Body - Manual Outside Mirror Wind Noise

NVH
NV012-03
REVISED

October 16, 2003

Title:
WIND NOISE: MANUAL OUTER REAR VIEW MIRROR

Models:
'03 Tacoma

TSB REVISION NOTICE:

^ November 27, 2003: Changes made in Warranty Information table.

^ October 17, 2003: The Parts Information table has been removed because the field fix does not require a new service part. The introduction has also been clarified. The previous TSB should be discarded.

Introduction

Some customers may experience a slight wind noise from either side of the vehicle on 2003 model year Tacoma vehicles with manual outside mirrors. The mirror gasket has been modified to improve this condition. Reseal mirror gasket as shown in the following Repair Procedures.

Applicable Vehicles
^ 2003 model year Tacoma vehicles produced BEFORE the Production Change Effective VIN shown below.





Production Change Information





Required Tools & Material





Warranty Information

Applicable Warranty:

This repair is covered under the Toyota Comprehensive Warranty. This warranty is in effect for 36 months or 36,000 miles, whichever occurs first, from the vehicle's in-service date.

* Warranty application is limited to correction of a problem based upon a customer's specific complaint.

Repair Procedure

Please refer to the Technical Information System (TIS) 2003 model year Tacoma Repair Manual: Body (Mechanical), Front Door.

1. Remove the Left Outer Rear View Mirror Assembly.





2. Locate the two pinholes on the mirror weatherstrip.

3. Using the 3M Auto Glass Butyl Sealer, plug the two pinholes.

4. Reassemble in reverse order.

5. Test drive to confirm the noise level.