent Gasoline
- Body - Stain/Film On Inside Perimeter Of Windshield
- Wheels - Chrome Wheel Staining/Pitting/Corrosion