Canada - Interior - Various Interior Trim Panels Loose

Bulletin
2567R

Issue Date
July 20, 2006

Market
Canada

Title:
TRIM GARNISH LOOSE

Component
BODY COMPONENT

Models
'91 - '07 All Models

TSB REVISION NOTICE:
- February 21, 2007: In the Parts Information table, the clip numbers for 2007 model year Camry vehicles have been updated.
Previous versions of this TSB should be discarded.

INTRODUCTION:
Customers may experience an interior trim panel either loose or fitting poorly due to a deformed or missing panel attachment clips. When a trim garnish (A, B, C, or D pillar garnish, door trim panel, etc.) is removed and reinstalled using the old clips, there is a possibility that the garnish may exhibit a loose condition. To prevent this condition from occurring, please use the following procedures.

APPLICABLE VEHICLES:
- 1991 - 2007 model year Toyota vehicles.







WARRANTY INFORMATION:

INSPECTION/REPLACEMENT PROCEDURE:

All Models:
All trim panel attachment clips must be inspected prior to reassembly and replaced if any damage or wear is detected. If NO damage is visible, the clip may be reused.

Always check to make sure that the garnish is properly attached after reinstallation of all interior trim panels.

2005 - 2006 model year Avalon, 2002 - 2007 model year Camry, and 2004 - 2006 model year Solara:
When removing the A pillar garnish panels, replace the plastic attachment clips.







Refer to the table for appropriate part numbers.