Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Customer Interest
- A/C - Unpleasant Odors Coming From Vents
- A/C - Unpleasant Musty Odor
- Fuel System - Poor Engine Performance
- A/C Evaporator Blower Motor - Scraping Noises
- A/C Evaporator - Water Leaking From Vents
- Coolant Pump - Leakage, Warning Lamp On, Residue
- Alternator - V Belt Slips Under Load
- Engine Oil Cooler - Leaks into the Cooling System
- Steering Knuckle - Interference With Brake Rotor
- Keys - Lost or Broken
- Vent Window - Sticks to Weatherstrip
- CV Joint - Knocking Noise From Rear
- M/T - Grinds Into 1st/Reverse/Hard Shifting
- ECM - Inoperative Due to Improper Battery Charging
- Engine - Does Not Crank or Battery Repeatedly Discharged
- Alternator - Replacing Loose Mounting Bolts
- Alternator Mounting Bolt - Loose/Broken
- Interior Light - Inoperative
- Radio - Static When Listening to AM Stations
- Oil Dipstick Tube - Loose Fit on Remanufactured Engines
- Coolant Temperature Gauge Light - Flashes
- Speedometer - Noisy
- Rear Lid Latch - Push Button Operation Difficult
- Wiper Blade - Smearing Windshield
- Wiper Blade - Chatter and Skipping
- Wiper Blades - Jerk or Skip Across Windshield
- M/T - Hard Shifting
- Fuel Cut-Off Solenoid - Sticking Plunger
- Engine - Rough Idle, Stalls
- MIL ON - Poor Idle/Stalls, Loss of Power, Exhaust Smoke
- Cruise Control - Does Not Work
- Tires/Suspension - Vehicle Pulls to one side
- Wheels/Tires - Vibrations
- Interior Trim - Dirty/Soiled
- Radio - Causes Excessive Battery Drain
- Carpet - Front Seam Gap
- Instrument Panel - Milky/Spotted
- Final Drive Flange Seal - Leaking Under Car
- Seals, Gaskets
- Superceded Bulletins
- 408902 - 10/31/89
- WARRV9224 - 11/02/92
- V9320 - 09/01/93
- 7093-04 - 11/15/93
- 179002 - 10/31/90
- 008803 - 10/10/88
- Vehicle - Component Nomenclature Revisions
- Speedometer - Replacement, Government Regulations
- Interior Leather Upholstery - Cleaning Tips
- Interior - Fabrics, Vinyls and Plastics, Cleaning Tips
- Restraint System - 'LATCH' System Installation/Retrofit
- Child Restraint - Anchor Installation/Retrofitting
- A/C - Musty Odors
- Electrical Contact Enhancer - Improves Contact Surface
- Brakes - Abnormal Vibration When Braking
- Fuel Tank - Fuel Neutralization After Removal
- Oxygen Sensor - Possible Damage Using Silicone
- Alloy Wheels - Build Up of Road Dirt or Brake Dust
- All Technical Service Bulletins
- A/C - Unpleasant Odors Coming From Vents
- Platform Wiring Harness - Repairing
- Vehicle - Ordering VIN Plates/Safety And Emission Labels
- Electrical Contact Enhancer - Enhances Conductivity
- Electrical - Aftermarket Equipment Installation
- Warranty - Plastic Bags for Electronic Parts Tag
- Fluids and Lubricants - Warranty Reimbursements
- Vehicle - Manufacturing Date Codes of Bosch Components
- Warranty - Replacement Price Estimate Guidelines
- Warranty - Loaner Car Charges, Paint/Corrosion Repairs
- Tools - Special Tool Minimum Requirements
- Overview
- Volkswagen Dealer Minimum Requirement Special Tools
- Volkswagen Dealer Minimum Requirement Test Equipment
- Volkswagen Dealer Minimum Requirement Metric Measuring
- Volkswagen Dealer Minimum Requirement Workshop Equipment
- Volkswagen Dealer Minimum Requirement - Service Information
- Volkswagen/Audi Dealer Minimum Requirement Special Tools
- Volkswagen/Audi Dealer Minimum Requirement Test Equipment
- Volkswagen/Audi Dealer Minimum Requirement Metric Measuring
- Volkswagen/Audi Dealer Minimum Requirement Workshop Equipment
- Volkswagen/Audi Dealer Minimum Requirement Service Information
- Tools - Digital Multimeter (Fluke 83) Introduction
- Engine Control Harness Connector Terminals - Replacing
- Towing - Information for Long Distance and Emergency
- Vehicle - Replacing Bolts And Nuts
- Vehicle - Lubricant Capacities and Type
- Tools - Introducing Power Brake Bleeder Package
- Diesel Engine - Auxiliary Heater New Style Glow Plug
- A/C - Unpleasant Musty Odor
- A/C Refrigerant - Compliance With Enviromental Laws
- Engine - Improvements of Remanufactured Units
- Engines And Short Blocks - Label Information
- Tools - Engine/Transmission Oil Temperature Tester
- Engine - Oil Consumption
- Tools - Support to Remove/Install Engine, Transmission
- Fuel Filter - Installing Water Indicator Kit
