Fastener Tightening Specifications - Engine

Component Torque/Ft. Lbs.

A/C Compressor Front Bracket To Block 35
A/C Compressor Front/Rear Bracket To Head 22
A/C Compressor To Front Bracket 35
A/C Compressor To Rear Bracket 22
Accelerator Bracket To Front Dash 8.8
Accelerator Cable Bracket To Intake Manifold 19
Accelerator Control Cable Stud 5.1
Air Cleaner Duct Clamp [01] 15
Air Cleaner/Resonator Bolts 7.4
Air Cleaner/Resonator Clamps [01] 18
Alternator Positive Terminal 7.4
Alternator To Block 27
Axle Shaft Intermediate Bracket To Block 41
Battery Cable 12.6
Battery Cable To Alternator 7
Belt Idler Pulley To Front Cover 33
Belt Tensioner Pulley 22
Belt Tensioner To Block 22
Block Oil Gallery Plug 22
Camshaft Sprocket To Camshaft 75
Camshaft Thrust Bearing To Head 18
Canister Band Clamp [01] 31
Canister Purge Solenoid To Block 22
Catalytic Converter To Isolator 19
Clutch Pressure Plate To Flywheel 19
Connecting Rod Cap To Rod 33
Coolant/Cylinder Block Heater 19
Coolant Drain Plug 26
Coolant Temperature Sensor 5.9
Cradle To Body 151
Crankshaft Bearing Cap To Block 37
Crankshaft Damper To Crankshaft 159
Crankshaft Position Sensor 6.7
Crankshaft Rear Oil Seal Carrier To Block 8.1
Cylinder Head Core Hole Plug [01] 53
De-Aeration Line Clamp 6.7
De-Aeration Line Fitting To Head 8.1
De-Aeration Line Nut To Head 12.6
De-Aeration Line To Cam Cover [01] 53
EGR Solenoid Bracket 19
EGR Valve Nut To Head 21
EGR Valve Stud To Head 5.1
Engine Block Heater To Block 18
Engine Lift Bracket To Block [06] 36
Engine Lift Bracket To Block [06] 22
Engine Mount To Front Cover 37
Engine Mount To Midrail Bracket 37
Engine Support Bracket 28
ESC Knock Sensor 11.1
Exhaust Manifold Studs To Front Pipe 9.6
Exhaust Manifold Studs To Head 8.8
Exhaust Manifold To Head 16
Exhaust Pipe To Converter 33
Flexplate To Converter 41
Flexplate To Crankshaft 44
Flywheel/Flexplate Cover 7.4
Flywheel To Crankshaft 59
Front Cover To Block (Center) 7.4
Front Cover To Block (Perimeter) 22
Front Engine Mount To Block 52
Fuel Canister Bracket To Frame Rail 22
Fuel Line Support Bracket 22
Fuel Line Support Clip 8.8
Fuel Rail To Intake Manifold 22
Fuel Tank Fill Hose [01] 27
Fuel Tank Fill Pipe [01] 18
Fuel Tank Fill Pipe [01] Bracket 53
Fuel Tank Straps 25
Fuel/Vapor Line To Body [01] 27
Heater Outlet To Intake Manifold 19
Heater Return Nipple 37
Idle Air Control Sensor 28
Idle Air Control Valve [01] 18
Ignition Module To Transaxle Case 5.9
Induction Air Sensor [01] 44
Intake Manifold Bracket To Block (LH) 22
Intake Manifold Bracket To Manifold 21
Intake Manifold Stud To Fuel Line Clamp 5.1
Intake Manifold Stud To Head 8.8
Intake Manifold Stud To Head (P/S Bracket) 15.7
Intake Manifold To Head 22
MAP Sensor [01] 53
Motion Restrictor Bracket 40
Motion Restrictor To Side Of Block 22
Oil Baffle Plate To Block 41
Oil Drain Plug 26
Oil Filter [05]
Oil Pan To Block 6.7
Oil Pipe Bracket To Block 41
Oil Pressure Sensor 26
Oil Pump Cover 8.1
Oxygen Sensor 37
Power Steering Hoses 20
Power Steering Pump Bracket 22
Power Steering Pump To Bracket 28
Power Steering Return Hose Clamp [01] 18
Radiator Upper Bracket 7.4
Rear Engine Mount To Block 35
Rocker Arm Cover To Head 22
Rocker Arm Shaft To Head 19
Spark Plug 20
Starter Bracket To Starter 7.4
Starter Motor 27
Starter Motor Bracket To Axle Shaft 22
Starter Positive Terminal 7.4
Starter Solenoid Terminal [01] 35
Steering Joint To Gear 35
Stiffening Bracket 40
Strut To Knuckle 148
TBI Assembly Fuel Line 19
TBI Assembly To Air Intake Manifold 24
TBI Injector [01] 18
Thermostat Housing To Block 22
Throttle Position Sensor [01] 18
Timing Chain Guides 19
Timing Chain Tensioner 14
Transaxle Case To Block (Lower) 96
Transaxle Case To Block (Upper) 66
Transaxle Lower Mount To Cradle 41
Transaxle Lower Mount To Transaxle 23
Transaxle Rear Mount 36
Vapor Canister To Body 22
Vehicle Speed Sensor [01] 19
Water Pump 22
Water Pump Pulley 18

[01] Inch lbs.
[05] Tighten to gasket, then turn an additional 3/4 to 1 turn.
[06] Less A/C.