- Fuel System - Poor Engine Performance
- A/C Compressor - Repairing Loose Hose Fittings
- A/C Evaporator Blower Motor - Scraping Noises
- A/C Evaporator - Water Leaking From Vents
- Tools - Spring Compressor
- Engine - Attach Pressure Plate or Flywheel to Crankshaft
- Cylinder Head - Modified to Accept 12 mm Bolts
- Cylinder Block - Eliminating Non-Rebuildable Blocks
- Engine Blocks - Plug Installed in Remanufactured Blocks
- Coolant Pump - Leakage, Warning Lamp On, Residue
- Alternator - V Belt Slips Under Load
- Engine Oil Cooler - Leaks into the Cooling System
- Steering Knuckle - Interference With Brake Rotor
- Shock Absorbers - Protection When Undercoating Vehicle
- Wheels/Tires - Size and Lug Application Chart
- Tires - Goodyear Tire And Rubber Toll Free Line
- Wheel Bolt - Standardized Tightening Torque
- Keys - Lost or Broken
- Tires - Aerosol Inflator/Sealer Flammability Hazard
- Vent Window - Sticks to Weatherstrip
- CV Joint - Revised Diagnosis, Inspection and Replacement
- CV Joint - Knocking Noise From Rear
- M/T - When Replacing, Match Flanges to Driveshafts
- Clutch Disc - Revised Lubricant for Installation
- M/T - Grinds Into 1st/Reverse/Hard Shifting
- Fuel Injector - Opening Pressure Requirements
- Injectors - Checking Procedures
- ECM - Inoperative Due to Improper Battery Charging
- Oxygen Sensor - Failure Due to Silicone
- Wheel Brake Cylinder, Rear - Replacement Criteria
- Low Maintenance Batteries - Updated Testing
- Glow Plugs - Avoiding Damage
- Engine - Does Not Crank or Battery Repeatedly Discharged
- Alternator - Replacing Loose Mounting Bolts
- Alternator Mounting Bolt - Loose/Broken
- Tools - Removing and Installing Generator V-Belt Pulley
- Accelerator Cable - Modified
- Exhaust - Sulfur Odor Noticed At the Pipe
- Interior Light - Inoperative
- Radio - Static When Listening to AM Stations
- Warranty - Locked-Up Radio Repair Program
- Radio - Diagnosis Instructions
- Vanity Mirror Bulb - Replacement
- Oil Dipstick Tube - Loose Fit on Remanufactured Engines
- Coolant Temperature Gauge Light - Flashes
- Voltage Stabilizer - Adding Diode To Circuit
- Speedometer - Replacement Procedure, Regulations
- Speedometer - Noisy
- Speedometer - Replacement Guidelines
- Tools - Headlights, Aiming, Hella Beamsetter Series IV
- Cylinder Head - New Sealing Compound Being Used
- Cylinder Head Bolts - Tightening Procedures
- Triple V-Belt Pulley - Removal And Installation
- Upper Control Arm Bushings - Checking
- Rear Lid Latch - Push Button Operation Difficult
- Wiper Blade - Smearing Windshield
- Tools - Windshield Wiper Alignment
- Wiper Blade - Chatter and Skipping
- Wiper Blades - Jerk or Skip Across Windshield
- Electric Mirrors, Outside - Removal and Installation
- Engine - Approved Oil And Additives
- Coolant - Revision
- A/C - Modified Drive Belt, Coolant Hose Clearance
- Tools - Universal Transmission Support 3282
- Tools - New High Lift Transmission Jack
- Warranty - Contact Tech Help Line During A/T Repair
- A/T - Synthetic Oil for Final Drive
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - 010/087/089/090 Bind In Low and Reverse
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Oil Level Change to Reduce Shifting Effort
- M/T - Hard Shifting
- Flywheel Mounting Bolt - Torque Revision
- Flywheel Mounting Bolt - Torque
- M/T - Correct Position of Boot On Shift Rod Bushing
- Tools - Install Air Conditioning Three Groove Pulley
- Fuel Injection Pump - Replacement Instructions
- Injection Pump Center Plug - New Tightening Torque
- Fuel Cut-Off Solenoid - Sticking Plunger
- Engine - Rough Idle, Stalls
- MIL ON - Poor Idle/Stalls, Loss of Power, Exhaust Smoke
- Cruise Control - Does Not Work
- Alignment - Conversion Chart for Specifications
- Tires/Suspension - Vehicle Pulls to one side
- Wheels/Tires - Vibrations
- Seat Belts, Rear - Retrofit Installation
- Interior Trim - Dirty/Soiled
- Radio - Causes Excessive Battery Drain
- Paint Finishes - Restoration
- Carpet - Front Seam Gap
- Instrument Panel - Milky/Spotted
- Axle Shaft Nut and Spacer Sleeve - Changed
- A/C Refrigerant - Capacity Reference Chart
- M/T - Modifications
- A/C Evaporator - Repair
- Refrigerator Unit Air Supply - Modification
- Tools - Power Brake Bleeder
- Final Drive Flange Seal - Leaking Under Car